NHTSA vehicle safety data

2004 Harley-Davidson Dyna Glide Recalls & Complaints

The 2004 Harley-Davidson Dyna Glide has 2 NHTSA recall campaigns and 5 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Harley-Davidson dealer.

NHTSA recall and complaint data for the 2004 Harley-Davidson Dyna Glide. Recall data is refreshed daily from NHTSA.

2004 Harley-Davidson Dyna Glide owner complaints

Owners have filed 5 complaints with NHTSA about the 2004 Harley-Davidson Dyna Glide, describing incidents dated April 16, 2004 to November 1, 2005.

Most-cited components

Power Train 2 complaints
Fuel/Propulsion System 1 complaint
Service Brakes 1 complaint
Suspension 1 complaint

Newest complaints

ODI #10142810 · Filed November 15, 2005
DT: THE CONTACT RECEIVED NHTSA RECALL 04V465000 CONCERNING THE FUEL TANK STORAGE ASSEMBLY. THWERE NOT AVAILABLE. THE DEALERSHIP TOLD HER THE PARTS MAY NOT BE AVAILABLE FOR AT LEAST SIX MORE WEEKS. *NM.
ODI #10090051 · Filed October 6, 2004
CONSUMER JUST PURCHASED A NEW HARLEY-DAVIDSON, AND THE FRONT WHEEL BEARINGS WERE DEFECTIVE, CAUSING THE FRONT WHEEL TO WOBBLE. THIS PROBLEM OCCURRED ONCE AT 844 MILES. THEN, IT HAPPENED AGAIN AT 1149 MILES. *AK THE CONSUMER HAD THE MOTORCYCLE REPAIRED SPACER WAS IN THE FRONT WHEEL . *TC
ODI #10081419 · Filed July 30, 2004
THE REAR BRAKES WERE NOT PROPERLY LUBRICATED, WHICH RESULTED IN THE REAR BRAKES LOCKING UP AND CAUSING CONTROL PROBLEMS. *AK *SC *JB

Read all 5 complaints

HARLEY-DAVIDSON/FUEL CANISTERS

NHTSA #04V465000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported September 30, 2004 · HARLEY-DAVIDSON MOTOR COMPANY

Potentially affected: 2,828 vehicles

Owners notified April 14, 2005 · Vehicles built June 22, 2004 – July 29, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTORCYCLES, A CONDITION OCCURS THAT COULD ALLOW PRESSURE TO BUILD UP IN THE FUEL TANK. ON FUEL INJECTED VEHICLES, THIS CONDITION COULD CAUSE FUEL TO SPRAY OUT UNEXPECTEDLY WHEN THE FUEL CAP IS REMOVED. ON CARBURETED VEHICLES, EXCESSIVE FUEL COULD BE TRANSFERRED TO THE CARBURETOR, WHICH WOULD EVENTUALLY ALLOW FUEL TO DRIP FROM THE AIR CLEANER.

Safety consequence

THESE SITUATIONS COULD CAUSE SERIOUS PERSONAL INJURY OR CREATE A FIRE HAZARD FOR PERSONS OR PROPERTY ON OR NEAR THE MOTORCYCLE.

Manufacturer remedy

DEALERS WILL TEST EACH CANISTER FOR BLOCKAGE, THEN REPLACE AS NECESSARY. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

HARLEY-DAVIDSON/FUEL HOSE

NHTSA #04V052000 · Fuel System, Gasoline — Fuel Injection System · NHTSA notice

Reported February 2, 2004 · HARLEY-DAVIDSON MOTOR COMPANY

Potentially affected: 4,593 vehicles

Harley-Davidson campaign 0112 · Owners notified February 12, 2004 · Vehicles built September 2, 2003 – November 9, 2003 (per NHTSA)

Defect description

ON CERTAIN FUEL INJECTED MOTORCYCLES, THE RUBBER FUEL HOSE HAS THE POTENTIAL TO SEPARATE FROM THE INNER LINER CAUSING A FUEL LEAK.

Safety consequence

THIS COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL LINE ASSEMBLY. OWNER NOTIFICATION BEGAN ON FEBRUARY 12, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680.

Notes

HARLEY-DAVIDSON NO. 0112.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2004 Harley-Davidson Dyna Glide. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

5 owner complaints have been filed with NHTSA for the 2004 Harley-Davidson Dyna Glide.

Fuel System, Gasoline

ODI #10142810

Incident: November 1, 2005 · Filed: November 15, 2005

DT: THE CONTACT RECEIVED NHTSA RECALL 04V465000 CONCERNING THE FUEL TANK STORAGE ASSEMBLY. THWERE NOT AVAILABLE. THE DEALERSHIP TOLD HER THE PARTS MAY NOT BE AVAILABLE FOR AT LEAST SIX MORE WEEKS. *NM.

Suspension

ODI #10090051

Incident: August 28, 2004 · Filed: October 6, 2004

CONSUMER JUST PURCHASED A NEW HARLEY-DAVIDSON, AND THE FRONT WHEEL BEARINGS WERE DEFECTIVE, CAUSING THE FRONT WHEEL TO WOBBLE. THIS PROBLEM OCCURRED ONCE AT 844 MILES. THEN, IT HAPPENED AGAIN AT 1149 MILES. *AK THE CONSUMER HAD THE MOTORCYCLE REPAIRED SPACER WAS IN THE FRONT WHEEL . *TC

Service Brakes, Hydraulic

ODI #10081419

Incident: July 2, 2004 · Filed: July 30, 2004

THE REAR BRAKES WERE NOT PROPERLY LUBRICATED, WHICH RESULTED IN THE REAR BRAKES LOCKING UP AND CAUSING CONTROL PROBLEMS. *AK *SC *JB

Power Train

ODI #10075915

Incident: June 8, 2004 · Filed: August 5, 2004

WHILE MOTORCYCLE WAS PARKED CONSUMER NOTICED FLUID LEAKING FROM UNDERNEATH. CONSUMER CONTACTED THE DEALER TO MAKE AN APPOINTMENT FOR REPAIRS. *AK THE LEAK OCCURRED IN FRONT OF THE REAR TIRE WHICH RESULTED IN SOME OF THE FLUID GETTING ON THE TIRE. THE DEALER HAS WORKED ON THE TRANSMISSION 3 TIMES AND HAS REPLACED 6 O-RINGS IN AN ATTEMPT TO CORRECT THE PROBLEM. THE SHIFTER PEG FELL OF WHILE THE CONSUMER WAS ON THE WAY TO THE DEALER. THIS ALMOST CAUSED AN ACCIDENT BECAUSE THE DRIVER WAS UNABLE TO SHIFT THE MOTORCYCLE. *NM

Power Train

ODI #10067935

Incident: April 16, 2004 · Filed: April 27, 2004

I WAS RIDING DOWN THE INTERSTATE AND THE CLUTCH BOLT FLEW OUT OF THE DERBY COVER I WAS LUCKY THAT IT FLEW OUT INSTED OF IN THE GEAR THAT WOULD HAVE LOCKED MY BACK WHEELE UP AND I WOULD HAVE CRASHED I TOOK IT TO THE HARLEY SHOP OF WYTHEVILLE VA AND THEY TOLD ME IT WAS UNCHECKED BY THE HARLEY SHOP OF ROANOKE VA OF WERE I PURCHASED IT FROM THE BIKE IS A 2004 MODEL AND HAS1600 MILES ON IT. *AK

Other Harley-Davidson Dyna Glide model years

Check your 2004 Harley-Davidson Dyna Glide VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Harley-Davidson Dyna Glide at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Harley-Davidson VIN