NHTSA vehicle safety data

2003 GMC Yukon XL 1500 Recalls & Complaints

The 2003 GMC Yukon XL 1500 has 1 NHTSA recall campaign and 63 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2003 GMC Yukon XL 1500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 GMC Yukon XL 1500 owner complaints

Owners have filed 63 complaints with NHTSA about the 2003 GMC Yukon XL 1500, describing incidents dated January 3, 2004 to December 9, 2017.

Most-cited components

Electrical System 24 complaints
Service Brakes 17 complaints
Engine 8 complaints
Vehicle Speed Control 8 complaints
Steering 7 complaints
Power Train 6 complaints

Of the 63 complaints on file, 5 report a crash; across all 63 complaints, owners report 8 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11054219 · Filed December 12, 2017
VEHICLE RANDOMLY GOES INTO REDUCE ENGINE POWER MODE AND STALLS WHILE DRIVING. THIS HAS HAPPENED MULTIPLE TIMES WHILE DRIVING ON A HIGHWAY AND GOING UP A HILL WHERE IT NEARLY CAUSED A THREE CATASTROPHIC ACCIDENTS. BASIC RESEARCH SHOWS THAT GM HAS KNOWN ABOUT THIS ISSUE SINCE THE VEHICLES WERE A FEW…
ODI #10940042 · Filed January 5, 2017
BRAKE LINES CORRODED RESULTING IN LOSS OF BRAKES AND REAR ENDING SCHOOL BUS. REPLACED ALL BRAKE LINES AT MY COST AS WELL AS THE DAMAGE TO THE FRONT END OF THE TRUCK. NOW, THE KNOWN ABS BRAKE SENSOR ISSUE IS ACTIVATING THE ABS AT LOW SPEEDS.
ODI #10874699 · Filed June 16, 2016
TL* THE CONTACT OWNS A 2003 GMC YUKON XL 1500. THE CONTACT MENTIONED THAT THE PREVIOUS OWNER OF THE VEHICLE EXPERIENCED A FAILURE WITH THE REDUCED ENGINE POWER WARNING INDICATOR. THE DEALER REPLACED THE THROTTLE BODY, BUT THE FAILURE CONTINUED BEFORE THE CONTACT OWNED THE VEHICLE. THE CONTACT…

Read all 63 complaints

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2003 GMC Yukon XL 1500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

63 owner complaints have been filed with NHTSA for the 2003 GMC Yukon XL 1500.

Electrical System

ODI #11054219

Incident: December 9, 2017 · Filed: December 12, 2017

VEHICLE RANDOMLY GOES INTO REDUCE ENGINE POWER MODE AND STALLS WHILE DRIVING. THIS HAS HAPPENED MULTIPLE TIMES WHILE DRIVING ON A HIGHWAY AND GOING UP A HILL WHERE IT NEARLY CAUSED A THREE CATASTROPHIC ACCIDENTS. BASIC RESEARCH SHOWS THAT GM HAS KNOWN ABOUT THIS ISSUE SINCE THE VEHICLES WERE A FEW YEARS OLD AND IT AFFECTS MANY YEARS OF GM VEHICLES. THERE IS A PROBLEM WITH BAD GROUNDING CONNECTORS RELATED TO THE THROTTLE BODY SENSOR AND AND WIRING HARNESS.

Service Brakes

ODI #10940042

Crash

Incident: January 5, 2017 · Filed: January 5, 2017

BRAKE LINES CORRODED RESULTING IN LOSS OF BRAKES AND REAR ENDING SCHOOL BUS. REPLACED ALL BRAKE LINES AT MY COST AS WELL AS THE DAMAGE TO THE FRONT END OF THE TRUCK. NOW, THE KNOWN ABS BRAKE SENSOR ISSUE IS ACTIVATING THE ABS AT LOW SPEEDS.

Electrical System; Engine

ODI #10874699

Incident: March 10, 2016 · Filed: June 16, 2016

TL* THE CONTACT OWNS A 2003 GMC YUKON XL 1500. THE CONTACT MENTIONED THAT THE PREVIOUS OWNER OF THE VEHICLE EXPERIENCED A FAILURE WITH THE REDUCED ENGINE POWER WARNING INDICATOR. THE DEALER REPLACED THE THROTTLE BODY, BUT THE FAILURE CONTINUED BEFORE THE CONTACT OWNED THE VEHICLE. THE CONTACT EXPERIENCED THE WARNING LIGHT RANDOMLY FLASHING, WHICH DRASTICALLY REDUCED THE SPEED TO LESS THAN 20 MPH. THE CONTACT HAD TO CONSTANTLY TURN OFF AND RESTART THE VEHICLE, BUT THE FAILURE CONTINUED TO PROGRESS RANDOMLY. THE DEALER REPLACED THE WIRING, 02 SENSOR, THE THROTTLE BODY WAS REPLACED A SECOND TIME, THE BATTERY, AND THE ALTERNATOR. THE REPAIRS FAILED TO PROVIDE A PERMANENT SOLUTION AND THE WARNING LIGHT CONTINUED TO ILLUMINATE FOR THE REDUCED ENGINE POWER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 188,000.

Electronic Stability Control (ESC)

ODI #10823872

Incident: January 3, 2015 · Filed: February 2, 2016

ANTILOCK BRAKES BEGAN TO APPLY THEMSELVES IN RIGHT HAND TURNS GOING UP AND DOWN HILL AT SPEEDS UP TO 45 MPH. ALMOST CAUSES ME TO LOOSE CONTROL OF VEHICLE. HAD TO TAKE TO HURRICANE CHEVROLET SEVERAL TIMES TO GET FIXED COST ALMOST $4000

Power Train; Electrical System; Engine

ODI #10818211

Incident: December 15, 2015 · Filed: January 5, 2016

REDUCED ENGINE POWER MODE ON HWY AT 70 MPH

Steering; Electrical System; Service Brakes

ODI #10778119

Incident: September 28, 2015 · Filed: September 28, 2015

WHILE TRAVELING TO WORK MY VEHICLES CHECK ENGINE LIGHT CAME ON AND THE REDUCED POWER WARNING CAME ON AT WHICH TIME I HAD COMPLETE LOSS OF ACCELERATION, COMPLETE LOSS OF BRAKING, AND COMPLETE LOSS OF STEERING POWER. I THEN HAD TO COAST TO A STOP AND ATTEMPTED TO RESTART THE VEHICLE 6 TIMES BEFORE I WAS ABLE TO GET THE REDUCED POWER WARNING TO GO OFF AND WAS ABLE TO DRIVE ALTHOUGH THE CHECK ENGINE LIGHT STAYED ON. THIS IS THE 2ND TIME THIS HAS HAPPENED TO ME IN 2 DAYS WITH THE LOSS OF POWER. I HAVE HAD THE REDUCED POWER WARNING ON NUMEROUS OCCASIONS YEARS PAST BUT NEVER HAVE I LOST TOTAL / ABSOLUTE POWER TO CONTROL THE VEHICLE, THIS IS A TOTAL DEATH TRAP FOR ANYONE WHO HAS HAD THIS EXPERIENCE, ESPECIALLY ON THE FREEWAY OR HIGHWAYS AT HIGH SPEEDS. I HAVE READ NUMEROUS ACCOUNTS OF THIS SAME ISSUE AFFECTING OTHER GMC OWNERS AND HAVE SEEN NO RESOLUTIONS OR ANY RECALLS FROM GMC. I HAVE ALREADY REPLACED THE THROTTLE HOUSING AND HARNESS COMPONENTS, ACCELERATION PEDAL SENSOR AND YET THE ISSUE CONTINUES, SOMEONE IS GOING TO ( DIE ) BECAUSE OF GMC'S LACK OF CONCERN AND RESPONSIBILITY TO OWNERS OF THEIR PRODUCTS. I WILL NEVER EVER OWN ANOTHER GMC ASSOCIATED PRODUCT.

Power Train; Vehicle Speed Control; Fuel/Propulsion System

ODI #10775355

Crash 4 injuries

Incident: September 17, 2015 · Filed: September 23, 2015

THERE IS AN ERROR MESSAGE THAT DISPLAYS ON THE DASH FOR MYSELF AND THOUSANDS OF OTHERS WHO OWN GMC/CHEVY TRUCKS WITH THESE MOTORS. THEY HAVE A DEFECTIVE THROTTLE POSITION SENSOR WITH THE TRUCK WHERE IT SAYS "REDUCED ENGINE POWER". I'VE FOUND 2 TECHNICAL SERVICE BULLETINS THAT SOMEWHAT ADDRESS THE ISSUE, BUT MANY PEOPLE TAKE THEIR TRUCKS TO MECHANICS AND DEALERSHIPS TO GET THE ISSUE FIXED AND SPEND THOUSANDS OF DOLLARS IN REPAIRS AND TROUBLESHOOTING TO GET THE ISSUE RESOLVED, TO NO AVAIL. THE 2 TECHNICAL SERVICE BULLETINS THAT I FOUND WERE #PIP3089B (DATED 10/31/2006) AND #PIP3042A (DATED 8/30/2004). I'VE SEEN ON MANY MANY FORUM POSTS ABOUT THIS ISSUE AND POSSIBLE FIXES, WHICH WHEN I READ DEEPER INTO THEM, SEEM TO NOT BE TRUE FIXES.

Vehicle Speed Control; Unknown or Other; Engine

ODI #10763770

Incident: September 14, 2015 · Filed: September 15, 2015

I KEEP HAVING THE DISPLAY SAY "REDUCED ENGINE POWER". I'LL BE DRIVING ON THE HIGHWAY, DOING 65 IN RUSH HOUR TRAFFIC, WHEN ALL OF THE SUDDEN THE ACCELERATOR NO LONGER ACCELERATES AND IT DISPLAYS "REDUCED ENGINE POWER" ON THE GAUGE CLUSTER DISPLAY. FROM WHAT I'VE SEEN ONLINE IT APPEARS TO BE AN ISSUE WITH THE THROTTLE POSITION SENSOR ON THOUSANDS OF OTHER SIMILAR VEHICLES WITH THE SAME ENGINE, CHEVY SUBURBAN'S, SILVERADO'S, TAHOE'S, ETC. I REPLACED THE THROTTLE POSITION SENSOR AND THE HARNESS (BECAUSE I HEARD THE HARNESS MIGHT ALSO BE AN ISSUE) AND I AM STILL HAVING THE SAME PROBLEM WITH MY TRUCK. IT HAS DONE IT OVER A DOZEN TIMES ON ONE TRIP BACK FROM WORK (80 MILES FOR ME). I HAVE TO PULL OVER TO THE SIDE OF THE ROAD (IF POSSIBLE) AND TURN OFF THE TRUCK, THEN WAIT A SHORT PERIOD OF TIME, THEN TURN THE TRUCK BACK ON. THIS USUALLY FIXES THE ISSUE, BUT IT DID NOT HELP ME WHEN IT HAPPENED TO ME IN THE TUNNEL AND I WAS GOING 5 MPH (TOP SPEED DURING THE "REDUCED ENGINE POWER" MODE, ONCE YOUR DRIFTING STOPS (BECAUSE YOU DRIFT, IT DOESN'T ENGAGE THE BRAKES). I WAS EXTREMELY WORRIED THAT I WOULDN'T MAKE IT OUT OF THE TUNNEL WITHOUT GET REAR ENDED, AND ONCE I MADE IT OUT, I WAS JUST OUTSIDE OF THE TUNNEL AWAITING ROADSIDE ASSISTANCE, IT WAS VERY FRIGHTENING, WITH MY DAUGHTER IN THE CAR.

Service Brakes

ODI #10726547

Crash

Incident: June 17, 2015 · Filed: June 22, 2015

IWAS DRIVING AT LOW SPEED WENT TO STOP AT STOP SIGN WHEN BRAKE PEDDLE WENT TO FLOOR.I CRASHED INTO STOP SIGN TO STOP . TRUCK WAS TOWED TO DEALER. I WAS TOLD TO MAJOR BRAKE LINE BURST. TRUCK IS NOW AT DEALER BEING FIXED. AT A PRICE OF 2800.00. SOMETHING HAS TO BE DONE. THIS CAN'T GO ON ANY LONGER.

Power Train; Vehicle Speed Control

ODI #10690082

Incident: September 14, 2014 · Filed: February 23, 2015

VEHICLE HAS BEEN SERVICED SEVERAL TIMES SINCE FIRST OCCURRENCE IN SEPTEMBER 2014. "REDUCED ENGINE POWER" AND SERVICE ENGINE SOON SIGNALS APPEAR ON VEHICLE PANEL CAUSING ENGINE POWER TO BE REDUCED IN A MATTER OF SECONDS. HAS HAPPENED TO ME GOING 10MPH, 55MPH, AND 70MPH ON HIGHWAY, CAUSING A NEAR REAR COLLISION BECAUSE I LOST POWER SO QUICKLY. I HAVE HAD IT SERVICED 6 OR 7 TIMES SINCE SEPTEMBER 2014 AND THIS ISSUE IS NOT GETTING RESOLVED. THROTTLE BODY SENSOR REPLACED TWICE, THROTTLE BODY HARNESS REPLACED, ALL WIRES, AND SENSORS HAVE BEEN CLEANED AND THOROUGHLY INSPECTED. REDUCED ENGINE POWER OCCURS WEEKLY EVEN AFTER BEING SERVICED. *TR

Other GMC Yukon XL 1500 model years

Check your 2003 GMC Yukon XL 1500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Yukon XL 1500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN