2001 Mercedes Benz ML320 Recalls & Complaints

Incident: May 18, 2026 · Filed: June 18, 2026

The failed component is the YAW rate sensor, original part number A1635426340 (ATE part number 10.0980-0454.2), manufactured by ATE. I have experienced multiple incidents of sudden, unintended braking at highway speeds. These events occurred without warning and created an immediate and significant risk of a serious collision, endangering not only myself and my family but also other motorists sharing the roadway. While the defect has not been reproduced or confirmed by either a Mercedes-Benz dealer or an independent repair facility, the absence of a successful diagnosis does not diminish the seriousness of the safety hazard. In fact, your agency opened an investigation into this issue in 2007, yet no corrective action was ultimately taken despite reports indicating that more than 100,000 vehicles may have been affected. According to publicly available information, Mercedes-Benz inspected and evaluated the YAW rate sensor in May 2007 as part of its review of this issue. The continued occurrence of sudden, unintended braking events raises concerns that the underlying defect may not have been fully addressed. Most concerning is that there were no warning lamps, fault messages, or other observable symptoms prior to the braking events. The vehicle operated normally until the moment the unintended braking occurred, leaving the driver with no opportunity to anticipate or prevent a potentially catastrophic situation.

Incident: December 27, 2024 · Filed: December 30, 2024

The contact owns a 2001 Mercedes-Benz ML320. The contact stated that the front passenger’s door failed to open more than 6 inches. The contact stated that no warning lights were illuminated. The vehicle was not taken to a dealer or independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Incident: May 15, 2021 · Filed: May 19, 2021

The contact owns a 2001 Mercedes Benz ML320. The contact stated that when they entered their vehicle and turned it on, the vehicle's passenger front door air bag made a sudden boom sound and then deployed. The contact stated that there were no warning lights. The contact had not taken the vehicle to the dealer. The manufacturer was not made aware of the failure. The approximate failure mileage was 132,000.

Incident: March 13, 2020 · Filed: March 14, 2020

AIR BAG OFF, PEDAL CONTROL SISTEM IS IN RECALL FROM MARCH 31 2011, SMOKE PASS BELONG TO NISSAN MENDOZA AUTO GROUP SOLD THIS CAR IN CA CAR IN RECALL DON'T PASS SMOKE, THEY SAID YES...PASS, PLEASE INVESTIGATION

Incident: September 1, 2019 · Filed: January 22, 2020

ECM IS MALFUNCTIONING AND NOT CONTROLLING FUEL INJECTION AND GIVING RANDOM MISFIRE ON CYLINDERS 2, 3, 4, 5, 6. CAUSING CHECK ENGINE LIGHT TO COME ON . CODES 0300, 0302,0303,0304,0305,0306.

Incident: December 30, 2019 · Filed: January 19, 2020

MY CAT BRAKE WOULD STOP CAR ROLL OVER

Incident: December 23, 2019 · Filed: January 8, 2020

THE FRONT BRAKE SYSTEM ON MERCEDES BENZ ML320 LOCKS UP WHILE DRIVING.

Incident: August 7, 2019 · Filed: August 19, 2019

TL* THE CONTACT OWNS A 2001 MERCEDES-BENZ ML320. ON TWO OCCASIONS, WHILE DRIVING APPROXIMATELY 45 MPH AND 60 MPH, THE VEHICLE SLOWED DOWN INDEPENDENTLY AND CAME TO AN ABRUPT STOP. THERE WAS NO CRASH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE YAW RATE SENSOR WAS DEFECTIVE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED VIA EMAIL. THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.

Incident: July 17, 2019 · Filed: July 27, 2019

STEERING FLUID LEEKS.THERE IS A HOLE IN THE TANK.THE STEERING IS VERY HARD.

Incident: May 14, 2019 · Filed: May 24, 2019

WHILE DRIVING ON HIGHWAY THE CAR BRAKES COME ON AUTOMATICALLY WITHOUT TOUCHING THE BRAKES, IT HAPPENED FEW TIMES, THE CAR HAS TO COME TO STOP, VERY DANGEROUS SITUATION