NHTSA vehicle safety data

2003 GMC Savana 2500 Recalls & Complaints

The 2003 GMC Savana 2500 has 1 NHTSA recall campaign and 5 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2003 GMC Savana 2500. Recall data is refreshed daily from NHTSA.

2003 GMC Savana 2500 owner complaints

Owners have filed 5 complaints with NHTSA about the 2003 GMC Savana 2500, describing incidents dated February 21, 2003 to November 9, 2010.

Most-cited components

Service Brakes 3 complaints
Power Train 2 complaints
Wheels 2 complaints
Exterior Lighting 1 complaint
Seat Belts 1 complaint

Of the 5 complaints on file, 1 reports a crash (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10386035 · Filed March 1, 2011
TL* THE CONTACT OWNS A 2003 GMC SAVANNAH 2500. THE CONTACT WAS DRIVING DOWNHILL IN REVERSE WHEN THE BRAKES MALFUNCTIONED AND WOULD NOT ENGAGE, CAUSING THE VEHICLE TO CRASH INTO ANOTHER VEHICLE. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS TOWED TO THE DEALER BUT THE DEALER WAS UNABLE TO LOCATE A…
ODI #10297664 · Filed December 31, 2009
TL* THE CONTACT OWNS A 2003 GMC SAVANA 2500. WHILE DRIVING 30 MPH HE HAD TO INCREASE HIS STOPPING DISTANCES DURING BRAKE APPLICATION. THE VEHICLE WAS TAKEN TO A SEARS REPAIR FACILITY AND HE WAS ADVISED THAT THE BRAKE MASTER CYLINDER FAILED. A REPRESENTATIVE FROM THE MANUFACTURER STATED THAT HE WAS…
ODI #10166150 · Filed August 21, 2006
DT*: THE CONTACT STATED WHILE DRIVING 35 MPH THE TRANSMISSION FAILED. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHERE PARTS IN THE TRANSMISSION WERE REPLACED. AFTER 90,000 MILES, THE TRANSMISSION CEASED TO OPERATE AGAIN. THE VEHICLE WAS TAKEN TO A DIFFERENT SERVICE DEALER WHO OFFERED TO REPLACE…

Read all 5 complaints

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2003 GMC Savana 2500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

5 owner complaints have been filed with NHTSA for the 2003 GMC Savana 2500.

Service Brakes, Hydraulic

ODI #10386035

Crash

Incident: November 9, 2010 · Filed: March 1, 2011

TL* THE CONTACT OWNS A 2003 GMC SAVANNAH 2500. THE CONTACT WAS DRIVING DOWNHILL IN REVERSE WHEN THE BRAKES MALFUNCTIONED AND WOULD NOT ENGAGE, CAUSING THE VEHICLE TO CRASH INTO ANOTHER VEHICLE. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS TOWED TO THE DEALER BUT THE DEALER WAS UNABLE TO LOCATE A FAILURE WITHIN THE BRAKES. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC YET THE MECHANIC WAS ALSO UNABLE TO DIAGNOSE A BRAKE FAILURE. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED ANY FURTHER BRAKE FAILURES SINCE THE CRASH. THE FAILURE MILEAGE WAS 110,000.

Service Brakes, Hydraulic

ODI #10297664

Incident: December 20, 2009 · Filed: December 31, 2009

TL* THE CONTACT OWNS A 2003 GMC SAVANA 2500. WHILE DRIVING 30 MPH HE HAD TO INCREASE HIS STOPPING DISTANCES DURING BRAKE APPLICATION. THE VEHICLE WAS TAKEN TO A SEARS REPAIR FACILITY AND HE WAS ADVISED THAT THE BRAKE MASTER CYLINDER FAILED. A REPRESENTATIVE FROM THE MANUFACTURER STATED THAT HE WAS INELIGIBLE FOR A FREE REMEDY. THE CURRENT AND FAILURE MILEAGES WERE 117,000.

Power Train; Exterior Lighting; Seat Belts; Wheels

ODI #10166150

Incident: February 21, 2003 · Filed: August 21, 2006

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH THE TRANSMISSION FAILED. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHERE PARTS IN THE TRANSMISSION WERE REPLACED. AFTER 90,000 MILES, THE TRANSMISSION CEASED TO OPERATE AGAIN. THE VEHICLE WAS TAKEN TO A DIFFERENT SERVICE DEALER WHO OFFERED TO REPLACE THE TRANSMISSION IF A WARRANTY PACKAGE WAS PURCHASED AND THE TRANSMISSION WAS REPLACED. DURING THIS VISIT TO THE 2ND DEALER, A DIAGNOSTIC TEST WAS PERFORMED WHERE THE TAIL LIGHT WAS DISCOVERED NOT TO BE WORKING. THERE WAS NO REPAIR WORK PERFORMED FOR THE TAIL LIGHT. THE CONTACT ALSO EXPRESSED THAT ONE DAY THE DRIVER SEAT BELT WOULD NOT UNLATCHED SO THE SEAT BELT WAS BROKEN TO RELEASE THE CONTACT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER FOR RECALL REMEDY #05113 PERTAINING TO THE SEAT BELT. WHILE AT THE DEALER THE REMEDY REPAIR WORK WAS PERFORMED ON THE PASSENGER SEAT BELT BUT NOT THE DRIVER'S SEAT BELT. AFTER THE REMEDY REPAIR TO THE PASSENGER SEAT BELT, IT NO LONGER WORKED PROPERLY. THE SERVICE DEALER WAS CONTACTED; HOWEVER THE SERVICE DEALER HAD TO ORDER THE PARTS FOR ADDITIONAL REPAIRS. ALSO, WHILE DRIVING 25 MPH THE LUG NUT ON THE HUB CAP DETACHED. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHERE PLASTIC LUG NUTS WERE INSTALLED AND THEY DETACHED AGAIN. WHEN THE VEHICLE WAS TAKEN BACK TO THE DEALER, THE SERVICE MANAGER RECOMMENDED THE LUG NUTS BE GLUED ON. THE CONTACT TOOK THE VEHICLE TO A TIRE COMPANY WHO INSTALLED BRAND NEW TIRES AND LUG NUTS.

Wheels

ODI #10161799

Incident: June 23, 2006 · Filed: July 7, 2006

I HAVE SEVERAL 2003 GMC SAVANA CARGO VANS THAT ARE USED AS SERVICE VEHICLES FOR BUILDING MAINTENANCE. I HAVE RECENTLY HAD THREE INCIDENTS WHERE THE OUTER SECTION OF THE OEM WHEELS (RIMS) HAVE SEPARATED FROM THE CENTER SPOKE SECTION ALONG THE WELD LINES THAT JOIN THE TWO. THE WHEELS ON THE VEHICLES AFFECTED HAVE BEEN REPLACED AND I HAVE THE OTHERS INSPECTED FOR POSSIBLE SIGNS OF FAILURE. I HAVE ONE OF THE WHEELS THAT SPLIT IN MY OFFICE. THE MOST RECENT INCIDENT WAS 6/23/2006. *NM

Service Brakes, Hydraulic; Power Train

ODI #10159840

Incident: June 14, 2006 · Filed: June 14, 2006

ALL 4 BRAKES LOCK UP WHILE DRIVING. BRAKE PADS DRAGGING 1 DAY PRIOR TO LOCK UP. BRAKE PEDAL GOES HARD. EXTREMELY DANGEROUS. TOLD COMPUTER ERROR IS PROBLEM FIRST TIME. SECOND TIME ANSWER PENDING. TRANSMISSION DOES NOT ENGAGE IMMEDIATELY WHEN SHIFTING FROM REVERSE TO FOREWORD. BACK OUT OF DRIVEWAY ONTO PUBLIC STREET-LAG TIME, DANGEROUS. INTERMITTENT PROBLEM. NO RESOLUTION FROM DEALER. *NM

Other GMC Savana 2500 model years

Check your 2003 GMC Savana 2500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Savana 2500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN