NHTSA vehicle safety data

2003 GMC Savana 3500 Recalls & Complaints

The 2003 GMC Savana 3500 has 1 NHTSA recall campaign and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2003 GMC Savana 3500. Recall data is refreshed daily from NHTSA.

2003 GMC Savana 3500 owner complaints

Owners have filed 3 complaints with NHTSA about the 2003 GMC Savana 3500, describing incidents dated November 30, 2006 to March 6, 2009.

Most-cited components

Electrical System 2 complaints
Engine 1 complaint
Equipment 1 complaint
Service Brakes 1 complaint
Suspension 1 complaint
Unknown or Other 1 complaint

Of the 3 complaints on file, 2 report a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10262640 · Filed March 21, 2009
VAN WAS BEING DRIVEN EARLY MORNING FOR ABOUT 30 MINUTES. NO RAIN, 45 DEGREE OUTSIDE TEMP., HEADLIGHTS ON. DRIVER FIRST NOTICED DASH LIGHTS FLICKER & ALTERNATOR GAUGE SHOWING A DISCHARGE, THEN THESE ISSUES RETURNED TO NORMAL. THE VAN CONTINUED BEING DRIVEN FOR 15 MINUTES TO DESTINATION W/O FURTHER…
ODI #10230563 · Filed June 11, 2008
TL*THE CONTACT OWNS A 2003 GMC SAVANA 3500. THE CONTACT NOTICED THAT THE HORN IN THE VEHICLE SOUNDED AUTOMATICALLY WHILE PARKED. IN AN ATTEMPT TO STOP THE NOISE, SOMEONE PRESSED THE HORN TO COUNTERACT THE FAILURE. ALMOST IMMEDIATELY, SMOKE BEGAN POURING FROM THE HOOD AND THE POLICE DEPARTMENT WAS…
ODI #10175302 · Filed December 6, 2006
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH UNDER NORMAL ROAD CONDITIONS, THE FRONT WHEEL BEARINGS FROZE UP, AND THE TIRES DID NOT TURN. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO REPLACED THE FRONT WHEEL BEARINGS AND THE BRAKE ROTORS. UPDATED…

Read all 3 complaints

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2003 GMC Savana 3500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2003 GMC Savana 3500.

Engine and Engine Cooling; Electrical System; Equipment; Unknown or Other

ODI #10262640

Fire

Incident: March 6, 2009 · Filed: March 21, 2009

VAN WAS BEING DRIVEN EARLY MORNING FOR ABOUT 30 MINUTES. NO RAIN, 45 DEGREE OUTSIDE TEMP., HEADLIGHTS ON. DRIVER FIRST NOTICED DASH LIGHTS FLICKER & ALTERNATOR GAUGE SHOWING A DISCHARGE, THEN THESE ISSUES RETURNED TO NORMAL. THE VAN CONTINUED BEING DRIVEN FOR 15 MINUTES TO DESTINATION W/O FURTHER ISSUES. UPON DEPARTING VAN, DRIVER NOTICED UNUSUAL SMELL AND WAS TOLD BY ANOTHER PERSON THAT SMOKE AND FIRE WERE COMING FROM UNDERNEATH THE VAN AT ABOUT MIDPOINT. UPON INSPECTION THE DRIVER SAW FLAMES EMANATING FROM SAID POINT UNDERNEATH THE VAN AND LIQUIDS ON THE GROUND. EMERGENCY CALL TO THE FIRE DEPARTMENT WAS MADE & A THIRD PERSON BROUGHT A FIRE EXTINGUISHER TO THE SCENE. FIRE WAS EXTINGUISHED BUT REIGNITED AS THE FIREMEN ARRIVED TO COMPLETE THE JOB. VEHICLE NOT SEVERELY DAMAGED AND NO INJURIES. VEHICLE WAS TOWED FOR INSPECTION. DISCOVERED THE ALTERNATOR CHARGING WIRE TO THE BATTERY HAD NOT ORIGINALLY BEEN SECURED OR SHIELDED PROPERLY AND WAS RUBBING ON A BOLT HEAD SECURING TWO A/C CHARGING TUBES. OVER AN EXTENDED TIME THE WIRES INSULATION WORE THROUGH & VOLTAGE WAS SUPPLIED TO THE A/C FREON TRANSFER TUBES RUNNING FROM THE LEFT FRONT SIDE TO THE REAR OF THE VAN WHERE THEY CROSSED OVER TO THE DRIVER SIDE AT ABOUT MIDPOINT ON THE BODY. THE CROSS TUBES ARE BETWEEN THE VEHICLES BODY & LONG SHIELD. THIS IS WHERE THE POSITIVELY CHARGED REAR A/C TRANSFER TUBES MADE CONTACT WITH THE NEGATIVE/GROUNDED REAR HEATER TRANSFER TUBES, SPARKED & IGNITED THE COMBUSTIBLE FLUIDS WITHIN THE FREON. THE ALTERNATOR CHARGING WIRE WAS REPAIRED, SHIELDED & SECURED. THE DAMAGED REAR TRANSFER, CROSSOVER A/C/HEATER TUBES SET WAS ORDERED FOR REPLACEMENT. REAR HEATER TUBES WERE BYPASSED AND THE VEHICLE IS BEING DRIVEN WITHOUT A/C OR REAR HEAT UNTIL THE PARTS ARRIVE. NO APPARENT DAMAGE TO THE CHARGING SYSTEM, A/C OR REAR A/C/HEATER IS SUSPECTED AT PRESENT. CONFIRMATION WILL OCCUR WHEN PART IS INSTALLED AND A/C IS RECHARGED, COOLANT SYSTEM IS SERVICED AND TESTED. *TR

Electrical System

ODI #10230563

Fire

Incident: June 8, 2008 · Filed: June 11, 2008

TL*THE CONTACT OWNS A 2003 GMC SAVANA 3500. THE CONTACT NOTICED THAT THE HORN IN THE VEHICLE SOUNDED AUTOMATICALLY WHILE PARKED. IN AN ATTEMPT TO STOP THE NOISE, SOMEONE PRESSED THE HORN TO COUNTERACT THE FAILURE. ALMOST IMMEDIATELY, SMOKE BEGAN POURING FROM THE HOOD AND THE POLICE DEPARTMENT WAS CALLED. THE VEHICLE WENT UP IN FLAMES WITHIN A MATTER OF MINUTES. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. AT THE TIME OF THE COMPLAINT, THE CONTACT'S INSURANCE COMPANY WAS ASSESSING THE DAMAGE TO DETERMINE IF THE VEHICLE WAS DESTROYED. THE ENTIRE FRONT END WAS BURNED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 89,000.

Suspension; Service Brakes, Hydraulic

ODI #10175302

Incident: November 30, 2006 · Filed: December 6, 2006

DT*: THE CONTACT STATED WHILE DRIVING 30 MPH UNDER NORMAL ROAD CONDITIONS, THE FRONT WHEEL BEARINGS FROZE UP, AND THE TIRES DID NOT TURN. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO REPLACED THE FRONT WHEEL BEARINGS AND THE BRAKE ROTORS. UPDATED 02/12/07. *JB

Other GMC Savana 3500 model years

Check your 2003 GMC Savana 3500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Savana 3500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN