2001 GMC Sierra 2500 HD Recalls & Complaints

Incident: October 5, 2016 · Filed: December 6, 2016

VEHICLE STALLS AND SHUTS OFF WHILE DRIVING AND IDLE. SOMETIMES IT STARTS BACK UP IMMEDIATELY, OTHER TIMES IT WILL JUST CRANK OVER BUT WILL NOT START. AFTER LETTING IT SIT SOMETIMES 5 TO 20 MINUTES AT A TIME IT WILL THEN START BACK UP. ALL RESEARCH AND ISSUES WITH THE VEHICLE INDICATE A MANUFACTURER RECALL OF A CRANKSHAFT POSITION SENSOR. THE VEHICLE WILL STALL OR SHUT OFF AT RANDOM WHETHER IT'S IN MOTION DOWN THE HIGHWAY IN THE MIDDLE OF A INTERSECTION OR AT A STOP SIGN . I HAVE ALMOST BEEN T-BONES DUE TO THE VEHICLE STALLING IN THE MIDDLE OF THE INTERSECTION AND I HAVE ALSO HAD TO REPLACE MY DRIVERS MIRROR DUE TO THE VEHICLE STALLING ON THE INTERSTATE AND NEARLY BEING HIT BY ANOTHER VEHICLE. *TR

Incident: March 10, 2016 · Filed: March 23, 2016

HAVING HEARD ABOUT MICHELIN RECALLS I CHECKED THE TIRES ON MY 2001 GMC SIERRA PICKUP. I HAVE MICHELIN LT245/75R16 120/116R XC LT4 TIRES WITH LESS THAN 20,000 MILES WEAR. TWO OF THEM ARE "CRUMBLING" OUT 1 1/2 INCH ABOVE THE RIM. YOU CAN SEE FIBERS IN THE HOLES. THERE ARE CRACKS EVERYWHERE ON ALL THE TIRES. THEY HAVE BEEN COVERED FROM THE SUN. GRANTED THE TIRES HAVE AGE BUT I HAVE NEVER SEEN "CRUMBLING" BEFORE.

Incident: January 30, 2016 · Filed: February 4, 2016

TL* THE CONTACT OWNS A 2001 GMC 2500 HD. WHILE DRIVING APPROXIMATELY 35 MPH AND DEPRESSING THE BRAKE PEDAL, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE. THE CONTACT ENGAGED THE EMERGENCY BRAKE AND PLACED THE VEHICLE IN PARK. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS DIAGNOSED THAT THE DISTRIBUTOR BRAKE BLOCK HAD EXCESSIVE RUST AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. THE VIN WAS UNAVAILABLE.

Incident: September 1, 2010 · Filed: September 18, 2015

IGNITION SWITCH FAULTY MY CAR NOT IN RECALL TAKES NUMEROUS ATTEMPTS TO START AND WHEN STARTED AIRBAG CONTINUOUSLY LIGHTS UP WHEN DRIVING.

Incident: May 8, 2015 · Filed: May 9, 2015

KUHMO ROAD VENTURE AT TIRE 245/75R/16 TREAD SEPARATION. THIS IS THE SECOND INCIDENT WITH TIRES UNDER 10,000 MILES FOR THIS BRAND AND SIZE TIRE. THE FIRST INCIDENT TORE UP THE SIDE OF MY PICKUP WHILE TOWING A 5TH WHEEL TRAILER. WHEN THE SECOND INCIDENT OCCURRED, I FELT A VIBRATION IN THE TRUCK AND PULLED INTO A ROADSIDE REST AREA. AFTER I STOPPED AND WAS ALMOST OUT OF THE TRUCK, I HEARD A LOUD POP AND THE TIRE TREAD HAD SEPARATED RIPPING THE SIDE OF THE TIRE OUT. AGAIN, TOWING A 5TH WHEEL TRAILER. IN THE FIRST INCIDENT KUHMO ARGUED FOR THREE MONTHS THAT I HAD DRIVEN THE TIRE FLAT. THEY FINALLY AGREED TO REPLACE THE TIRE AND REPAIR MY TRUCK. THESE TIRES ARE UNSAFE FOR HIGHWAY USE.

Incident: July 12, 2013 · Filed: August 21, 2014

ON THE DURAMAX DIESEL, WHILE UNDER A LOAD (TOWING, FULL BED) FUEL LINES COLLAPSE CAUSING SEVERAL CHECK ENGINE LIGHTS AND VEHICLE TO GO INTO "LIMP" MODE. MUST RELEASE VACUUM IN FUEL SYSTEM (BY LOOSENING THE FUEL FILTER THEN RE-BLEEDING THE FUEL SYSTEM) IN ORDER FOR THE CODE TO GO OFF. HAPPENED SEVERAL TIMES, ONCE WHILE TOWING UP HILL. IF THIS HAD CAUSED AN ACCIDENT, I WOULD HAVE BEEN A GM SHARE HOLDER. VEHICLE HAS STALLED OUT SEVERAL TIMES IN THE WINTER DUE TO A COMBINATION OF THE WINTER DIESEL AND THE VACUUM FUEL SYSTEM. ONCE WHILE ON AN ICY ROAD, ON MY WAY TO WORK AT 4AM. GM NEEDS TO RECALL THIS. *TR

Incident: July 1, 2014 · Filed: July 21, 2014

I CONNECTED MY CAMPER TO THE TRUCK. PROCEEDED TOWARD THE STREET DRIVING ON THE DRIVEWAY. I APPLIED THE BRAKE AND FELT A THUMP AT MY FOOT THAT'S WAS APPLYING THE BRAKE. THE BRAKE PEDAL WENT SLOWLY TO THE FLOOR. I WAS ABLE TO STOP, LOOKED UNDER THE TRUCK AND NOTICED BRAKE FLUID FLOWING FROM UNDERNEATH THE TRUCK. APON INSPECTION MY BRAKE LINES WERE TOTALLY RUSTED. THE TRUCK IS IN THE REPAIR FACILITY AS I WRITE THE COMPLAINT. THE TRUCK BODY IS IN GREAT SHAPE EXCEPT FOR THE BRAKE LINES. BETTER REGULATIONS NEED TO BE MET REGARDING BRAKE LINE. PLEASE HELP. *TR

Incident: June 1, 2013 · Filed: June 19, 2014

TRUCK JUST SHUTS DOWN WHILE DRIVING, COAST TO SAFEST PULL OVER, TURN KEY OFF, SIT AND WAIT A MINUTE, SOMETIMES LONGER, TRY TO START ENGINE, USUALLY STARTS, SOMETIMES LONGER WAITS. OTHER THEN THE APPARENT SAFETY POSSIBILITIES, DIDN'T THINK MUCH ABOUT IT. WELL, THIS WOULD HAPPEN EVERY ONCE & AWHILE. FOR OVER A YEAR NOW, LAST 3 MONTHS WITH INCREASING OCCURRENCES. TRUCK OUT OF WARRANTY, SO I HAVE IT SERVICED LOCALLY, DAVE COTE AUTOMOTIVE, A GM TRAINED TECHNICIAN WITH 30 YEARS EXPERIENCE, PROBLEM DIAGNOSED, CRANKSHAFT POSITION SENSOR AT THE REAR OF THE 8.1 L ENGINE. TECHNICIAN COTE HAS EXTREMELY DIFFICULT TIME REMOVING SENSOR, AT THIS WRITING STILL NO WORD. COTE GOES ON LINE TO SEEK ONLINE HELP FROM OTHER TECH'S AND DISCOVERS A SUPPOSED RECALL FOR MY YEAR AND MODEL TRUCK, THAT I NEVER RECEIVED. I ENQUIRE AT THE LOCAL DEALER VENDEHTTI MOTORS, FRANKLIN, MA ABOUT IT AFTER SUPPLYING THE VIN NUMBER, THEY TELL ME THAT MY VIN IS NOT INCLUDED WITH THE RECALL? I SAY TO THEM THAT "HOW CAN THAT BE WHEN IT IS DOING WHAT THE RECALL WAS FOR" & THEY SAID "THE PROBLEM WAS FIXED AT THE FACTORY BEFORE MY TRUCK WAS MANUFACTURED"? SO I AM ASKING WHY I WILL HAVE TO PAY POSSIBLY THOUSANDS OF DOLLARS THAT I CAN NOT AFFORD AT PRESENT, WHEN OBVIOUSLY THE PROBLEM WAS NEVER FIXED TO BEGIN WITH. SENSOR IN BAD LOCATION. I OWN A SMALL LANDSCAPE MAINTENANCE CO. MOSTLY MOWING & SEASONAL CLEAN-UPS, I WAS EXPECTING TO USE THIS TRUCK TILL I HAD TO RETIRE. IT IS MY SOLE MEANS TO OPERATE PLOWING & LANDSCAPING BUSINESS. I CAN NOT AFFORD A NEW TRUCK. THIS TRUCK HAS LESS THEN 45,000 MILES ON IT, IT IS USED LOCALLY ONLY, LESS THEN 4,000 MI. A YEAR, I HAVE MAINTAINED IT WELL. NO MAJOR ACCIDENTS, LITTLE PLOWING DENTS. CAN SOMEBODY PLEASE HELP ME WITH THIS PROBLEM. IT SEEMS THAT GM IS NOT ONLY HAVING RECENT DIFFICULTIES WITH ITS VEHICLES BUT HAS BEEN HIDING ALLOT FROM THE PUBLIC & GOVERNMENT! *TR

Incident: October 14, 2013 · Filed: October 28, 2013

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. THE CONTACT STATED THAT WHEN TRAVELING UNDER 5 MPH, THE CONTACT STATED THAT THE PEDAL BEGAN TO PULSATE. THE ANTI-LOCK BRAKE SYSTEM ACTIVATED AND THE VEHICLE FAILED TO STOP IMMEDIATELY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

Incident: October 12, 2013 · Filed: October 17, 2013

WE HAD DRIVEN ABOUT 90 MILES FROM OUR MAIN HOUSE TO OUR LAKE HOUSE ON FRIDAY NIGHT-BRAKES WERE FINE. SATURDAY MORNING WE BACKED THE SIERRA UP AND HOOKED UP THE BOAT TO THE HITCH. AFTER HOOKING UP THE BOAT WHILE WE WERE PULLING OUT OF THE DRIVEWAY THE BRAKE PEDAL WENT TO THE FLOOR. WE DROPPED THE BOAT AND DROVE THE SIERRA A FEW MILES TO THE STORE. WHILE AT THE STORE WE NOTICED A LEAK ABOVE THE GAS TANK. THE LEAK WAS BRAKE FLUID AND THE SIERRA TOOK AN ENTIRE BOTTLE OF BRAKE FLUID. WE DROVE IT THE FEW MILES BACK TO THE HOUSE AND GOT THE TRUCK TOWED HOME THE NEXT DAY. WHEN THE GAS TANK WAS DROPPED WE NOTICED RUST SO BAD ON THE FRAME THAT A SCREWDRIVER WENT THRU THE FRAME. THE FRAME COULD HAVE BUSTED APART RIGHT BEHIND THE CAB OF THE TRUCK. WE WERE EXTREMELY LUCKY THAT THERE WERE NO INJURIES. *TR