NHTSA vehicle safety data

2004 Gulf Stream Conquest Recalls & Complaints

The 2004 Gulf Stream Conquest has 3 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Gulf Stream dealer.

NHTSA recall and complaint data for the 2004 Gulf Stream Conquest. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Gulf Stream Conquest owner complaints

Owners have filed 3 complaints with NHTSA about the 2004 Gulf Stream Conquest, describing incidents dated November 4, 2004 to September 16, 2008.

Most-cited components

Suspension 2 complaints
Equipment 1 complaint
Seats 1 complaint
Steering 1 complaint

Newest complaints

ODI #10246278 · Filed October 21, 2008
TL*THE CONTACT OWNS A 2004 GULF STREAM CONQUEST. THE VEHICLE HAS A DOMETIC REFRIGERATOR, MODEL RM2852. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08E032000 (EQUIPMENT). THE MANUFACTURER STATED THAT THEY WOULD NOT PAY FOR THE REPAIR BECAUSE HIS VEHICLE WAS NO LONGER UNDER…
ODI #10123696 · Filed May 31, 2005
MY WIFE ( IS DISABLED AND OUR RV IS THE ONLY MODE OF TRANSPORTATION ) AND WE HAD TAKEN OUR LAST TRIP TO VERMONT IN OUR 2004 GULF STREAM CONQUEST, AND WE WERE ON I-91 AND THERE IS SEVERAL MILES OF THE ROAD WHICH HAS BEEN BEATEN BADLY AND THE RV WAS BOUNCING AND VIBRATING THE WHOLE VEHICLE TO THE…
ODI #10104386 · Filed December 23, 2004
WHEN YOU DRIVE THIS MOTORHOME AND ATTEMPT TO NEGOTIATE A CURVE, IT IS REALLY HARD TO KEEP THE MOTORHOME IN IT'S OWN LANE. I DRIVE BETWEEN 55-58 MPH.AND SLOW DOWN WHEN I FEEL THE ROAD CONDITIONS WARRANT, THE MOTORHOME FEELS AS IF IT WANTS TO ROLL OVER, I HAVE SPOKE WITH OTHERS WHO SHARE THE SAME…

Read all 3 complaints

ELECTRICAL WIRING

NHTSA #12V105000 · Electrical System — Wiring · NHTSA notice

Reported March 20, 2012 · GULF STREAM COACH, INC.

Potentially affected: 1,502 vehicles

Gulf Stream campaign 12WG-0105 · Owners notified April 4, 2012 · Vehicles built January 5, 2001 – March 14, 2005 (per NHTSA)

Defect description

GULF STREAM IS RECALLING CERTAIN MODEL YEAR 2001-2005 CLASS A AND C RECREATIONAL VEHICLES, BUILT ON FLOORPLANS 6316, 6317, 6330, 8325 AND 8328, DUE TO A SECTION OF UNSECURED WIRING. SEE THE ABOVE LIST FOR THE MODELS AFFECTED. THE WIRING WITHIN THE RACEWAY MAY NOT BE PROPERLY SECURED LEADING TO WEAR AND POTENTIAL HEAT DEVELOPMENT BETWEEN THE EXPOSED WIRING AND HEATED REFRIGERATOR COILS.

Safety consequence

THIS CONDITION COULD LEAD TO FAILURE OF THE 110 VOLT ELECTRICAL WIRING ROUTED TO THE MICROWAVE CABINET, INCREASING THE RISK OF FIRE, PERSONAL INJURY, OR PROPERTY DAMAGE.

Manufacturer remedy

GULF STREAM WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 4, 2012. OWNERS MAY CONTACT GULF STREAM AT 1-800-482-6456.

Notes

GULF STREAMS RECALL NUMBER IS 12WG-0105.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATIONS VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #08V411000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported August 15, 2008 · GULF STREAM COACH, INC.

Potentially affected: 26,847 vehicles

Owners notified October 31, 2008 · Vehicles built June 1, 2003 – October 31, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

GULF STREAM IS RECALLING 26,847 MY 2003-2006 RECREATIONAL VEHICLES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

GULF STREAM IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR GULF STREAM AT 1-574-773-7761.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GULF STREAM/GFCI RECEPTACLES

NHTSA #03V532000 · Electrical System · NHTSA notice

Reported December 12, 2003 · GULF STREAM COACH, INC.

Potentially affected: 574 vehicles

Vehicles built July 23, 2003 – September 4, 2003 (per NHTSA)

Defect description

ON CERTAIN TRAVEL TRAILERS AND FIFTH WHEELS EQUIPPED WITH EZ-FLO GROUND FAULT CIRCUIT INTERRUPTER (GFCI) RECEPTACLES, THE RECEPTACLE MAY NOT TRIP WHEN A GROUND FAULT IS PRESENT.

Safety consequence

THIS COULD RESULT IN RISK OF ELECTRICAL SHOCK AND CAUSE A FIRE HAZARD.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE GFCI RECEPTACLE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DECEMBER 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT GULF STREAM AT 1-800-289-8787.

Notes

CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2004 Gulf Stream Conquest. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2004 Gulf Stream Conquest.

Equipment

ODI #10246278

Incident: September 16, 2008 · Filed: October 21, 2008

TL*THE CONTACT OWNS A 2004 GULF STREAM CONQUEST. THE VEHICLE HAS A DOMETIC REFRIGERATOR, MODEL RM2852. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08E032000 (EQUIPMENT). THE MANUFACTURER STATED THAT THEY WOULD NOT PAY FOR THE REPAIR BECAUSE HIS VEHICLE WAS NO LONGER UNDER WARRANTY. HE WOULD HAVE TO PAY FOR THE EXPENSES OUT OF POCKET. THERE HAD BEEN NO FAILURE TO DATE. THE PART NUMBER AND PURCHASE DATE WERE UNKNOWN.

Suspension; Seats

ODI #10123696

Incident: April 25, 2005 · Filed: May 31, 2005

MY WIFE ( IS DISABLED AND OUR RV IS THE ONLY MODE OF TRANSPORTATION ) AND WE HAD TAKEN OUR LAST TRIP TO VERMONT IN OUR 2004 GULF STREAM CONQUEST, AND WE WERE ON I-91 AND THERE IS SEVERAL MILES OF THE ROAD WHICH HAS BEEN BEATEN BADLY AND THE RV WAS BOUNCING AND VIBRATING THE WHOLE VEHICLE TO THE POINT MY WIFE HAD TO HOLD ONTO THE DINETTE TABLE SHE WAS SITTING AT( DRIVERS SIDE FACING FORWARD WITH SEATBELTS ON). THE SUSPENTION/ SHOCKS ON THIS RV DIDN'T DO ANYTHING TO TAKE OUT THE BUMPS AND SHIMMY'S AND THE SEAT MY WIFE WAS SITTING IN JUST COMPRESSED EVEN MORE AND BOTTOMED OUT AND HURT HER NECK FROM THE JARRING AND BOUNCING THAT THERE ARE OTHER SECTIONS OF THE ROAD WHICH ARE ALSO ROUGH AND THE VEHICLE BOUNCES AND WANTS TO CHANGE LANES ON ME. I'M HAVING SOME BILSTEIN SHOCKS INSTALLED AND WE CONTACTED THE GULF STREAM TO COMPLAIN ABOUT THE SEATING AND TELL THEM ABOUT THE RIDE WE ASKED THEM TO REPLACE THOSE WITH SOMETHING MORE SUPPORTIVE BUT THEY SAID THEY DIDN'T MAKE ANY THING WITH ACTUAL COIL SPRINGS OR A STIFFER FOAM PADDING. THEY CONTACTED A NEW LOCAL DISTRIBUTOR OF THEIRS WHO WOULD LOOK AT THE SEATS. WE ASKED IF THE EXISTING BARREL CHAIR COULD BE REPLACED WITH NECK SUPPRT BUT THAT THEY DIDN'T HAVE ANYTHING AND IF WE CHANGED ANYTHING WE COULD "VOID THE WARRENTY ON THE COACH". I BROUGHT THE RV TO THIS DEALER WHO WAS THE SERVICE MANAGER AND HE SAT IN THE SEAT WHICH BOTTOMED OUT(HE SAID HE WAS AROUND 300 #'S) AND SAID ALL THESE SEATS ARE UNCOMFORTABLE AND THAT YOU CAN'T SIT IN THESE SEATS FOR LONG WITH OUT THE FOAM COLLAPSING. HE ASKED ME ABOUT MY WIFE'S WEIGHT AND THEN MADE A COMMENT ABOUT THE FACT THAT GOVERMENT STANDARDS FOR SEATING IS ONLY 150 LBS. HE WENT ON TO SAY THAT HE DIDN'T BELIEVE THERE WAS ANY TYPE OF SEPARATION OR ACTUAL DEFECT IN THE SEAT CUSHION. THE CHANGING OF THE SHOCKS SOUNDED GOODAND MAYBE GOING TO A VAN CONVERSTION SHOP OR CALLING A MOBILITY COMPANY WOULD BE OUR BEST BET BUT THIS WAS ALL AN UPGRADE AND NOT GULF STREAM'S RESPONSIBILITY.

Steering; Suspension

ODI #10104386

Incident: November 4, 2004 · Filed: December 23, 2004

WHEN YOU DRIVE THIS MOTORHOME AND ATTEMPT TO NEGOTIATE A CURVE, IT IS REALLY HARD TO KEEP THE MOTORHOME IN IT'S OWN LANE. I DRIVE BETWEEN 55-58 MPH.AND SLOW DOWN WHEN I FEEL THE ROAD CONDITIONS WARRANT, THE MOTORHOME FEELS AS IF IT WANTS TO ROLL OVER, I HAVE SPOKE WITH OTHERS WHO SHARE THE SAME CONCERNS. IF YOU GET. E ONTO A ENTRANCE RAMP THAT IS A LOOP, AND THE SUGGESTED SAFE SPEED IS "30" MPH DON'T DO IT, MAYBE 15-20- MPH, I HAVE DRIVEN MANY VEHICLES IN MY LIFETIME AND THIS MOTORHOME SCARES ME. IT IS EQUIPPED WITH 19.5 INCH TIRES, AND THERE IS TO MUCH HEIGHT AND TOP WEIGHT FOR THE TIRES AND SUSPENSION TO SUPPORT ON A STABLE BASE. I HAVE YET TO CRASH BUT I KNOW IT'S ONLY A MATTER OF TIME BEFORE I CRASH AND BURN. I AM A RETIRED POLICE OFFICER AND I WOULD BE MORE THAN GLAD TO TAKE ONE OF YOUR STAFF FOR A RIDE, AND LET THEM DRIVE SO THEY CAN EXPERIANCE THE AMUSEMENT PARK HANDLING OF THIS MOTORHOME. # OF FAILURES WILL INDICATE TIMES OF UNSAFE HANDLING.THE UNIT IS A GULFSTREAM ENDURA 6340 EH 2 SLIDES. *AK

Other Gulf Stream Conquest model years

Check your 2004 Gulf Stream Conquest VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Gulf Stream Conquest at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Gulf Stream VIN