NHTSA vehicle safety data
2005 Itasca Sundancer Recalls & Complaints
The 2005 Itasca Sundancer has 4 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Itasca dealer.
NHTSA recall and complaint data for the 2005 Itasca Sundancer. Recall data is refreshed daily from NHTSA.
2005 Itasca Sundancer owner complaints
Owners have filed 1 complaint with NHTSA about the 2005 Itasca Sundancer, describing incidents dated August 19, 2004.
Most-cited components
- Engine 1 complaint
Newest complaints
ODI #10097501 · Filed
REGARDING A MODEL YEAR 2005 WINNEBAGO ITASCA MOTORHOME (SERIAL NO. 70467F241566C) UTILIZING A MODEL YEAR 2004 FORD E450 CHASSIS. WHILE SLEEPING AN ALARM WENT OFF INSIDE THE MOBILE HOME. THE LOCAL FIRE DEPARTMENT ARRIVED ON LOCATION AND FOUND A SLIDE OUT SHIELD WAS BLOCKING THE GENERATOR EXHAUST…
TV STRAP BOLTS
NHTSA #06V456000 · Equipment — Electrical — Radio/Tape Deck/Cd Etc. · NHTSA notice
Reported November 28, 2006 · WINNEBAGO INDUSTRIES, INC.
Potentially affected: 1,491 vehicles
Manufacturer campaign 103 · Owners notified December 15, 2006 · Vehicles built March 19, 2003 – September 29, 2005 (per NHTSA)
Defect description
ON CERTAIN MOTOR HOMES EQUIPPED WITH FRONT OVERHEAD TELEVISIONS, INCORRECT FASTENERS WERE USED TO SECURE THE TELEVISION LOCATED IN THE FRONT OVERHEAD AREA OF THE MOTOR HOME.
Safety consequence
THE TELEVISION MAY BECOME LOOSE AND POSSIBLY FALL FROM ITS POSITION WHICH HAS THE POTENTIAL TO IMPACT THE DRIVER OR PASSENGERS, RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.
Manufacturer remedy
DEALERS WILL INSPECT THE VEHICLE TO ASSURE THE CORRECT FASTENERS (BOLTS) WERE USED IN THE TV RETENTION STRAP. THE RECALL BEGAN ON DECEMBER 15, 2006. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.
Notes
WINNEBAGO RECALL NO. 103.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
FUEL TANK STRAPS
NHTSA #05V475000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice
Reported October 13, 2005 · WINNEBAGO INDUSTRIES, INC.
Potentially affected: 3,613 vehicles
Owners notified October 14, 2005 · Vehicles built April 12, 2004 – July 17, 2005 (per NHTSA)
Defect description
ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE FASTENERS HOLDING THE FUEL TANK MOUNTING STRAPS MAY NOT HAVE BEEN PROPERLY TIGHTENED, ALLOWING THE POSSIBILITY FOR THE FUEL TANK TO LOOSEN AND FALL.
Safety consequence
IF THE FUEL TANK FALLS, THERE IS THE POTENTIAL FOR THE TANK TO IGNITE, RESULTING IN PERSONAL INJURY, VEHICLE AND PROPERTY DAMAGE.
Manufacturer remedy
DEALERS WILL INSPECT AND PROPERLY TIGHTEN THE FASTENERS TO THE FUEL TANK STRAPS. THE RECALL BEGAN ON OCTOBER 15, 2005. OWNERS MAY CONTACT WINNEBAGO AT 614-585-6939.
Notes
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
WINNEBAGO/FORD/ABS BRAKE SYSTEM
NHTSA #04V512000 · Electrical System — Wiring · NHTSA notice
Reported October 20, 2004 · WINNEBAGO INDUSTRIES, INC.
Potentially affected: 3,950 vehicles
Manufacturer campaign 04S22 · Vehicles built September 23, 2002 – April 14, 2004 (per NHTSA)
Defect description
ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS AND EQUIPPED WITH GAS ENGINES, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.
Safety consequence
THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.
Manufacturer remedy
FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.
Notes
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
WINNEBAGO/FORD/AIR FILTER
NHTSA #04V516000 · Engine and Engine Cooling · NHTSA notice
Reported October 20, 2004 · WINNEBAGO INDUSTRIES, INC.
Potentially affected: 5,125 vehicles
Manufacturer campaign 04S23 · Vehicles built October 3, 2002 – September 30, 2004 (per NHTSA)
Defect description
ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
Safety consequence
THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Manufacturer remedy
FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.
Notes
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Other Itasca Sundancer model years
Check your 2005 Itasca Sundancer VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Itasca Sundancer at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check an Itasca VIN