NHTSA vehicle safety data
2007 Jayco Designer Recalls, Ratings & Complaints
The 2007 Jayco Designer has 3 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized Jayco dealer.
NHTSA recall and complaint data for the 2007 Jayco Designer. Recall data is refreshed daily from NHTSA.
EQUIPMENT:OTHER:LABELS
NHTSA #07V185000Reported April 27, 2007 · JAYCO, INC.
Potentially affected: 398 vehicles
Defect description
CERTAIN FIFTH WHEEL TRAVEL TRAILERS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE FEDERAL IDENTIFICATION LABEL CONTAINS THE INCORRECT TIRE LOAD RANGE AND INFLATION PRESSURES.
Safety consequence
THIS STANDARD SPECIFIES TIRE AND RIM SELECTION REQUIREMENTS AND RIM MARKING REQUIREMENTS.
Manufacturer remedy
THE INCORRECT LABEL WILL BE REMOVED AND A NEW CORRECT LABEL WILL BE INSTALLED. THE RECALL BEGAN ON MAY 15, 2007. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
Notes
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
STRUCTURE
NHTSA #07V118000Reported March 20, 2007 · JAYCO, INC.
Potentially affected: 561 vehicles
Defect description
ON CERTAIN TRAVEL AND FIFTH WHEEL TRAILERS EQUIPPED WITH HICKORY SPRINGS 'BIG EASY TRIPLE STEPS,' AN IMPROPER ENGAGEMENT OF THE BOTTOM STEP PIVOT ARM WITH THE FORMED STOP EDGE OF THE MIDDLE STEP SUPPORT BRACKET CAN RESULT IN THE BOTTOM STEP ROTATING TO AN UNSAFE DOWNWARD ANGLE.
Safety consequence
A PERSON COULD BE INJURED SHOULD THE STEP GIVE WAY WHILE BEING USED TO ENTER OR EXIT THE TRAILER.
Manufacturer remedy
DEALERS WILL INSPECT THE TRAILERS FOR THE MANUFACTURING DATE STICKER TO VERIFY THE DATE OF PRODUCTION OF THE STEP AND, IF NECESSARY, WILL WELD STOCK TO EACH SIDE OF THE LOWER (TRIPLE) STEP STOP EDGES. THE RECALL BEGAN ON MARCH 30, 2007. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
Notes
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
ELECTRICAL SYSTEM:WIRING
NHTSA #06V331000Reported August 31, 2006 · JAYCO, INC.
Potentially affected: 260 vehicles
Defect description
ON CERTAIN FIFTH WHEEL TRAILERS, A JUMPER WIRE BETWEEN THE TWO NEUTRAL BARS IS NOT OF ADEQUATE GAUGE.
Safety consequence
THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN AN ELECTRICAL FIRE.
Manufacturer remedy
DEALERS WILL REPLACE THE 12/14 GAUGE JUMPER WIRE WITH A 6 GAUGE JUMPER WIRE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 1, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
Notes
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Other Jayco Designer model years
Check your 2007 Jayco Designer VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Jayco Designer at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Jayco VIN