How many recalls does the 2004 International 7500 have?

NHTSA lists 6 recall campaigns for the 2004 International 7500 as of October 16, 2026. Each includes the defect description, safety consequence, and the remedy International will perform. New recalls can be issued at any time; this page is refreshed from NHTSA daily.

How do I tell if my 2004 International 7500 is affected by a recall?

Enter your 17-character VIN — stamped at the base of the windshield on the driver side and on the door jamb sticker — at nhtsa.gov/recalls. NHTSA's VIN lookup shows whether your specific vehicle has an unrepaired recall; the list on this page covers every campaign for the 2004 International 7500.

Are recall repairs on a 2004 International 7500 free?

Usually. Federal law requires International to remedy recalls on the 2004 7500 free of charge at an authorized International dealer, regardless of how many owners the vehicle has had or how many miles are on the odometer — unless it was first sold more than 15 years before the recall was issued (5 years for tires).

Does a recall on the 2004 International 7500 affect resale value?

An open recall can reduce resale value; a recall that has been repaired (documented in the vehicle history report) generally does not. Before you buy or sell a used 2004 International 7500, check the VIN at nhtsa.gov/recalls to confirm every recall has been remedied.

How many owner complaints are on file for the 2004 International 7500?

No owner complaints have been filed with NHTSA on the 2004 International 7500.

NHTSA vehicle safety data

2004 International 7500 Recalls, Ratings & Complaints

The 2004 International 7500 has 6 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized International dealer.

NHTSA recall and complaint data for the 2004 International 7500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

TRAILER HITCHES:FIFTH WHEEL ASSEMBLY

NHTSA #05V188000

Reported April 28, 2005 · INTERNATIONAL TRUCK & ENGINE CORPORATION

Potentially affected: 4,616 vehicles

Defect description

ON CERTAIN VEHICLES EQUIPPED WITH AIR OPERATED FIFTH WHEEL SLIDES AND AN MSVA 7-PACK ACCESSORY CONTROLLER, THE 7-PACK CAN ALLOW WATER TO CONTAMINATE ITS CIRCUIT BOARD. THIS COULD RESULT IN INADVERTENT OPERATION OF THE FIFTH WHEEL SLIDE CONTROL.

Safety consequence

IF THE SLIDE CONTROL ACTUATES WHILE THE VEHICLE IS IN MOTION, MOMENTUM FROM THE TRAILER CAN CAUSE THE FIFTH WHEEL TO SLIDE WITHOUT INPUT FROM THE DRIVER, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL RELOCATE THE MSVA 7-PACK TO A LESS WATER INTENSIVE ENVIRONMENT. A NEW MSVA 7-PACK BASE, THAT HAS BEEN IMPROVED TO PREVENT WATER INTRUSION, AND ALL AIR ACCESSORY SOLENOIDS WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Notes

INTERNATIONAL RECALL NO.05511. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

STRUCTURE

NHTSA #04V569000

Reported December 3, 2004 · INTERNATIONAL TRUCK & ENGINE CORPORATION

Potentially affected: 17,443 vehicles

Defect description

ON CERTAIN TRUCKS, THE BOLTS THAT MOUNT THE FRONT OF THE CAB TO THE MOUNTING BRACKETS WERE NOT PROPERLY TORQUED AT THE MANUFACTURING PLANT.

Safety consequence

THESE BOLTS CAN LOOSEN DURING NORMAL VEHICLE USE AND FALL OUT. THIS MAY LEAD TO THE CAB SEPARATING FROM THE VEHICLE'S CHASSIS DURING A VEHICLE CRASH THAT MAY RESULT IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Manufacturer remedy

AS AN INTERIM ACTION, DEALERS WILL PROPERLY TIGHTEN THE EXISTING CAB MOUNTING BOLTS AND REPLACE ANY MISSING BOLTS. AS SOON AS PARTS ARE AVAILABLE, DEALERS WILL REPLACE ALL SIXTEEN BOLTS AND TIGHTEN THEM PROPERLY. AN INTERIM LETTER WAS SENT TO OWNERS ON FEBRUARY 11, 2005. ANOTHER LETTER WAS SENT TO OWNERS ON APRIL 8, 2005, AS SOON AS PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Notes

INTERNATIONAL RECALL NO. 05502 (04521 INTERIM ACTION).CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

NHTSA #04V306000

Reported June 30, 2004 · INTERNATIONAL TRUCK & ENGINE CORPORATION

Potentially affected: 18,545 vehicles

Defect description

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH INTERNATIONAL DT530, CUMMINS, OR CATERPILLAR I-6 ENGINES, THE POSITIVE BATTERY CABLE BETWEEN THE BATTERIES AND THE STARTER MAY RUB AGAINST AN ELECTRICAL GROUND CABLE BETWEEN THE STARTER AND FRAME RAIL.

Safety consequence

THIS COULD CAUSE AN ELECTRICAL SHORT AND/OR FIRE.

Manufacturer remedy

DEALERS WILL INSPECT FOR ANY CHAFING. IF THERE IS NO EVIDENCE OF CHAFING, A SADDLE CLAMP WILL BE INSTALLED. IF THERE IS EVIDENCE OF CHAFING, THE DAMAGED CABLES WILL BE REPLACED AND THE SADDLE CLAMP INSTALLED. THE RECALL BEGAN ON AUGUST 16, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Notes

INTERNATIONAL RECALL NO. 04510. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

NHTSA #04V193000

Reported April 22, 2004 · INTERNATIONAL TRUCK & ENGINE CORPORATION

Potentially affected: 1,687 vehicles

Defect description

CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SEAT BELT LATCH FAILED A QUALITY REVIEW.

Safety consequence

THIS COULD CAUSE THE SEAT BELT LATCH TO BECOME DISENGAGED WITHOUT WARNING IN A VEHICLE CRASH OR DURING EPISODES OF HIGH SEAT BELT LOADING.

Manufacturer remedy

DEALERS WILL REPLACE THE SEAT BELT ASSEMBLIES. OWNER NOTIFICATION IS BEGAN ON JUNE 11, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-445-7825.

Notes

INTERNATIONAL RECALL NO. 04506.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PARKING BRAKE

NHTSA #04V191000

Reported April 19, 2004 · INTERNATIONAL TRUCK & ENGINE CORPORATION

Potentially affected: 327 vehicles

Defect description

CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." A STANDARD FITTING WAS INSTALLED IN PLACE OF A SINGLE CHECK VALVE ON THE PARK BRAKE RELAY VALVE.

Safety consequence

THIS COULD RESULT IN THE PARKING BRAKE NOT RELEASING AND STOPPING THE VEHICLE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL THE CHECK VALVE. OWNER NOTIFICATION BEGAN ON MAY 3, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Notes

INTERNATIONAL RECALL NO. 04504.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

POWER TRAIN:DRIVELINE:UNIVERSAL JOINT

NHTSA #04V144000

Reported March 22, 2004 · INTERNATIONAL TRUCK & ENGINE CORPORATION

Potentially affected: 2,021 vehicles

Defect description

ON CERTAIN TRUCKS EQUIPPED WITH DT466 OR DT530 1308 STYLE ENGINES AND 4X4 OR 6X6 CAPABILITY, THE UNIVERSAL JOINT BETWEEN THE FRONT DRIVE SHAFT AND DRIVE AXLE COULD COME IN CONTACT WITH THE ENGINE OIL FILTER UNDER CERTAIN BRAKING CONDITIONS.

Safety consequence

THIS COULD CAUSE A LOSS OF COMPLETE ENGINE OIL WHICH COULD RESULT IN THE ENGINE SHUTTING DOWN AND INCREASE THE RISK OF PROPERTY DAMAGE, PERSONAL INJURY, OR A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A SHORTER OIL FILTER AND ADAPTER. OWNER NOTIFICATION IS EXPECTED TO BEGIN APRIL 29, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Notes

INTERNATIONAL RECALL NO. 04504.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other International 7500 model years

Check your 2004 International 7500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your International 7500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an International VIN