2025 Lexus TX Recalls & Complaints

Incident: September 27, 2026 · Filed: October 3, 2026

My 2025 Lexus TX 500h has experienced an intermittent loss of acceleration from a stop approximately four times. The most recent incident occurred on September 27, 2026, at approximately 25,000 miles. At the time of the incident, the vehicle was in Eco mode. The engine had been started approximately five minutes earlier. I drove through a parking lot that is on a slight incline and came to a complete stop at a stop sign where the parking lot exits onto a public road. When I attempted to make a left turn onto the roadway, I pressed the accelerator, but the vehicle would only move at approximately creep speed. I pressed the accelerator further, including fully depressing the accelerator pedal, but the vehicle still did not accelerate normally. This condition lasted for approximately 15 seconds. After that, power gradually returned and the vehicle began accelerating normally. There were no warning lights or warning messages during the incident. Because this occurred while I was attempting to turn left and enter normal roadway traffic, the unexpected lack of acceleration created a significant safety concern due to approaching traffic. The vehicle operated normally afterward. Because the condition is intermittent and has occurred only a few times, it may be difficult to reproduce during a dealership inspection. I am reporting this because the unexpected loss or significant delay of acceleration from a stop, particularly when entering traffic, presents a potential safety hazard.

Incident: September 14, 2026 · Filed: September 15, 2026

I am reporting a severe, systemic vehicle performance discrepancy on my 2025 Lexus TX 350h (2.4L Turbo Hybrid powertrain). The vehicle is officially labeled with an EPA rating of 23 MPG combined. However, under normal, conservative driving conditions, the vehicle routinely achieves only 17-17.7 MPG—a consistent 26%+ shortfall from the manufacturer's certified window sticker metrics. I have never gotten EPA higher than 17.7 since owning the new car. This has drastically limited the vehicle's safe total driving range to under 300 miles per tank. The shortfall persists despite cautious driving in Eco Mode and after passing the engine break-in period. This issue matches a widespread pattern reported by numerous other owners in consumer forums, pointing to a potential defect in the vehicle’s fuel management software or hybrid battery management logic. I request that NHTSA log this tracking data to investigate whether the manufacturer misrepresented the vehicle's real-world operational capabilities or fuel-system integration. I have a separate compliant #11762922 open for extreme safety concern related to visible gas vapors and overpowering health concerning gasoline smell at times which have occurred 5 times that I have recorded; unsure if this issue is related. Please investigate all the Lexus TX and Toyota Grand Highlander formal NHTSA complaints, Lexus Tickets, Technical Service Bulletin requests, and the previous Lexus Service repair for fuel leaking being a fire hazard - the fix was a fuel tank protector under Service Campaign #25LC05. My car had this protector installed; ironically there were no incidents of the gas smell & visible vapors until AFTER the service campaign and install of the fuel protector; coincidence or not. It seems highly probably that the following 4 issues are related on these cars: 1) fuel leaking/protector installed 2) gas mileage off 3) Visible gas vapors 4) strong gas smell. Please act before someone gets hurt. This is a family car w kids.

Incident: September 8, 2026 · Filed: September 8, 2026

I am reporting a recurring potential fuel-system/EVAP safety issue with a 2025 Lexus TX 350 (same as Toyota Grand Highlander). On FIVE separate occasions (May, 6/27, July, 8/14, and 9/8/2026), I experienced an overwhelming raw gasoline odor associated with visible vapors coming from the fuel-filler/gas-cap area. Three incidents occurred after refueling; the two most recent occurred WITHOUT recent refueling and with less than half tank full. On 8/14, with temps in the 90s and approximately 135 miles to empty, I drove 30–40 miles, idled approximately 45 minutes, then drove another 10 miles. The overwhelming gasoline odor and visible vapors occurred again. On 9/8, at approximately 108F and with 152 miles to empty, I drove 46 miles, idled 27 minutes, then drove another 10 miles. The overwhelming raw gasoline odor and visible vapors again came from the fuel-filler area. A strong gasoline odor was also present underneath/around the driver's-side rear wheel well, but not around the passenger-side rear wheel. This recurring release of gasoline vapors presents a potential fire and occupant/public safety concern because gasoline vapors are flammable. I have kept the vehicle outside after incidents rather than parking it in an enclosed garage near an ignition source. The vehicle is available for inspection. The vehicle was previously inspected by an authorized Lexus dealer for this same concern, and Lexus Brand Engagement opened a case and technical-assistance ticket. The dealer reported no fuel leak and deemed the vehicle safe to drive but did not reproduce the condition. The vehicle was driven only approximately 3 miles at the dealership under different conditions. The problem has since recurred multiple times. There have been NO warning lights or dashboard messages. The repeated visible vapors and overwhelming raw gasoline odor during normal operation raise concerns about a potentially unsafe fuel/EVAP system malfunction.

Incident: June 6, 2025 · Filed: August 23, 2026

When starting from a stop, putting foot on the gas pedal the car won’t move. Hesitates for a longtime. It has happened numerous times since purchased new. The manufacturer stated that engineering is looking into it, with no definitive answers. No warning lights. It just won’t go, at times which is a safety concerning especially when crossing with oncoming traffic. Unresponsive.

Incident: July 10, 2026 · Filed: August 17, 2026

We have had 2 windshields crack on the Lexus TX350, with very low impact to the windshield by very small road debris. Both windshields require(d) replacement due to long migrating cracks. There are several issues with the windshields on the TX350 per online searches. The windshields are a laminated acrylic one that are prone to cracks requiring replacement. This is a common issue on the TX350. The windshields are on long back orders for a genuine Lexus part. We are having our second windshield replaced on XXX at the Lexus dealer. I am of the opinion that this issue should be looked into by NHTSA for a potential recall and improved manufacturing process for future original equipment and genuine Lexus replacement. Our TX350 will be available for inspection on XXX at Parker Lexus in Little Rock Arkansas. The approximate cost to replace the windshield is $1850.00. We are not claiming the windshield on our insurance for this replacement for fear of potentially being cancelled by our insurance company. Please research this issue at your earliest convenience and feel free to request more information from me if needed to help in the assessment of the problem. We look forward to hearing from you asap. Thank You! [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: July 23, 2026 · Filed: July 25, 2026

The electronic throttle control, vehicle speed control, and powertrain/transmission control system failed. When I press the pedal to accelerate there was no power. However I did not lose power to the vehicle as I can see the vehicle was in Drive mode but was not moving forward. I was on a decline hill and the decline helped me go downwards before a truck could hit me. This total loss of acceleration has occurred exactly 2 times within a 4-week period. The vehicle is currently located at the Lexus dealership service center and is available for immediate inspection upon request. My wife and small children were in the vehicle when the accelerator pedal went completely dead while driving. The sudden drop in speed in active traffic almost caused us to be catastrophically rear-ended by an 18-wheeler semi-truck. After one minute of zero throttle, the vehicle violently jerked, locked us into a highly dangerous 5 MPH limp mode on the road, jerked a second time, and then suddenly resumed normal speed. My family's lives were put at extreme risk. No. The vehicle is currently at the authorized Lexus dealership for inspection, but the service department states they cannot find any diagnostic trouble codes (DTCs) and have not yet reproduced the intermittent failure on a test drive. The vehicle is currently under inspection by the authorized Lexus dealership service department. It has not yet been inspected by the manufacturer's regional corporate specialists, police, or insurance. No. There were absolutely no warning lamps, check engine lights, dashboard messages, or symptoms prior to either of the two failures. The loss of acceleration happened instantly without warning. The vehicle's computer system failed to store any error codes despite the severe mechanical jerking and the sudden 5 MPH speed restriction.

Incident: July 5, 2026 · Filed: July 6, 2026

We were driving down the highway and the vehicle started shaking. I immediately slowed down as I felt we had a flat. There was notification on the screen. I moved to the right onto the shoulder. Only after we were completely stopped did I see a low tire warning come on display. I slowly got out as the traffic was heavy. I could see the outer section of the tire came apart from both sides. As we were in a dangerous location someone called the police. Two police cars pulled behind us and provided us some safety. We agreed to swap out bad tire for spare as we were in a very dangerous location and needed to get vehicle moved before someone ran into all of us. We did look at the highway to ensure no objects were in the road. I didn’t see any while driving, but we wanted to verify to protect other drivers. There also weren’t any pot-holes in highway. We inspected tire after taking it off and there were no screws, nails, objects, or damage to the center tread/sides. The tire seemed to separate fairly cleanly on both sides. Tires were Continental Cross-contact 255/45 R22 107V LX20 (Eco plus) To repeat, no Warning Lights came on vehicle before tire came apart. I have sent message to my insurance company. No one has inspected tire and it is in my possession.

Incident: October 15, 2025 · Filed: July 1, 2026

I am reporting two separate but related fuel-system defects on my 2025 Lexus TX500h (VIN [XXX]) that raise safety concerns and appear to be widespread across Lexus TX and NX hybrid models. FUEL FILLER DOOR FAILS TO OPEN: The electronic fuel filler door intermittently fails to open when the release is activated. It sometimes requires multiple attempts, and at times will not open at all, leaving the vehicle unable to be refueled. This creates a safety risk of being stranded with no ability to add fuel, including the risk of running out of fuel on the road or being unable to refuel in an emergency. The failure appears to worsen in cold weather. This is a widely reported problem on 2022-2025 Lexus NX and TX hybrid vehicles and has been attributed to a faulty electronic fuel-door lock actuator (referenced by owners and parts suppliers as OEM part number 77030-F6020). Owners are frequently forced to use a manual emergency release located behind an access panel in the cargo area in order to refuel. FUEL TANK CANNOT BE FILLED TO CAPACITY: On a near-empty tank, the fuel pump nozzle shuts off after only approximately 8 gallons, despite the tank's rated capacity of approximately 17 gallons. Adding additional fuel requires repeated, prolonged attempts and often only a few more gallons can be added. This significantly reduces usable driving range relative to what the vehicle's fuel gauge and range estimate imply, creating a risk of unexpectedly low fuel and reduced range in situations where refueling options are limited. Other owners have reported the same behavior, and in at least one documented case a Lexus Field Technical Specialist diagnosed the cause as a deformed/defective fuel tank requiring a redesigned replacement. Both conditions are present on my vehicle. I am reporting them so that they are documented at the federal level. No crash, injury, or fire has occurred. I have also raised these issues with my Lexus dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: June 19, 2026 · Filed: June 23, 2026

y 2025 Lexus TX500h experienced sudden and complete AC failure at fewer than 25,000 miles, 18 months after purchase. The selling dealer diagnosed a refrigerant leak from the AC condenser and denied warranty coverage citing road debris impact damage. No photographic documentation of a discrete impact event or specific leak point was provided to support the denial. This failure is consistent with a documented, systemic design vulnerability in the Lexus TX platform. The vehicle's wide-open front grille design allows road debris direct access to the AC condenser, which sits as the frontmost component in the cooling stack with no protective barrier. Multiple NHTSA complaints document identical failures on TX platform vehicles at extremely low mileages including 580 miles and 900 miles, with dealers uniformly denying warranty coverage. Operating without AC in Texas summer heat constitutes a safety hazard, particularly for child passengers. I am requesting NHTSA investigate this as a systemic design defect pattern across the TX platform. Attached photos include: (1) photos provided by the dealer as their evidence of "impact damage" — none of which document a specific leak point or impact deformation zone; and (2) photos taken by the owner of the condenser on the Westside Lexus loaner vehicle provided during this service visit, which show comparable fin condition and debris accumulation to the denied vehicle. The loaner vehicle photos demonstrate that this condenser condition is consistent with normal operation in this environment, not discrete impact damage.

Incident: June 17, 2026 · Filed: June 22, 2026

On our 2025 Lexus TX350, less than 1 year old, and under normal driving conditions, our AC stopped working suddenly. Upon inspection at the dealership, they determined a rock or road debris came through the front grill and impacted the condenser, which caused a major refrigerant leak and ac to stop working. I believe this was due to a poor design of the lower half of the front grill, it’s wide open and offers little to no protection to ac and engine components. They should have a better honeycomb or similar grill to protect components. The refrigerant leak is an environmental and road safety issue, and living in hot climates like southern Nevada, when it’s 110 degrees outside, the heat inside the vehicle with no AC is a safety issue for children, adults, etc. The dealership did not cover repairs under warranty, and quoted $3,500 to repair either with cash or submit insurance claim.