NHTSA vehicle safety data

2001 Mercury Cougar Recalls, Ratings & Complaints

The 2001 Mercury Cougar has 3 NHTSA recall campaigns and 82 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Mercury dealer.

NHTSA recall and complaint data for the 2001 Mercury Cougar, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Mercury Cougar owner complaints

Owners have filed 82 complaints with NHTSA about the 2001 Mercury Cougar, describing incidents dated March 24, 2001 to May 1, 2020.

Most-cited components

Fuel/Propulsion System 26 complaints
Electrical System 12 complaints
Engine 12 complaints
Power Train 10 complaints
Visibility/Wiper 7 complaints
Air Bags 6 complaints

Of the 82 complaints on file, 7 report a crash and 6 a fire; across all 82 complaints, owners report 5 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11350028 · Filed August 18, 2020
TL* THE CONTACT OWNS A 2001 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE FAILED TO START-UP AFTER MULTIPLE ATTEMPTS. THE CONTACT ALSO STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHUTOFF AS THE OIL WARNING LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT HAD TAKEN…
ODI #11342354 · Filed July 30, 2020
TL* THE CONTACT OWNS A 2001 MERCURY COUGAR. THE CONTACT STATED THAT ONCE THE FUEL LEVEL REACHED A HALF TANK OF GASOLINE, THE VEHICLE HESITATED AND LOSS MOTIVE POWER WITH THE ACCELERATOR PEDAL DEPRESSED. THE CONTACT STATED THAT THE TRANS AXLE AND CHECK ENGINE WARNING LIGHTS WERE ILLUMINATED. COLUMBIA…
ODI #11321151 · Filed April 14, 2020
BATTERY LIGHT IS ON AND HAS FOR AWHILE. LIGHTS KEEP BLOWING FUSES. AND TODAY I HAD TO RIP OUT A HEADLIGHT OR THE CAR WOULD HAVE SET ON FIRE. *TR

Read all 82 complaints

AFTERMARKET BALL JOINT ASSEMBLIES

NHTSA #08E033000 · Suspension · NHTSA notice

Reported April 14, 2008 · FEDERAL-MOGUL CHASSIS PRODUCTS

Potentially affected: 6,903 vehicles

Owners notified May 22, 2008

Defect description

FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.

Safety consequence

THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET BALL JOINT ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

BRAKE HYDRAULIC MASTER CYLINDER

NHTSA #06E022000 · Service Brakes, Hydraulic · NHTSA notice

Reported March 13, 2006 · BRAKE PARTS, INC.

Potentially affected: 7,440 vehicles

Owners notified March 20, 2006

Defect description

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Safety consequence

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Manufacturer remedy

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET NAPA, RAYBESTOS, AC DELCO, AIMCO, CARQUEST, AND BENDIX BRAKE HYDRAULIC MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FORD/FUEL DELIVERY MODULE

NHTSA #04V421000 · Fuel System, Gasoline · NHTSA notice

Reported August 30, 2004 · FORD MOTOR COMPANY

Potentially affected: 88,600 vehicles

Manufacturer campaign 04N02 · Owners notified April 16, 2004 · Vehicles built May 25, 1999 – November 30, 2001 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.

Safety consequence

THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Notes

FORD RECALL NO. 04N02.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2001 Mercury Cougar 2-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Crash

Not Rated

Driver: 3, Passenger: 3

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

82 owner complaints have been filed with NHTSA for the 2001 Mercury Cougar.

Fuel System, Gasoline

ODI #11350028

Incident: May 1, 2020 · Filed: August 18, 2020

TL* THE CONTACT OWNS A 2001 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE FAILED TO START-UP AFTER MULTIPLE ATTEMPTS. THE CONTACT ALSO STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHUTOFF AS THE OIL WARNING LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT HAD TAKEN THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE FUEL SENSOR, RELAY SENSOR, FUEL INJECTION SENOR AND MULTIPLE OTHER PARTS WERE REPLACED. DESPITE MULTIPLE REPAIRS TO THE VEHICLE, THE FAILURE PERSISTED. THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE AND THEY INFORMED HER THAT HER VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V421000 (FUEL SYSTEM, GASOLINE) WHICH WAS LINKED TO HER FAILURE. A DEALER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 116,000.

Fuel System, Gasoline

ODI #11342354

Incident: March 1, 2019 · Filed: July 30, 2020

TL* THE CONTACT OWNS A 2001 MERCURY COUGAR. THE CONTACT STATED THAT ONCE THE FUEL LEVEL REACHED A HALF TANK OF GASOLINE, THE VEHICLE HESITATED AND LOSS MOTIVE POWER WITH THE ACCELERATOR PEDAL DEPRESSED. THE CONTACT STATED THAT THE TRANS AXLE AND CHECK ENGINE WARNING LIGHTS WERE ILLUMINATED. COLUMBIA FORD LINCOLN HYUNDAI (700 7TH AVE, LONGVIEW, WA 98632) WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE MANUFACTURER WAS CONTACTED AND NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.

Electrical System; Exterior Lighting; Fuel/Propulsion System

ODI #11321151

Fire

Incident: April 14, 2020 · Filed: April 14, 2020

BATTERY LIGHT IS ON AND HAS FOR AWHILE. LIGHTS KEEP BLOWING FUSES. AND TODAY I HAD TO RIP OUT A HEADLIGHT OR THE CAR WOULD HAVE SET ON FIRE. *TR

Electrical System; Exterior Lighting; Service Brakes

ODI #11321150

Incident: April 8, 2019 · Filed: April 14, 2020

WELL HEADLIGHT WIRING HARNESS IS DRY ROTTED LIKE CRAZY THE CAR LOOSES POWER WHILE EXCELERATING WHEN BELOW 3/4 OF A TANK BRAKE FLUID/CLUTCH FLUID IS LEAKING DON'T KNOW WHY AND THE BATTERY LIGHT IS ON

Structure

ODI #10993568

Incident: March 15, 2017 · Filed: June 6, 2017

THE SUNROOF JUST RELEASED FROM THE CAR IN THE MIDDLE OF I71 DOING 65MPH AND I AM NOT THE ONLY PERSON WHO HAS HAD THIS PROBLEM WITH THIS MODEL OF COUGAR

Electrical System

ODI #10956249

Incident: August 13, 2016 · Filed: February 22, 2017

TL* THE CONTACT OWNS A 2001 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY. IN ADDITION, WHILE DRIVING, THE VEHICLE STALLED, THE BATTERY WARNING INDICATOR ILLUMINATED, AND THE INSTRUMENT PANEL GAUGES FLICKERED. THE BATTERY WAS REPLACED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 129,000.

Fuel/Propulsion System

ODI #10944316

Incident: January 10, 2017 · Filed: January 11, 2017

TL* THE CONTACT OWNS A 2001 MERCURY COUGAR. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE DECELERATED AND STALLED WITHOUT WARNING. THE CONTACT, WITH THE HELP OF OTHER DRIVERS, HAD TO PHYSICALLY PUSH THE VEHICLE OUT OF TRAFFIC TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MOTOR BURNED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

Vehicle Speed Control

ODI #10883481

Incident: June 23, 2016 · Filed: July 8, 2016

OVER PAST FEW WEEKS LOOSING ACCELERATION ESPECIALLY ON INCLINES AND HIGHWAY ENTRANCE RAMPS CAUSING NEAR COLLISSION AS I CAN'T SPEED UP TO HIGHWAY SPEED AND CAR BEHIND ME MUST BRAKE AT FAST SPEEDS. ENGINE LIGHT ON. MECHANIC SAYS CAN'T FIX AND CONTACT FORD. MY VIN # DOES NOT BRING UP RECALL BUT IT MATCHES RECALL NOTICE SUMMARY STATING CONTAMINATION OF FILTER IN FUEL DELIVERY MODULE (FDM) THI RECALL STATE 1999-2002 COUGARS.MINE IS 2001 BOUGHT NEW, UNDER 70,000 MI WITH NEW FUEL PUMP. THIS HAS BEEN GOING ON FOR WEEKS AND SCARED TO DRIVE MY ONLY CAR. PLEASE HELP.

Engine; Fuel/Propulsion System

ODI #10883445

Incident: June 23, 2015 · Filed: July 7, 2016

TL* THE CONTACT OWNS A 2001 MERCURY COUGAR. WHILE DRIVING 45 MPH, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE ENGINE CHECK WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL DELIVERY MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V421000(FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 59,800.

Engine and Engine Cooling; Fuel/Propulsion System

ODI #10706169

Incident: April 1, 2015 · Filed: April 16, 2015

CAR STARTED HESITATING AND LOST POWER THEN STALLED OUT CAUSING TRAFFIC TO GET BACKED UP. *TR

Other Mercury Cougar model years

Check your 2001 Mercury Cougar VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Mercury Cougar at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Mercury VIN