2015 Harley-Davidson Flhxs Recalls & Complaints

Incident: July 2, 2017 · Filed: July 3, 2017

ON 7/2/17 I WAS RIDING ON HIGHWAY 13 TRAVELING 50-55 MILES PER HOUR AND GOING INTO A GENTLE CURVE HEADING TO CLINTON, MO. FOR LUNCH WITH A GROUP OF FRIENDS. MY RIGHT SADDLEBAG CAME OFF THE BIKE AND SLIDE ACROSS THE ASPHALT ROAD INTO A GRASSY AREA. THIS COULD HAVE BEEN BAD SINCE THERE WERE FIVE (5) BIKES BEHIND ME, I TURNED AROUND AS DID SOME OF THE OTHER TO GO BACK TO GET WHAT WAS LEFT OF MY BAG AND CONTENTS. ON SATURDAY 7/1/17 I HAD MY BIKE IN THE SHOP FOR IT'S 20,000 MILE SERVICE AND TOLD THEM TO CHECK EVERYTHING OUT REALLY GOOD BECAUSE I AM LEAVING ON A TRIP TO SOUTH DAKOTA IN TWO (2) WEEKS; USUALLY THEY CHECK EVERY NUT, BOLT AND CABLE TO MAKE SURE THEY ARE IN GOOD CONDITION AND WORKING ORDER, I DON'T KNOW IF THEY CHECK THIS OR NOT, BUT AFTER I TOLD THE DEALERSHIP (OUTLAW HARLEY-DAVIDSON IN BLUE SPRINGS, MO) WHAT HAPPEN AND FELT THAT THEY SHOULD REPLACE THE SADDLEBAG AS I DON'T TAKE THEM OFF I ONLY HAVE THEM DO THAT WHEN THEY DO SERVICE AND/OR WASH THE BIKE FOR ME. THE GENERAL MANGER OF THIS DEALERSHIP GAVE ME THE IMPRESSION THEY AREN'T GOING TO DO ANYTHING FOR ME, BUT AFTER DOING SOME RESEARCH ON THE INTERNET I SAW THAT HARLEY HAS A RECALL ON SOME MODELS (MINE IS LISTED FLHXS EVEN THOUGH WHEN I TYPED IN THE VIN# IT STATED NO RECALLS) I FEEL THE DEALERSHIP SHOULD FIX AND/OR REPLACE THE DAMAGED BAG AND PINS THAT HOLD THEM ON..

Incident: November 11, 2016 · Filed: November 24, 2016

CLUTCH FAILED TO DISENGAGE. I WAS IN MY DRIVEWAY. I HAD JUST ROLLED MY MOTORCYCLE OUTTA THE GARAGE. STARTED THE MOTORCYCLE IN NEUTRAL AND THAT'S WHEN IT LEAPED FORWARD WITH A VIOLENT JERKING MOTION AND WOULDN'T STOP. LUCKILY I WAS ABLE TO KEEP HANGING ONTO THE RIGHT HAND BRAKE LEVER UNTIL IT ULTIMATELY KILLED THE ENGINE AND STOPPING THE MOTORCYCLE. THE DEALER HAS ESTIMATED THE DAMAGE TO BE OVER $9200...!!! IT HAS HAD ALL RECALLS PREVIOUSLY PERFORMED.

Incident: August 10, 2015 · Filed: November 25, 2015

TL* THE CONTACT OWNS A 2015 HARLEY-DAVIDSON FLHXS. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE CONTACT LOST CONTROL OF THE MOTORCYCLE CAUSING IT TO RUN OFF OF THE ROAD AND FLIP THE CONTACT OFF OF THE MOTORCYCLE. A POLICE REPORT WAS FILED. THE CONTACT STATED THAT AS A RESULT OF THE CRASH THERE WERE INJURIES SUSTAINED THAT REQUIRED MEDICAL ATTENTION DUE TO A TRAUMATIC BRAIN INJURY. THE MOTORCYCLE WAS TOWED TO AN INDEPENDENT MECHANIC, HOWEVER IT WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V216000 (POWER TRAIN). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

Incident: April 14, 2015 · Filed: September 17, 2015

TL* THE CONTACT OWNS A 2015 HARLEY-DAVIDSON FLHXS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V216000 (POWER TRAIN); HOWEVER, THE PARTS TO DO THE RECALL REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Incident: August 7, 2015 · Filed: August 10, 2015

STARTED THE MOTORCYCLE IN NEUTRAL. WHEN I PULLED IN THE HYDRAULIC CLUTCH AND PUT THE BIKE IN 1ST GEAR, THE BIKE TOOK OFF. THE CLUTCH WAS COMPLETELY INEFFECTIVE AND I BARELY AVOIDED AN ACCIDENT. I WAS ABLE TO CONTROL THE BIKE BY SLAMMING ON THE BRAKES AND SHUTTING THE BIKE OFF. THE BIKE HAD TO BE TOWED TO THE DEALERSHIP AS IT IS NOT SAFE TO RIDE. WHEN THE DEALER RAN THE VIN TO SEE IF IT WAS PART OF THE 2014-2015 FLHXS THAT ARE RECALLED...IT CAME UP AS NOT PART OF THE RECALL.

Incident: April 20, 2015 · Filed: May 13, 2015

EXCESSIVE HEAT FROM A DEFECTIVE ENGINE DESIGN HAS CAUSED SEVERAL BURNS TO RIGHT LOWER LEG. REAR CYLINDER CREATES EXCESSIVE HEAT WHICH FORCES OPERATOR TO ASSUME UNSAFE SITTING POSITIONS TO AVOID ENGINE HEAT, WHICH RIGHT LEG IS ALWAYS EXPOSED TO WITH NO CHOICE DUE TO VEHICLE CONTROLS.