2022 Hyundai Tucson Hybrid Recalls, Ratings & Complaints

Incident: August 17, 2026 · Filed: October 6, 2026

The contact owns a 2022 Hyundai Tucson. The contact stated that while driving 5 MPH, the brake pedal was depressed; however, the vehicle failed to stop. The contact stated that the vehicle independently accelerated. The contact stated that the brake pedal was depressed with force and the vehicle came to a stop. The failure occurred intermittently at first but became a persistent failure. The dealer was contacted by phone and made aware of the failure. The failure mileage was approximately 17,000.

Incident: August 27, 2026 · Filed: August 31, 2026

My vehicle suffered a disabling failure 325 miles from home due to an open Safety Recall campaign. The vehicle is repaired under Campaign Claim #43195279, but Hyundai Corporate is actively denying both a reunite transport tow and travel rental accommodations to retrieve the vehicle. The manufacturer is failing to provide a reasonable or accessible remedy, leaving me completely carless at home for 3 days due to an admitted safety defect with no way to retrieve my vehicle 325 miles from home.

Incident: May 11, 2026 · Filed: August 19, 2026

System/Component Failed & Inspection: The vehicle suffers from recurring failures across the engine, powertrain, electronic throttle control, and exhaust gas recirculation (EGR) control systems (DTCs P0524, P0642, P2118, P022100). The vehicle is fully available for inspection upon request. Safety Risk: While driving, the vehicle suffered a complete, sudden loss of motive power on an active highway entrance ramp. The engine stalled in moving traffic with zero throttle response, creating an immediate collision hazard before requiring a tow. Confirmation by Dealer: Technicians formally confirmed these defect patterns. In May 2026, diagnostics logged major engine and emission/EGR control codes, but corporate refused goodwill repair. In August 2026, the highway stall recurred. Diagnostics confirmed active low oil pressure and throttle failure codes, which the dealer resolved by applying 4 factory ECU software updates under TSB 25-01-010H. Service personnel explicitly confirmed these engine control issues are manufacturing defects, not wear-and-tear or mileage-related. Inspections: Inspected, diagnosed, and serviced by authorized dealership service department technicians during both the May and August 2026 failure events. Warning Symptoms & History: Engine issues began at 341 miles when purchased new (settled). In May 2026, check engine lights returned with diagnostic codes for engine and EGR/emissions systems. In August 2026, total power loss occurred, preceded by check engine, forward collision camera, and radar sensor warnings.

Incident: August 4, 2026 · Filed: August 6, 2026

While driving my 2022 Hyundai Tucson Hybrid, the vehicle suddenly lost power, began shaking, and all warning lights illuminated at once. The car would not accelerate properly and became unsafe to operate in traffic. After pulling over and restarting the vehicle, the warnings cleared, but the issue has occurred more than once. It first occurred 3/25/26. The dealer was not able to reproduce the issue but found numerous faults and reset them. This is a serious safety concern because the vehicle can unexpectedly lose motor power while driving, creating a risk of collision. The problem is intermittent and unpredictable.

Incident: June 26, 2026 · Filed: August 4, 2026

I am reporting a critical Exhaust Gas Recirculation (EGR) valve and electrical circuit failure on my 2022 Hyundai Tucson Hybrid. The failure resulted in the check engine light illuminating, diagnostic codes identifying an EGR system malfunction, and visible corrosion found within the EGR connector and extension harness. This component breakdown causes severe performance risks, risk of sudden loss of engine power, and compromises vehicle safety. Diagnostic & Technical Details: Error Codes Captured: Diagnostic trouble codes in the P0400 series (EGR system flow/circuit malfunction) along with connector/wiring degradation were confirmed during inspection. Root Cause & Symptoms: The failure stems from degradation and electrical shorting risks in the EGR valve assembly and its immediate wiring harness connection. Manufacturer Response & Escalation Denial: When addressing this failure, I discovered that Hyundai has acknowledged widespread EGR valve assembly defects, electrical short risks, and solder flux contamination issues across multiple model years and production lines (such as NHTSA Campaign 24V-308 and subsequent service campaigns like 9B3). However, Hyundai restricts safety recall and warranty coverage strictly based on narrow VIN manufacturing parameters, leaving owners with identical, failing hardware to shoulder exorbitant out-of-pocket repair costs—in my case, quoted at over $2,013.  Because a compromised EGR system and corroded electrical harness can cause sudden engine performance failures while driving in traffic, and because Hyundai is limiting its accountability through arbitrary production windows, I am requesting that NHTSA investigate this systemic EGR and harness failure on 2022 Tucson Hybrid models and compel Hyundai to expand its safety coverage and reimburse affected owners for necessary repairs.

Incident: May 19, 2026 · Filed: July 29, 2026

On XXX the vehicle lost motive power while my wife was accelerating to merge onto a highway with our two young children aboard. It would not accelerate and she was forced to pull over in an active merge area. Simultaneous warnings illuminated: Electronic Parking Brake, ESC, Forward Collision Avoidance, Blind Spot Detection, and hybrid system, with "Check Hybrid System" displayed. No crash or injury occurred, but loss of propulsion during a highway merge created serious collision risk. This is a recurring defect documented since early 2023: Hyundai's own Blue Link telematics auto-flagged an Engine Control System DTC on XXX; a jump-start was required XXX (dealer RO #XXX); check engine light and stored CAN-bus codes U100387, U100100, U004600, U010100 on 08/10/2023 (RO #XXX); and a September 2023 incident in which the center display shut off during reverse, disabling the backup camera. Hyundai performed Service Campaign 9B4 (BMS software update, DTC P1BB20, TSB 25-01-010H-1) on this VIN on XXX; the same failure category recurred 84 days later. The vehicle was towed to Safford Hyundai of [XXX] onXXX and has remained there 65+ consecutive days. The dealer replaced the 12V battery (defect persisted) and the Hybrid Power Control Unit (HPCU); per Hyundai Consumer Affairs' own written email ofXXX, the check engine light returned after the HPCU replacement and the cause "remains unidentified." The dealer states it cannot determine the root cause. The vehicle IS available for inspection at Safford Hyundai of Springfield, [XXX]. Five Hyundai Consumer Affairs cases exist on this VIN (current: #XXX). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: July 24, 2026 · Filed: July 28, 2026

This is the 4th time that a new fuel pump has been replaced on this 2022 Hyundai Tucson hybrid. I think the car part needs a recall because the fuel pump keeps breaking.

Incident: January 17, 2026 · Filed: July 14, 2026

The contact owns a 2022 Hyundai Tucson. The contact stated that while driving, after an hour, the vehicle was shaking and shuddering abnormally and the vehicle lost motive power. The driver was unable to maintain a steady speed while driving the vehicle. The vehicle was making an abnormal sound while driving at 60 MPH, and the vehicle was struggling to accelerate. There were no warning lights illuminated. The blue link indicated that the failure was associated with DTC: P03600. The vehicle was taken to the local dealer, who was unable to retrieve a diagnostic trouble code. The vehicle was diagnosed as needing the fluid, tires, and brakes to be changed, and the low jack to be removed. The vehicle was not repaired. Another local dealer, Napleton Hyundai (4333 W Ogden Ave, Aurora, IL 60504) was contacted, but there was no response. The manufacturer was contacted, and a case was opened. The failure mileage was approximately 48,000.

Incident: April 15, 2026 · Filed: June 26, 2026

My 2025 Mazda CX-5 has an intermittent defect that causes Android phones connected to Android Auto through the vehicle's USB-C port to unexpectedly perform a complete device reboot while the vehicle is being driven. The problem began in August 2025 after I purchased a Google Pixel 9. I initially believed the phone was defective and spent several months troubleshooting the phone. After the same problem occurred with my son's Google Pixel 10, I determined the issue was not phone-specific. I reported the problem to Mastria Mazda in March/April 2026 and returned again in May 2026. I opened a case with Mazda Customer Experience on June 4, 2026. The vehicle software has been updated, but the defect remains. The failure is random. It does not occur immediately after connecting the phone and is not associated with navigation, music, phone calls, messaging, or trip duration. It can occur once during a trip or multiple times during the same trip. The defect has been reproduced with two different phones (Google Pixel 9 and Pixel 10) using multiple USB-C cables. The same phones were then tested using wired Android Auto in another 2025 Mazda CX-5 (loaner driven for one week), a Mazda3, a Mazda CX-90, and a Tesla. The problem did not occur in any of those vehicles. My Pixel 9 also works normally in my vehicle when using wireless Android Auto. The reboots occur only through the wired USB-C Android Auto connection in my vehicle. This creates a safety hazard because Android Auto immediately disconnects, causing the sudden loss of navigation, the head-up display directions, hands-free calling, and voice commands while driving. The defect has occurred multiple times during Boston morning rush-hour traffic and while navigating a major highway interchange under construction where lane assignments had been temporarily changed. The unexpected loss of navigation and driver information at these critical moments creates a significant driver distraction and potential safety risk.

Incident: June 2, 2025 · Filed: June 22, 2026

WIPERS STOP WORKING. THEY WILL FREEZE AND STOP MOVING ACROSS THE WINDSHIELD. SO FAR I CAN FIX THE PROBLEM BY TURNING THE WIPERS OFF AND THEN BACK ON. MY CONCERN IS THAT MAY NOT WORK IN THE FUTURE. ALSO, IN HEAVY RAIN AN ACCIDENT MAY HAPPEN BEFORE I CAN RESTART THE WIPERS. I BROUGHT THE CAR IN TO THE DEALERSHIP, BUT THEY COULD NOT FIND ANYTHING WRONG.