NHTSA vehicle safety data

2005 Keystone Springdale Recalls & Complaints

The 2005 Keystone Springdale has 3 NHTSA recall campaigns and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Keystone dealer.

NHTSA recall and complaint data for the 2005 Keystone Springdale. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Keystone Springdale owner complaints

Owners have filed 4 complaints with NHTSA about the 2005 Keystone Springdale, describing incidents dated June 1, 2005 to October 1, 2009.

Most-cited components

Equipment 2 complaints
Structure 2 complaints
Latches/Locks/Linkages 1 complaint
Tires 1 complaint

Newest complaints

ODI #10290233 · Filed October 29, 2009
DOMETIC REFRIGERATORS IN A RV, MINE BURNED THROUGH THE BOILER TUBE LEAKING AMMONIA OUT, DOMETIC HAS A RECALL OUT, BUT THEY WONT REPLACE THE DAMAGE DONE, ALL THEY WILL DO IS IF I HAVE THE DAMAGE REPAIRED THEY WILL THEN REMEDY THE PROBLEM SO IT WONT HAPPEN AGAIN, THIS IS A BURNER PROBLEM AND WOULD…
ODI #10174409 · Filed November 27, 2006
DT*: THE CONTACT STATED WHILE THE FIFTH WHEEL TRAILER WAS PARKED, THE INNER WALL AND WALL FRAME SUPPORTS DROPPED WITHOUT WARNING. THE TRAILER WAS INSPECTED BY THE DEALER, WHO DETERMINED THE FRAME SUPPORTS WERE NOT ADEQUATE, AND THE OUTRIGGERS NEEDED TO BE REPLACED. ALSO, THE TRAILER HAD ADDITIONAL…
ODI #10144822 · Filed December 9, 2005
DT: THE CONTACT STATED WITH LESS THAN 500 MILES ON THE TIRES NOTICED CRACKS ON THE SIDEWALL ALL THE WAY AROUND ALL THE TIRES. HE REPLACED THEM. ALSO, THE DOOR LOCKED AND HE COULD NOT GET IN OR OUT OF THE TRAILER. THE TRAILER WAS DAMAGED WHEN THEY CRACKED THE DOOR TO GET OUT. HE CONTACTED THE…

Read all 4 complaints

Fire Extinguisher May Be Clogged or Inoperable

NHTSA #17V755000 · Equipment · NHTSA notice

Reported November 22, 2017 · Keystone RV Company

Potentially affected: 1,205,997 vehicles

Repair completion: 2.15% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Keystone campaign 17-307 · Owners notified January 15, 2018

Defect description

Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Safety consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Manufacturer remedy

Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

REFRIGERATOR/DOMETIC

NHTSA #08V325000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 17, 2008 · KEYSTONE RV COMPANY

Potentially affected: 161,250 vehicles

Keystone campaign 08-111 · Owners notified September 30, 2008 · Vehicles built June 1, 2003 – April 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

KEYSTONE IS RECALLING 161,250 MY 2004-2007 FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

KEYSTONE IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR KEYSTONE AT 1-866-425-4369.

Notes

KEYSTONE RECALL NO. 08-111.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

GASKET INSTALLATION/SECURE THE FURNACE TO FLOOR

NHTSA #05V076000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Furnace · NHTSA notice

Reported March 8, 2005 · KEYSTONE RV COMPANY

Potentially affected: 2,168 vehicles

Keystone campaign 05-052 · Owners notified March 14, 2005 · Vehicles built June 3, 2004 – February 24, 2005 (per NHTSA)

Defect description

ON CERTAIN TRAVEL TRAILERS AND FIFTH WHEEL RECREATIONAL VEHICLES, DURING PRODUCTION IT WAS DISCOVERED THAT THE FURNACE MAY NOT BE SECURED AND THE GASKET THAT SEALS THE FURNACE TO THE FLOOR DUCT SYSTEM MAY BE MISSING.

Safety consequence

THE FURNACE COULD MOVE AWAY FROM THE OUTSIDE WALL AND DISCONNECT FROM THE EXHAUST OUTLET. IF THIS OCCURS, EXHAUST GASSES WILL ENTER THE INTERIOR OF THE VEHICLE WHEN THE FURNACE IS OPERATING WHICH COULD LEAD TO INJURY OR DEATH FROM CARBON MONOXIDE POISONING.

Manufacturer remedy

DEALERS WILL INSPECT AND INSTALL THE FURNACE CORRECTLY, SECURING IT TO THE FLOOR AND ADDING THE MISSING GASKET FREE OF CHARGE. THE RECALL BEGAN ON MARCH 14, 2005. OWNERS MAY CONTACT KEYSTONE AT 1-866-425-4369.

Notes

KEYSTONE RECALL NO. 05-052.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2005 Keystone Springdale. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

4 owner complaints have been filed with NHTSA for the 2005 Keystone Springdale.

Equipment

ODI #10290233

Incident: October 1, 2009 · Filed: October 29, 2009

DOMETIC REFRIGERATORS IN A RV, MINE BURNED THROUGH THE BOILER TUBE LEAKING AMMONIA OUT, DOMETIC HAS A RECALL OUT, BUT THEY WONT REPLACE THE DAMAGE DONE, ALL THEY WILL DO IS IF I HAVE THE DAMAGE REPAIRED THEY WILL THEN REMEDY THE PROBLEM SO IT WONT HAPPEN AGAIN, THIS IS A BURNER PROBLEM AND WOULD HAVE BEEN ALL THE SAME IF IT HAD CAUSED A FIRE, AND MY FAMILY AND MYSELF HAD BURNED UP IN IT IN OUR SLEEP. AND IT'S JUST A 2005 MODEL. *TR

Structure

ODI #10174409

Incident: November 27, 2006 · Filed: November 27, 2006

DT*: THE CONTACT STATED WHILE THE FIFTH WHEEL TRAILER WAS PARKED, THE INNER WALL AND WALL FRAME SUPPORTS DROPPED WITHOUT WARNING. THE TRAILER WAS INSPECTED BY THE DEALER, WHO DETERMINED THE FRAME SUPPORTS WERE NOT ADEQUATE, AND THE OUTRIGGERS NEEDED TO BE REPLACED. ALSO, THE TRAILER HAD ADDITIONAL SUPPORTS INSTALLED ALONG THE FRAME WALL AND FLOOR. THE PROBLEM PERSISTED, AND THE MANUFACTURER WAS ALERTED. AFTERWARDS, THE TRAILER WAS TAKEN TO THE DEALER TO AWAIT FURTHER INSPECTION. UPDATED 12/15/2006 - *NM

Latches/Locks/Linkages; Tires

ODI #10144822

Incident: June 1, 2005 · Filed: December 9, 2005

DT: THE CONTACT STATED WITH LESS THAN 500 MILES ON THE TIRES NOTICED CRACKS ON THE SIDEWALL ALL THE WAY AROUND ALL THE TIRES. HE REPLACED THEM. ALSO, THE DOOR LOCKED AND HE COULD NOT GET IN OR OUT OF THE TRAILER. THE TRAILER WAS DAMAGED WHEN THEY CRACKED THE DOOR TO GET OUT. HE CONTACTED THE MANUFACTURER, THEY STATED HE NEEDED TO CONTACT THE LOCK MANUFACTURER. THEY WERE NOT WILLING TO ASSIST IN THE REPAIRS OF THE DOOR OR THE LOCK. *AK

Structure; Equipment

ODI #10135218

Incident: June 14, 2005 · Filed: September 2, 2005

STRUCTURE; FRAME AND MEMBERS;UNDERBODY VEHICLE IS LEANING TO LEFT SIDE AND WHEELS ARE RUBBING AGAINST THE WHEEL WELLS ,TRIED TO SPEAK WITH PLACE I PURCHASED THE VEHICLE,BUT THEY WON,T LOOK AT IT,VEHICLE CAME WITH A 2000 POUND JACK,DEALERSHIP CHANGED IT TO A 1000 POUNDS JACK, ALSO CALLED WARRANTY 10 TIMES, THAY WILL NOT CALL ME BACK,ALSO DEALERSHIP WON,T CALL . DEALERSHIP,BOAT N RV WAREHOUSE,12634 RTE. 9W W.COXSACKIE,N,Y 1-800-262-8678 MANUFACTURER,& WARRANT ,COM SUNRAY RV 161GILES INDUSTRIAL DR TAZEWELL,TN 37879 423-626-6344 WWW.SUNRAYRV.COM

Other Keystone Springdale model years

Check your 2005 Keystone Springdale VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Keystone Springdale at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Keystone VIN