2026 Mazda CX-90 Recalls, Ratings & Complaints

Incident: October 29, 2026 · Filed: October 30, 2026

While driving the vehicle, the entire instrument cluster repeatedly turns off and "reboots". All warning lights appear, gauge needles drop to zero, then it all turns back on to normal operation. This has happened intermittently since purchasing the vehicle new. Currently has 1150mi

Incident: September 3, 2026 · Filed: October 23, 2026

The contact owns a 2026 Mazda CX-90. The contact stated that while the vehicle was parked, there was a strong gasoline odor inside and outside the vehicle. The odor was strong enough that the contact and other passengers were often nauseated. The vehicle was taken to the dealer, where the failure was confirmed and associated with the EVAP system. The contact was informed that a service case needed to be opened, and the contact was referred to the dealer for additional assistance. The part was scheduled to be ordered but was on backorder. The manufacturer was made aware of the failure by email, and a case was opened.

Incident: September 20, 2026 · Filed: October 22, 2026

The contact owns a 2026 Mazda CX-90. The contact stated that while driving, the instrument cluster rebooted, causing warning lights and messages were displayed and then immediately went to a blank screen and was reset to zero before self-correcting. The contacted stated that the failure had occurred on several occasions. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The failure mileage was 300.

Incident: September 18, 2026 · Filed: October 19, 2026

Incident #1 Upon startup vehicle did not have power steering. Power steering light was on gauge cluster, ready light was flashing on the dash, could not shift from park (have video of failure). Ongoing Incident: Incident has been ongoing since 300 miles- while driving all lights come on the dash and the gauge cluster shuts down, windshield wipers come on and then gauge cluster starts back up, all while going about 45mph. has occurred 4+ times. Vehicle has been in and out of service - total 26 days in service and is where it presently sits.

Incident: July 21, 2026 · Filed: October 2, 2026

While traveling approximately 70–80 mph on a heavily traveled interstate with significant commercial truck traffic, the vehicle suddenly stopped responding normally to accelerator input. I pressed the accelerator pedal fully multiple times, but the vehicle would not accelerate. I was traveling with my mother and young child and was able to safely move the vehicle to the shoulder. After shutting the vehicle off and restarting it, a high-voltage battery temperature warning briefly appeared on the instrument display for several seconds and then disappeared. The vehicle was subsequently taken to an authorized Mazda dealer for inspection. Mazda and the dealer performed diagnostic testing, system updates, and extensive road testing, but advised that they were unable to duplicate the original incident and that no related diagnostic trouble codes were stored. We have not been provided with a specific root cause for the loss of accelerator response. No crash or injury occurred. I am reporting this incident because an unexpected inability to accelerate while traveling at highway speed could create a serious safety risk if the condition occurs again.

Incident: September 20, 2026 · Filed: September 25, 2026

Component: Instrument cluster/dash electrical system, with linked wiper activation. 2026 Mazda CX-90, VIN [XXX]. Vehicle available for inspection. Safety risk: While driving, warning icons flood on (amber, sometimes a large red brake/emergency-stop icon) for 2-5 seconds, with an unrequested single wiper pass. Speedometer, gear indicator, and MPG stay active. On this occurrence, the malfunction happened twice in immediate succession — as soon as the reset resolved, it recurred within about one second, which has not happened before. This occurred with 3 passengers in the vehicle during a road trip. The icon flood obscures whether a real emergency warning is present, at speeds ~45 mph. Also occurs up to 65mph highway speeds. Reproduced by dealer: No — dealer (Southern States Mazda) held vehicle 3+ weeks, drove it only ~6 miles, closed as "not replicated." Dealer staff said another local CX-90 owner has the identical issue and is filing a lemon law claim. Inspected by others: 3 dealer visits (16 business days out of service). Reviewed by Mazda corporate case manager (Case #[XXX], opened April 2026) via logs, photos, video. No police/insurance inspection — no accident occurred. Warning signs prior to failure: None — malfunction is sudden, no advance indicator. First occurred [XXX] at ~1,700 miles. Separately, 3 times since [XXX]: on startup, steering wheel warning lights up, i-ACTIVSENSE READY flashes, vehicle won't shift out of Park despite brake pedal depressed, and the AC fails to engage every time this occurs. 49+ confirmed occurrences as of 9/25/2026. Incident log (mileage, speed, pass #) and photo attached. Video of both malfunction types available. This is 1 of 49+ confirmed recurrences since 3/4/2026 (Mazda Case #[XXX], opened 4/2026, unresolved). Dealer held vehicle 3+ weeks, drove only ~6 miles, closed as "not replicated." Dealer staff confirmed another local CX-90 owner has the identical issue and is filing a lemon law claim. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 4, 2026 · Filed: September 20, 2026

My boyfriend and I rented the car from Hertz Car Rental in [XXX] on Labor Day weekend. Within moments of driving the car off the lot, the safety camera system stopped working and the lights came on saying they weren’t working. The touch screen also started glitching and intermittently working but we didn’t think too much about it. We started driving across the state to [XXX] and made it about 4 hours away from [XXX] when the car started making a noise like a marble in a tin can, lost power, started shaking, and could not make it up hills at a safe speed. The check engine light came on. We pulled over and popped the hood to find a lot of rat feces scattered all over the engine bay, some of it looked fresh and some was turning white telling us it was there for a while. We called the Hertz rental roadside assistance who could not help us as they rented out all of their cars for the weekend and our only options were to tow us back to [XXX] without a replacement car or try to continue driving it the 1 hour to our destination. We continued to drive the car as we did not have anywhere else to stay and were in the middle of nowhere. We drove the car slowly to our destination but it did keep making the noise and shaking although the check engine light went out. When I got out of the car, I noticed a raw gas oder which worried me. I called my dad who works on cars and he told me not to drive it any farther as it could be a serious safety risk as the rats likely have been chewing wires and hoses and there could be a fire risk. We were also breathing the rat feces in our whole trip unknowingly. We called for the car to be towed and paid to rent another from another company. Since then, we have not gotten any money back and they continue to charge us daily for the car saying we must return it, meaning they have no record of where there car is even though we watched it be towed away and talked to the driver who said he was taking it to the Grand Junction Airport. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 11, 2026 · Filed: September 15, 2026

I am reporting a fuel odor concern with my Mazda CX-90. After driving the vehicle and pulling it into my attached garage, I noticed a strong gasoline/fuel smell coming from the vehicle. I reported this to the Mazda dealership's service department. They told me Mazda is aware of the fuel smell for several years now and that it is coming from the EVAP system/canister. They explained that the EVAP system has openings that allow it to vent and that this venting is causing the fuel smell. The service department told me they have contacted Mazda corporate about this issue in the past. According to them, Mazda's response is that [XXX] and [XXX] are considered "extreme climates" due to the heat, and Mazda has not provided a repair or modification for the issue. The dealership advised me to park the vehicle outside for approximately 10 minutes after arriving home before putting it in my garage. They said this allows the fuel smell/vapors to dissipate outside instead of entering the garage or home and creating a potential fire hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: August 7, 2026 · Filed: August 12, 2026

On multiple occasions, the steering wheel became stiff or locked while driving or during start-up, multiple dashboard warning lights illuminated, and the vehicle could not be shifted from Park to Drive. This occurred repeatedly since the vehicle was purchased. The dealer inspected the vehicle multiple times; on the first attempts they could not duplicate the issue. On a later visit, the vehicle displayed a lost communication fault with the electric power steering (EPS) system, and the dealer replaced the steering gear/rack assembly and EPS motor per the manufacturer’s technical hotline instructions. Despite this part replacement, the same steering/warning light condition recurred weeks later. At that point the dealer confirmed the defect but stated there is currently no authorized repair or parts replacement available, and that engineering is developing a permanent corrective action. The vehicle remains in my possession and is available for inspection. This defect creates a serious safety risk because the vehicle cannot be steered or shifted normally when the condition occurs, including while driving. No crash or injury has occurred to date.”

Incident: July 29, 2026 · Filed: August 3, 2026

While driving approximately 50 mph, we heard a sudden, extremely loud bang, followed immediately by the sound of shattering glass. We pulled over and discovered that the panoramic sunroof had shattered and appeared to have exploded outward. There was no collision, no object that we saw strike the vehicle, and no warning before the failure. The glass remained largely in place but was completely fractured. This occurred while my family was in the vehicle, including my young children. The sudden explosion startled the driver and created a potentially dangerous driving situation. I am concerned that a spontaneous sunroof failure at highway speeds could cause a driver to lose control of the vehicle or result in injuries from flying glass. I am reporting this because I believe it represents a serious safety issue that should be investigated to determine whether this is a manufacturing defect or other vehicle safety problem.