2025 Hyundai Ioniq 5 Recalls, Ratings & Complaints

Incident: October 26, 2026 · Filed: October 27, 2026

Second failure of the Integrated Charging Control Unit (ICCU) on this 2025 IONIQ 5. The ICCU stopped charging the 12-volt battery, leaving the vehicle unable to start. This is the second time the ICCU has failed and required replacement in approximately one year. The vehicle was towed to the dealer. ICCU failure can cause a loss of drive power while driving; this failure was discovered while parked. Earlier model years (2022-2024 IONIQ 5) are covered by recall 24V-868 for this same defect; this 2025 vehicle is outside that recall population and has now failed twice.

Incident: October 10, 2026 · Filed: October 20, 2026

On XXX, while driving my 2025 Hyundai Ioniq 5 on a local road, the vehicle suddenly lost power and would not accelerate beyond 40 MPH. There was no prior warning. I had not yet merged onto the expressway. Had this happened at highway speed, I would have been unable to keep up with traffic, which would have created a serious risk of a collision. I continued driving at reduced speed until I could safely pull into a gas station. Once stopped, the instrument cluster displayed "Stop vehicle and check power supply." About 10 minutes later, with the vehicle parked and still on, it displayed "Check 12V battery. Stop safely and engage parking brake." Roughly 10-15 minutes after that, the vehicle shut down completely and could not be restarted. The vehicle was towed to Gerald Hyundai in [XXX] on that day. On XXX, the dealer confirmed that the Integrated Charging Control Unit (ICCU) and a fuse failed and had to be ordered for replacement. The vehicle is less than one year old. I am aware of numerous reports of ICCU and 12V battery failures on this model, and my experience is consistent with them. A sudden loss of propulsion while driving is a safety hazard, and I am concerned this defect can occur without warning at highway speeds. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 10, 2026 · Filed: October 16, 2026

I am reporting a serious suspected brake malfunction involving my 2025 Hyundai IONIQ 5, VIN [XXX]. While driving straight on a wet road during rainy conditions, I pressed the brake pedal to slow down. The pedal felt soft and sank toward the floor, but the vehicle did not slow down or respond as expected. The vehicle continued moving, and an accident occurred. The vehicle sustained major damage and may be a total loss. I am concerned that the braking system may have malfunctioned. I am requesting that NHTSA review this incident for a possible safety-related defect affecting the braking system of the 2025 Hyundai IONIQ 5. I request that this complaint be considered alongside other reports of braking problems involving the same vehicle or braking components. I would like the vehicle and its braking system to be inspected before it is dismantled or disposed of, and I ask that relevant diagnostic information be preserved. Please investigate whether this incident may be related to a safety defect that could affect other drivers. Additional information, including the accident date, vehicle mileage, warning lights, and accident report, can be provided as available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 19, 2026 · Filed: September 19, 2026

I am writing to document my case regarding my leased 2025 Hyundai Ioniq 5 XRT. Vehicle: 2025 Ioniq 5 XRT, VIN [XXX] Lease start / delivery date: Odometer: 4,368 miles Servicing dealer: Stevinson Hyundai, [XXX] Case number: XXX What happened: On Saturday, XXX, while I was driving, the vehicle displayed "Stop vehicle and check power supply" with the red 12V battery warning and the master warning light, and power was limited to approximately 25 mph. The high-voltage battery was at 66 percent. I was able to get the vehicle home at reduced speed, and Hyundai Roadside Assistance towed it to the dealer the same day. The symptoms are consistent with an ICCU failure, pending the dealer's diagnosis. Photos of the instrument cluster are attached. I consider a sudden loss of drive power at 4,368 miles to be a safety-related defect, and I have reported it to NHTSA. My situation: This is one of two vehicles in our household, and both of us need to get to work. The dealer is about 30 miles from my home. I am without transportation as of September 19. What I am requesting: 1. Written authorization for a rental vehicle starting immediately and continuing until my vehicle is repaired and returned, including the approved daily rate and how billing or reimbursement will work. 2. A parts availability check and estimated repair date as soon as the dealer confirms the diagnosis. 3. If the vehicle is out of service for an extended period, reimbursement of my lease payments for the time I cannot use it. 4. Confirmation of the warranty coverage that applies to the ICCU on this VIN, including any extended ICCU coverage. I am keeping a record of the days the vehicle is out of service, starting XXX. Please reply in writing so I have everything documented. Thank you for your help, [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: May 1, 2025 · Filed: September 11, 2026

Driving at highway speeds, the front end feels unstable. It feels as if the tires are jumping around and will move the car to the right or left. It is difficult to maintain control. I had it into the dealer shortly after I bought the car to complain about what I thought was a front end alignment problem. They didn't think there was an issue until they got it into the shop. They said afterwords that it WAS OUT OF LINE. But their fix did not hold, so I went in again for the one year maintenace and mentioned the problem, but they said it was not out of line. Well, The problem still exists. Something serious is wrong and needs to be fixed.

Incident: September 8, 2026 · Filed: September 8, 2026

Full electrical power system failure. Heard a loud pop noise emanating from under the rear seats of the car. The power. Failure lights came on and the car lost power. We were able to get the car to slowly drive back to the garage where it completely shut down and was inoperable from that point on. Car has been towed to the local dealer for diagnostics and repair.

Incident: September 4, 2026 · Filed: September 8, 2026

On 8/30 my vehicle experienced a power loss on a highway (reported here separately). I took the car to the dealership and they could not replicate the error and gave the vehicle back to me on 9/4. Later that day I had to drive 2 hours north to a wedding in the mountains. At 9:30pm my vehicle experienced a full drive power loss on an unlighted, curving, rural 2-lane mountain road in an area with minimal cell phone service. I tried to restart the vehicle several times and could not get any power. I called roadside assistance and had to wait over 2 hours in the dark on a winding mountain road for the tow truck to find us and then be towed 40 minutes away to the nearest dealership where my car is still sitting waiting to be looked at (2 hours away from where I live)

Incident: August 30, 2026 · Filed: September 4, 2026

Driving home near my apartment, I had to join a busy highway from a full stop. I found a small gap and tried to accelerate to quickly merge into traffic, when my car made a high pitched alert noise and noticably did not accelerate beyond about 25 miles per hour on a 45-50mph highway with heavy traffic. I turned on my hazards and still ended up with a line up of cars honking behind me. Flooring the accelerator did absolutely nothing to increase my speed. On slight downhills I could get up to about 40mph but as soon as it leveled off my speed went back down to limping along. I was able to exit the highway at slow speed and tried to parallel park in an avaialble spot but could not reverse. I tried to drive on toward my house but the car could not make it up the hill even with the full accelerator pedal down. People were stuck behind me on my street so I turned the car off and back on again and the car appeared to resume normal operation and I was able to drive up the hill. I took the car to the dealer and they were "not able to replicate the error". They did fix a seat belt recall and updated the software for my ECU and said to come back if it happened again...

Incident: August 27, 2026 · Filed: September 2, 2026

While driving this EV with cruise control on, the dashboard suddenly showed a message that “Smart Cruise Control conditions not met”. Attempting to re-engage the cruise control did not work and then the vehicle suddenly lost all propulsion (pressing the accelerator did nothing). The car quickly slowed to about 20 mph before we could maneuver it to the shoulder and turn it off. After a couple minutes, we restarted the car and drove it to the dealer. There were no other messages or warning lights or indicators. The dealer could not find anything wrong and asked us to pick up the car and resume using it. We use both a home charger (Emporia) and roadside (Tesla) chargers.

Incident: August 22, 2026 · Filed: August 31, 2026

I heard a loud popped sound from the back of my car while driving home. The car lost power and eventually died on the street. The war displacy came on to tell em to check electrical system. I originally bought th car from Capitol Huyndai in San Jose on September 2025 and it has 5992 miles. I towed the car to Dublin Hyundai for repair and confirmed the DTCP1A9096 for ICCU computer failing to charge the 12 v battery. It was a well known recall . I do not have any update on the repair since 8/25/26. I worry about my safety because the car can lose power while driving