NHTSA vehicle safety data
1996 Mitsubishi Fuso FE639 Recalls & Complaints
The 1996 Mitsubishi Fuso FE639 has 3 NHTSA recall campaigns on file as of November 3, 2026. try.vin has no NHTSA owner complaints on file for the 1996 Mitsubishi Fuso FE639. Recall repairs are usually free at an authorized Mitsubishi Fuso dealer.
NHTSA recall and complaint data for the 1996 Mitsubishi Fuso FE639. Recall data is refreshed daily from NHTSA.
FMVSS 108/REPLACEMENT HALOGEN HIGH BEAM HEADLAMPS
NHTSA #09E010000 · Exterior Lighting — Headlights · NHTSA notice
Reported March 30, 2009 · MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Potentially affected: 156 vehicles
Mitsubishi Fuso campaign C1003910 · Owners notified April 15, 2009
Defect description
MITSUBISHI FUSO TRUCK OF AMERICA (MFTA) IS RECALLING 156 HALOGEN SEALED BEAM HIGH BEAM HEADLAMP ASSEMBLIES SOLD BETWEEN OCTOBER 24, 2007 AND DECEMBER 2, 2008 FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN MITSUBISHI FUSO TRUCKS. THESE LAMPS FAIL TO CONFORM TO THE SAE STANDARDS OR RECOMMENDED PRACTICES REFERENCED IN TABLE I OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Safety consequence
THE PURPOSE OF THIS STANDARD IS TO REDUCE DEATHS AND INJURIES FROM MOTOR VEHICLE CRASHES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
Manufacturer remedy
MFTA WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 15, 2009. OWNERS MAY CONTACT MFTA AT 1-856-467-4500.
Notes
MFTA'S RECALL NO. C1003910.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
MITSUBISHI FUSO/PARKING BRAKE CABLE
NHTSA #04V571000 · Parking Brake — Conventional — Mechanical — Linkage and Cable · NHTSA notice
Reported December 3, 2004 · MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Potentially affected: 18,094 vehicles
Mitsubishi Fuso campaign C0021610 · Owners notified January 13, 2005 · Vehicles built February 21, 1995 – March 29, 2001 (per NHTSA)
Defect description
ON CERTAIN TRUCKS, THE CABLE END OF THE PARKING BRAKE CABLE, WHERE IT ATTACHES TO THE PARKING BRAKE LEVER, IS DESIGNED IMPROPERLY. REPEATED NORMAL PARKING BRAKE OPERATION MAY CAUSE THE CABLE END TO BECOME IMPROPERLY SEATED IN THE PARKING BRAKE LEVER GROOVE.
Safety consequence
IN THIS CONDITION, THE PARKING BRAKE CABLE MAY BEND AND BREAK DUE TO FATIGUE. THE PARKING BRAKE MAY BECOME INOPERATIVE AND THE TRUCK MAY ROLL AND CAUSE A CRASH, PROPERTY AND PERSONAL INJURIES.
Manufacturer remedy
DEALERS WILL INSPECT THE PARKING BRAKE CABLE FOR BENDING OR DAMAGE AT THE CABLE END AND INSTALL A MODIFIED PARKING BRAKE CABLE ASSEMBLY IF THE CABLE IS BENT OR DAMAGED AT THE CABLE END. IF NO BENDING OR DAMAGE EXISTS, DEALERS WILL INSTALL A CABLE RETAINER ON THE CABLE END OF THE PARKING BRAKE CABLE. THE RECALL BEGAN ON JANUARY 13, 2005. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707.
Notes
MITSUBISHI FUSO RECALL NO. C0021610.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
MITSUBISHI FUSO/TIE ROD END BALL JOINTS
NHTSA #04V535000 · Suspension — Front — Control Arm · NHTSA notice
Reported November 8, 2004 · MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Potentially affected: 10,333 vehicles
Mitsubishi Fuso campaign R3128610 · Owners notified January 13, 2005 · Vehicles built February 21, 1995 – November 6, 1998 (per NHTSA)
Defect description
ON CERTAIN TRUCKS, THE TIE ROD END BALL JOINT DUST BOOT WAS DESIGNED WITH INSUFFICIENT SEALING ABILITY. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER INTO THE TIE ROD END BALL JOINT, ABNORMALLY WEARING THE RESIN BEARING LOCATED INSIDE THE JOINT.
Safety consequence
THE TIE ROD END BALL JOINT COULD SEPARATE FROM THE TIE ROD END, DISABLING THE STEERING SYSTEM, AND CAUSING A CRASH .
Manufacturer remedy
DEALERS WILL INSTALL MODIFIED TIE ROD END ASSEMBLIES. THE RECALL BEGAN ON JANUARY 13, 2005. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 856-467-3917.
Notes
MITSUBISHI FUSO RECALL NO. R3128610.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Other Mitsubishi Fuso FE639 model years
Check your 1996 Mitsubishi Fuso FE639 VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Mitsubishi Fuso FE639 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Mitsubishi Fuso VIN