1999 Mercedes Benz ML430 Recalls & Complaints

Incident: December 11, 2013 · Filed: December 31, 2013

DECEMBER 11, 2013 I WAS DRIVING HOME FROM WORK MY BENZ QUIT ON ME IN THE ROAD WOULD NOT START BACK (MY HOME IS WITHIN 2 MILES OF MY WORK) THE DAY BEFORE IT HAD QUIT AS I WAS MAKING A TURN BUT RESTARTED A COUPLE OF DAYS PRIOR I HAD THE CAR WARMING AND IT SHUT OFF WHILE WARMING UP BUT RESTARTED. THERE WAS NO LIGHTS ON THE INSTRUMENT DASH PANEL LIT OR STAYING LIT. AFTER SOME INTERNET INVESTIGATING I ASSUME IT WAS THE CRANKSHAFT POSITION SENSOR AS IT HAD ALL THE SIGNS THAT OTHERS HAVE HAD I PURCHASED ONE FOR THE REPAIR SHOP TO INSTALL. THEY HAVE INSTALLED IT BUT BELIEVE THERE IS A PROBLEM WITH THE CRANKSHAFT SO I AM NOT CURRENTLY DRIVING IT. I AM AFRAID TO DRIVE IT WITH IT QUITTING WITHOUT ANY TYPE OF WARNING. MY BENZ HAS LESS THAN 65K I DON'T HAVE THE CURRENT MILEAGE WITH ME AT THIS TIME BUT IF IT IS NEEDED PLEASE LET ME KNOW. *TR

Incident: April 19, 2013 · Filed: April 24, 2013

AFTER EXITING THE FREEWAY I NOTICED A LOUD EXHAUST SOUND COMING FROM UNDERNEATH THE CAR. AFTER PULLING OVER IOOKED UNDERNEATH THE CAR ANT THE FRONT DRIVER'S SIDE CATALYTIC CONVERTER SPLIT IN HALF ALONG THE WELDS. *TR BASICALLY, THE EXHAUST IS VENTING DIRECTLY TO THE OPEN AIR WITHOUT GOING THROUGH THE EMISSION SYSTEM. THE LEFT SIDE EXHAUST NOT HOLDING TOGETHER CORRECTLY. I THEN FOUND THAT MY CAR HAS A MANUFACTURER DEFECT: MERCEDES-BENZ USA, LLC AND DAIMLERCHRYSLER AG SETTLEMENT (EPA) AFFECTED VEHICLES: THE FOLLOWING VEHICLES HAVE BEEN RECALLED TO INSPECT AND REPLACE, IF NECESSARY, THE CATALYTIC CONVERTER: 1999-2001 MERCEDES BENZ ML 320 (VIN RANGE A036519-A260405) 1999 -2001 MERCEDES BENZ ML 430 ( VIN RANGE A057639-A260575) THERE IS NO MILEAGE LIMIT OR TIME LIMIT FOR THIS REPAIR/REPLACEMENT. I AM AN OWNER OF THE AFFECTED VEHICLE BUT THE DEALER WILL NOT FIX THE PROBLEM. HOW DO I PROCEED TO GET THIS VIOLATION REPAIRED? CAN YOU PLEASE POINT ME IN THE RIGHT DIRECTION? THIS IS A HEALTH/SAFETY ISSUE. THANK YOU, SCOTT

Incident: October 20, 2011 · Filed: November 2, 2011

THE BRAKELINES RUSTED THROUGH CAUSING A COMPLETE LOSS OF FLUID AND THE ABILITY TO STOP THE CAR. *TR

Incident: September 15, 2010 · Filed: September 22, 2010

TL* THE OWNS A 1999 MERCEDES-BENZ ML 430. THE CONTACT STATED WHILE DRIVING 25 MPH THE CATALYTIC CONVERTER STARTING MAKING A NOISE AND LEAKING. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC AND THE MECHANIC NOTICE THE WELDING WAS CRACKING. THE MECHANIC PULLED UP A RECALL AND SUGGESTED THE CONTACT TAKE THE VEHICLE TO THE DEALER. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR THE RECALL REMEDY REPAIR AND THE DEALER STATED DUE TO THE VIN NUMBER, THE VEHICLE IS NOT INCLUDED IN THE RECALL. THE DEALER SUGGESTED TO THE CONTACT THAT HE CALL MANUFACTURER. THE CONTACT CALLED THE MANUFACTURER AND THEY INFORMED THE CONTACT THEIR IS NOTHING THEY CAN DO AND THE RECALL CAMPAIGN IS CLOSED. THE CONTACT STATED THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE RECALL. THE FAILURE MILEAGE WAS 98,000.

Incident: July 14, 2010 · Filed: July 28, 2010

TL* THE CONTACT OWNS A 1999 MERCEDES BENZ ML430. WHILE DRIVING AT 25 MPH, THE CONTACT HEARD A LOUD, UNUSUAL POP. THE CONTACT STATED THE VEHICLE SOUNDED SIMILAR TO A LOUD MOTORCYCLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE TWO FRONT CATALYTIC CONVERTERS WOULD NEED TO BE REPLACED. THERE WAS NOT A RECALL FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 131,700 AND THE CURRENT MILEAGE WAS 132,000.

Incident: April 5, 2010 · Filed: April 9, 2010

TL* THE CONTACT OWNS 1999 MERCEDES ML-430. THE CONTACT STATED THERE WAS OIL LEAKING FROM THE LED REAR VIEW MIRROR, FILTERING THROUGH THE MIRROR AND CAUSING VISIBILITY DIFFICULTIES. IN ADDITION, THE OIL WAS LEAKING INTO THE VEHICLE INTERIOR CORRODING THE STEERING WHEEL AND DASHBOARD. THE CONTACT FELT THE FAILURE WAS A SAFETY ISSUE BECAUSE IT WAS AFFECTING HER LINE OF SIGHT. THE FAILURE MILEAGE WAS 57,000 AND THE CURRENT MILEAGE WAS 57,000.

Incident: April 20, 2008 · Filed: October 3, 2009

THE CHECK ENGINE LIGHT CAME ON AND I TOOK IT TO THE MERCEDES DEALER. I WAS TOLD THAT MY FUEL TANK SENSOR IS BROKEN AND IT NEEDS TO BE REPLACED. MERCEDES DEALERS SELL THE FUEL TANK SENSOR WITH THE FUEL TANK AS ONE UNIT. THEREFORE THE COST OF REPLACEMENT IS ENORMOUS. IN ADDITION AFTER RESEARCHING THIS ISSUE. I HAVE FOUND THAT COMPLAINTS FOR THE ML MODELS AND THE FUEL TANK IS NUMEROUS AND WORTH NOTICING. THIS DEFECT HAS OCCURRED IN THE MAJORITY OF MERCEDES ML MODELS AND THE DEALER ACTUALLY HAS A HUGE INVENTORY OF FUEL TANKS IN ORDER TO PROFIT FROM THIS DEFECT. NOT ONLY IS IT DANGER BUT IT CAUSES A HEADACHE FOR CONSUMERS FOR FAIL THE EMISSIONS TEST BECAUSE OF THE CHECK ENGINE LIGHT AND THE SHEER COST OF REPAIR. *TR

Incident: March 21, 2009 · Filed: April 2, 2009

TL*THE CONTACT OWNS A 1999 MERCEDES BENZ ML430. WHILE DRIVING IN REVERSE AND FORWARD AT 25 MPH, THE CONTACT HEARD A CLICKING SOUND UNDERNEATH THE CENTER OF THE VEHICLE. HE ASSUMED SOMETHING WAS LOOSE UNDER THE VEHICLE AND DROVE TO THE DEALER. THE DEALER NOTICED THAT THE FRONT DRIVESHAFT BEARING WAS LOOSE. AFTER REPAIRING THE SHAFT, THE DEALER DISCOVERED THAT THE TRANSFER CASE WAS ALSO CAUSING THE ISSUE. THE CONTACT FEELS THAT THE MANUFACTURER SHOULD REPAIR THE VEHICLE BECAUSE THE OWNER'S MANUAL DOES NOT STATE ANYTHING ABOUT REPAIRING THE TRANSFER CASE. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE CURRENT MILEAGE WAS 115,000 AND FAILURE MILEAGE WAS 85,000. UPDATED 04/13/09.*JB THE CONSUMER HAD TO PAY$ 3850 FOR A NEW TRANSFER CASE. UPDATED 06/15/09.*JB

Incident: December 20, 2008 · Filed: January 6, 2009

TL*THE CONTACT OWNS A 1999 MERCEDES BENZ ML430. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08V465000 (STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS). THE DEALER STATED THAT THE POWER STEERING PUMP WAS PREVIOUSLY DAMAGED TO A LOSS OF POWER STEERING FLUID OVER TIME. THE POWER STEERING PUMP WOULD COST $1,050 TO REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER DID NOT ASSIST. THE FAILURE AND CURRENT MILEAGES WERE 93,000.

Incident: December 16, 2008 · Filed: December 22, 2008

TL*THE CONTACT OWNS A 1999 MERCEDES BENZ ML430. AFTER HAVING THE VEHICLE REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 2003040005, THE FAILURE OCCURRED WHILE DRIVING 65 MPH ON THE HIGHWAY. THE CONTACT WAS UNABLE TO TAKE THE VEHICLE TO THE DEALER BECAUSE IT WAS 60 MILES AWAY. AN INDEPENDENT MECHANIC REPAIRED THE VEHICLE ACCORDING TO THE RECALL AGAIN. WHILE ATTEMPTING TO RECEIVE REIMBURSEMENT FOR THE REPAIRS, THE MANUFACTURER STATED THAT THE VEHICLE WAS NEVER REPAIRED AT AN AUTHORIZED DEALER FOR THE REPAIRS. THE CONTACT HAS ALL THE DOCUMENTS STATING THAT THE VEHICLE WAS REPAIRED BY THE DEALER. THE RECALL NUMBER WAS INACCURATE AND THE EXACT FAILURE WAS UNKNOWN. THE FAILURE MILEAGE WAS 139,212.