NHTSA vehicle safety data

2011 Jayco Pinnacle Recalls & Complaints

The 2011 Jayco Pinnacle has 2 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Jayco dealer.

NHTSA recall and complaint data for the 2011 Jayco Pinnacle. Recall data is refreshed daily from NHTSA.

2011 Jayco Pinnacle owner complaints

Owners have filed 2 complaints with NHTSA about the 2011 Jayco Pinnacle, describing incidents dated July 2, 2012 to July 5, 2018.

Most-cited components

Electrical System 2 complaints
Tires 1 complaint

Newest complaints

ODI #11114409 · Filed July 29, 2018
KEPT SMELLING HOT WIRES AND BURNING PLASTIC SMELL. SERVICE TECH WAS ALREADY IN CAMPGROUND SO WE CALLED THEM OVER TO INVESTIGATE AND THEY DISCOVERED THE IOTA MODEL ITS-50R AUTOMATIC TRANSFER SWITCH HAD BURNT WIRES. OUR UNIT IS PREPPED FOR A GENERATOR BUT WE DO NOT HAVE ONE INSTALLED SO WE QUESTION…
ODI #10898558 · Filed August 25, 2016
TL* THE CONTACT OWNS A 2012 (NA) JAYCO PINNACLE EQUIPPED WITH GOODYEAR MARATHON ST TIRES, SIZE: ST235/80R16. WHILE THE VEHICLE WAS BEING TOWED AT 55 MPH, THE DRIVER'S SIDE TIRE EXPERIENCED A BLOW OUT. THE RV WAS TAKEN TO AN INDEPENDENT MECHANIC TO HAVE THE TIRE REPLACED. THE CONTACT WAS CONCERNED…

Read all 2 complaints

RANGE/OVEN COMBO/GAS SUPPLY LINE/POSSIBLE FIRE

NHTSA #10V500000 · Equipment · NHTSA notice

Reported October 21, 2010 · JAYCO, INC.

Potentially affected: 836 vehicles

Owners notified November 8, 2010 · Vehicles built August 16, 2010 – October 1, 2010 (per NHTSA)

Defect description

JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 TRAVEL TRAILERS AND FIFTH WHEELS MANUFACTURED FROM AUGUST 16, 2010, THROUGH OCTOBER 1, 2010, EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Safety consequence

A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Manufacturer remedy

JAYCO IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 8, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR JAYCO AT 1-574-825-0608.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AXLE ASSEMBLY/WHEEL END SEPARATION

NHTSA #10V469000 · Power Train — Axle Assembly · NHTSA notice

Reported October 4, 2010 · JAYCO, INC.

Potentially affected: 9 vehicles

Owners notified October 18, 2010 · Vehicles built August 25, 2010 – October 1, 2010 (per NHTSA)

Defect description

JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 PINNACLE FIFTH WHEEL TRAILERS EQUIPPED WITH DEXTER AXLES. ON SOME AXLES, CRACKS COULD APPEAR IN THE SPINDLE WELD.

Safety consequence

THESE CRACKS CAN PROPAGATE AND CAUSE THE SPINDLE TO DETACH FROM THE AXLE TUBE, RESULTING IN THE SEPARATION OF THE WHEEL END FROM THE VEHICLE, CREATING A ROAD HAZARD THAT INCREASES THE RISK OF A CRASH TO OTHER VEHICLES, AND COMPROMISES THE DRIVER'S CONTROL OF THE VEHICLE INCREASING THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

JAYCO IS WORKING WITH DEXTER AXLE AND WILL INSPECT THE AXLE SERIAL NUMBER AND REPLACE IT IF IT FALLS WITHIN THE SERIAL NUMBER RANGE. REPLACEMENT OF THE AXLE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267 AND DEXTER AXLE AT 1-800-2164.

Notes

try.vin has no NCAP crash-test rating on file for the 2011 Jayco Pinnacle. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2011 Jayco Pinnacle.

Electrical System

ODI #11114409

Incident: July 5, 2018 · Filed: July 29, 2018

KEPT SMELLING HOT WIRES AND BURNING PLASTIC SMELL. SERVICE TECH WAS ALREADY IN CAMPGROUND SO WE CALLED THEM OVER TO INVESTIGATE AND THEY DISCOVERED THE IOTA MODEL ITS-50R AUTOMATIC TRANSFER SWITCH HAD BURNT WIRES. OUR UNIT IS PREPPED FOR A GENERATOR BUT WE DO NOT HAVE ONE INSTALLED SO WE QUESTION HOW/WHY THIS TRANSFER SWITCH SHOULD GO BAD SINCE IT'S NOT USED. REPEATED EMAILS TO JAYCO ARE NOT OFFERING MUCH INFORMATION. WE SAW WHERE OTHER TRANSFER SWITCHES HAD BEEN RECALLED AND WONDERED IF OUR SWITCH WAS ONE OF THOSE BUT WE COULD NOT FIND RECALL NOTICE. ARE THERE ISSUES WITH THIS MODEL ALSO? THEY KEEP ASKING IF A POWER SURGE CREATED THE ISSUE. THE CAMPER IS HOOKED UP TO A 50A SURGE PROTECTOR AT OUR SEASONAL CAMPSITE SO THIS SHOULDN'T BE AN ISSUE. AND, IT'S NOT A SINGLE WIRE THAT IS BURNT BUT SEVERAL WHICH IS A MAJOR MALFUNCTION. I'M UPLOADING A PDF OF THE EMAIL CONVERSATION WITH JAYCO,

Electrical System; Tires

ODI #10898558

Incident: July 2, 2012 · Filed: August 25, 2016

TL* THE CONTACT OWNS A 2012 (NA) JAYCO PINNACLE EQUIPPED WITH GOODYEAR MARATHON ST TIRES, SIZE: ST235/80R16. WHILE THE VEHICLE WAS BEING TOWED AT 55 MPH, THE DRIVER'S SIDE TIRE EXPERIENCED A BLOW OUT. THE RV WAS TAKEN TO AN INDEPENDENT MECHANIC TO HAVE THE TIRE REPLACED. THE CONTACT WAS CONCERNED THAT THE TRAILER WAS SOLD WITH THREE YEAR OLD TIRES. THE CONTACT ALSO STATED THAT THE BATTERIES IN THE RV EXPLODED WITHOUT WARNING. THE TRAILER WAS TAKEN TO THE DEALER TO HAVE THE BATTERIES REPLACED. THE DEALER REPLACED THE BATTERY; HOWEVER, THE BATTERIES EXPLODED AGAIN AFTER A FEW DAYS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DOT NUMBER WAS UNKNOWN. THE APPROXIMATE TIRE AND VEHICLE FAILURE MILEAGE WAS 1,400.

Other Jayco Pinnacle model years

Check your 2011 Jayco Pinnacle VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Jayco Pinnacle at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Jayco VIN