NHTSA vehicle safety data
2004 Georgie BOY Pursuit Recalls & Complaints
The 2004 Georgie BOY Pursuit has 4 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Georgie BOY dealer.
NHTSA recall and complaint data for the 2004 Georgie BOY Pursuit. Recall data is refreshed daily from NHTSA.
2004 Georgie BOY Pursuit owner complaints
Owners have filed 2 complaints with NHTSA about the 2004 Georgie BOY Pursuit, describing incidents dated April 5, 2005 to August 15, 2005.
Most-cited components
- Service Brakes 1 complaint
- Structure 1 complaint
Newest complaints
ODI #10133766 · Filed
DT: 2004 GEORGIE BOY CRUSH AIR - CHASSIS FREIGHTLINER XC. THIS IS A FULL AIR BRAKES UNIT, SOMEONE HAS CROSSED THE TWO AIR LINES TO REAR AXLE UNDER TENSION, AND ONE SAWED THE OTHER THROUGH IN 9300 MILES, THE OTHER WITHIN ITSELF WAS NEARLY THROUGH. THIS IS AN METAL ARMORED CABLE, AND THIS WAS AT THE…
ODI #10129926 · Filed
2004 GEORGIE BOY CL A MH NO METAL IN REAR FENDER WELDS, JUST FABRIC UNDER FLOOR BOARD RAIN WATER AND EXHAUST FUMES ENTER COACH. RETURNED TO SERVICE DEALER.METAL ADDED. NO RECALL ON OTHER UNITS ACCORDING TO GBM BECAUSE THEY FELT NOT NECESSARY. TOOK 3 MONTHS FOR REPAIR. OTHER COMPLAINTS TOO NUMEROUS.
OVERHEATED BRAKE CALIPERS/BOSCH/WORKHORSE
NHTSA #09V193000 · Service Brakes, Hydraulic — Fluid · NHTSA notice
Reported June 2, 2009 · COACHMEN RV COMPANY, LLC
Potentially affected: 2,555 vehicles
Owners notified May 1, 2009 · Vehicles built August 1, 2000 – May 31, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
COACHMEN IS RECALLING 2,555 MY 2000-2009 GEORGIE BOY AND COACHMEN RECREATIONAL TRAILERS EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Safety consequence
THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR COACHMEN AT 1-574-266-4030, option 5.
Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
SHOWER DOOR TOWEL BAR
NHTSA #08V639000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice
Reported December 4, 2008 · COACHMEN RV COMPANY, LLC
Potentially affected: 13,662 vehicles
Owners notified February 9, 2009 · Vehicles built June 15, 2001 – August 6, 2007 (per NHTSA)
Defect description
COACHMEN IS RECALLING 13,662 MY 2002-2008 MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH GLASS SHOWER DOORS AND MANUFACTURED FROM JUNE 15, 2001 THORUGH AUGUST 6, 2007. WHEN PRESSURE IS APPLIED TO THE TOWEL BAR ON THE GLASS SHOWER DOOR, THE EDGE OF THE BAR MAY CONTACT THE GLASS.
Safety consequence
GLASS BREAKAGE MAY OCCUR WHICH COULD CAUSE PERSONAL INJURY.
Manufacturer remedy
OWNERS WILL BE PROVIDED WITH NEW MOUNTING HARDWARE FOR THE TOWEL BAR AND INSTALLATION INSTRUCTIONS. IF AN OWNER IS NOT COMFORTABLE REPLACING THE HARDWARE THEMSELVES, A DEALER WILL INSTALL THE HARDWARE AT NO COST TO THEM. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 19, 2008. OWNERS MAY CONTACT COACHMEN AT 1-574-825-5821.
Notes
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO WWW.SAFERCAR.GOV.
FUEL RAIL DAMPER RETAINER CLIP/WORKHORSE
NHTSA #06V352000 · Engine and Engine Cooling · NHTSA notice
Reported September 13, 2006 · COACHMEN RV COMPANY, LLC
Potentially affected: 1,332 vehicles
Vehicles built July 1, 2004 – August 31, 2006 (per NHTSA)
Defect description
ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
Safety consequence
IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
Manufacturer remedy
WORKHORSE IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773 OR COACHMAN AT 219-825-8528.
Notes
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
INSTRUMENT CLUSTER/FMVSS 101 & 105/ WORKHORSE
NHTSA #05V089000 · Electrical System · NHTSA notice
Reported March 17, 2005 · GEORGIE BOY MFG., LLC
Potentially affected: 151 vehicles
Georgie BOY campaign 50402-C · Vehicles built August 27, 2002 – February 2, 2004 (per NHTSA)
Defect description
ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 101, "CONTROLS AND DISPLAY" AND STANDARD NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." MODELS WITH ACTIA INSTRUMENT CLUSTER, THE INCORRECT SOFTWARE PROGRAMMED INTO THE CLUSTER SUCH THAT CERTAIN WARNINGS ARE NOT DISPLAYED.
Safety consequence
INCORRECT SOFTWARE MAY NOT HAVE THE ABILITY TO ILLUMINATE WARNING LAMPS INDICATING BRAKE SYSTEM FAILURES. THE STANDARDS REQUIRE DRIVER WARNING WHEN BRAKE FAILURE CODES ARE SET.
Manufacturer remedy
WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR GEORGIE BOY AT 877-876-9024.
Notes
WORKHORSE RECALL NO. 50402-C.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Other Georgie BOY Pursuit model years
Check your 2004 Georgie BOY Pursuit VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Georgie BOY Pursuit at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Georgie BOY VIN