NHTSA vehicle safety data

2003 Harley-Davidson Flhrci Recalls & Complaints

The 2003 Harley-Davidson Flhrci has 1 NHTSA recall campaign and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Harley-Davidson dealer.

NHTSA recall and complaint data for the 2003 Harley-Davidson Flhrci. Recall data is refreshed daily from NHTSA.

2003 Harley-Davidson Flhrci owner complaints

Owners have filed 4 complaints with NHTSA about the 2003 Harley-Davidson Flhrci, describing incidents dated July 31, 2002 to July 16, 2005.

Most-cited components

Electrical System 1 complaint
Engine 1 complaint
Equipment 1 complaint
Service Brakes 1 complaint

Newest complaints

ODI #10149870 · Filed February 9, 2006
REAR BRAKE FAILURE DUE TO USE OF DOT 5 BREAK FLUID AT HIGH ALTITUDE IN HOT WEATHER. ON TRIP OVER SIERRAS ON JULY 16, 2006, I AND FOUR OTHERS HAD REAR BRAKE OR OTHER HYDRALIC FAILURE. *NM
ODI #10138424 · Filed October 4, 2005
THE STOCK HORN ON MY 2003 HARLEY DAVIDSON ROAD KING CLASSIC MOTORCYCLE HAD BEEN ANEMIC AT BEST FROM NEW AND HAD PROGRESSIVELY GOTTEN WEAKER IN VOLUME AND NOW ONLY WORKS INTERMITTENTLY. THE DEALERS HAS CLAIMED THAT THE LOW VOLUME IS TYPICAL OF HD HORNS AND THAT, SINCE THE INTERMITTENT FAILURE…
ODI #10080877 · Filed July 12, 2004
CATASTROPHIC ENGINE FAILURE OCCURRED TWICE IN A NEW 2003 HARLEY-DAVIDSON MOTORCYCLE AT 3284 MILES AND AGAIN AT 7420 MILES. THE FIRST WAS DUE TO A CRACKED FLYWHEEL, WHICH WAS REPLACED UNDER WARRANTY, AND THE SECOND DUE TO A BROKEN OIL PUMP. THE CAUSE WAS DETERMINED BY AN ENGINEER'S MEASUREMENTS TO BE…

Read all 4 complaints

HARLEY-DAVIDSON/TAIL LIGHT BULB

NHTSA #04V218000 · Exterior Lighting — Tail Lights · NHTSA notice

Reported May 7, 2004 · HARLEY-DAVIDSON MOTOR COMPANY

Potentially affected: 31,070 vehicles

Harley-Davidson campaign 0114 · Owners notified June 3, 2004 · Vehicles built June 4, 2003 – August 22, 2003 (per NHTSA)

Defect description

ON CERTAIN DYNA, XL, AND TOURING MOTORCYCLES, THE TAIL LIGHT BULB CAN FALL OUT OF THE SOCKET.

Safety consequence

THE TAIL LIGHT AND THE BRAKE LIGHT BECOME INOPERATIVE, WHICH COULD LEAD TO A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE BULBS. OWNER NOTIFICATION BEGAN ON JUNE 3, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2003 Harley-Davidson Flhrci. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

4 owner complaints have been filed with NHTSA for the 2003 Harley-Davidson Flhrci.

Service Brakes, Hydraulic

ODI #10149870

Incident: July 16, 2005 · Filed: February 9, 2006

REAR BRAKE FAILURE DUE TO USE OF DOT 5 BREAK FLUID AT HIGH ALTITUDE IN HOT WEATHER. ON TRIP OVER SIERRAS ON JULY 16, 2006, I AND FOUR OTHERS HAD REAR BRAKE OR OTHER HYDRALIC FAILURE. *NM

Electrical System

ODI #10138424

Incident: July 31, 2002 · Filed: October 4, 2005

THE STOCK HORN ON MY 2003 HARLEY DAVIDSON ROAD KING CLASSIC MOTORCYCLE HAD BEEN ANEMIC AT BEST FROM NEW AND HAD PROGRESSIVELY GOTTEN WEAKER IN VOLUME AND NOW ONLY WORKS INTERMITTENTLY. THE DEALERS HAS CLAIMED THAT THE LOW VOLUME IS TYPICAL OF HD HORNS AND THAT, SINCE THE INTERMITTENT FAILURE OCCURRED AFTER THE 12 MONTH ORIGINAL WARRANTY, IT IS NOT A HD PROBLEM. THERE HAS NOT BEEN AN ACCIDENT YET. IF THERE IS, I MIGHT NOT BE AROUND TO COMPLAIN. *JB

Engine and Engine Cooling

ODI #10080877

Incident: January 16, 2004 · Filed: July 12, 2004

CATASTROPHIC ENGINE FAILURE OCCURRED TWICE IN A NEW 2003 HARLEY-DAVIDSON MOTORCYCLE AT 3284 MILES AND AGAIN AT 7420 MILES. THE FIRST WAS DUE TO A CRACKED FLYWHEEL, WHICH WAS REPLACED UNDER WARRANTY, AND THE SECOND DUE TO A BROKEN OIL PUMP. THE CAUSE WAS DETERMINED BY AN ENGINEER'S MEASUREMENTS TO BE MIS-ALIGNED CRANKCASE, AND THE MANUFACTURER REFUSES TO REPAIR OR REPLACE THE ENGINE. *LA

Equipment

ODI #10048429

Filed: January 7, 2004

HARLEY DAVIDSON FLHRCI 2003. THE HOSES TO THE OIL COOLER COULD POSSIBLY RUBBED AGAINST THE ENGINE CRANKCASE. THE HOSES MAY LEAK OIL WHICH CAN CAUSE THE REAR TIRE TO SPIN OUT IF THE OIL CAME IN CONTACT WITH THE TIRE. PLEASE PROVIDE FURTHER DETAILS. *PH THE CONSUMER RECEIVED RECALL#03E051000 FROM A THIRD PARTY, HOWEVER WHEN THE CONSUMER CONTACTED THE MANUFACTURER, HE WAS INFORMED THAT A FIX HAD NOT BEEN DEVELOPED AND TO TAKE THE MOTORCYCLE TO THE DEALER WHO MAY PROVIDE A SOLUTION. THE DEALER REPLACED THE HOSE, HOWEVER THE CONSUMER DID NOT BELIEVE THAT WOULD SOLVE THE PROBLEM.*JB

Other Harley-Davidson Flhrci model years

Check your 2003 Harley-Davidson Flhrci VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Harley-Davidson Flhrci at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Harley-Davidson VIN