NHTSA vehicle safety data

2003 Freightliner Business Class Recalls & Complaints

The 2003 Freightliner Business Class has 1 NHTSA recall campaign and 7 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Freightliner dealer.

NHTSA recall and complaint data for the 2003 Freightliner Business Class. Recall data is refreshed daily from NHTSA.

2003 Freightliner Business Class owner complaints

Owners have filed 7 complaints with NHTSA about the 2003 Freightliner Business Class, describing incidents dated March 15, 2004 to November 30, 2014.

Most-cited components

Engine 2 complaints
Tires 2 complaints
Fuel/Propulsion System 1 complaint
Structure 1 complaint
Unknown or Other 1 complaint

Of the 7 complaints on file, 1 reports a crash; across all 7 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10681167 · Filed February 4, 2015
TL* THE CONTACT OWNS A 2003 FREIGHTLINER BUSINESS CLASS EQUIPPED WITH KELLY CHARGER HPT TIRES, SIZE 275/70R/24.5 (NA). THE DOT NUMBER WAS UNAVAILABLE. WHILE DRIVING APPROXIMATELY 70 MPH, THE TWO FRONT TIRES BLEW OUT. AS A RESULT, THE VEHICLE CRASHED INTO A WALL. A POLICE REPORT WAS FILED AND THERE…
ODI #10533306 · Filed August 2, 2013
TL* THE CONTACT OWNS A 2003 FREIGHT LINER M2 BUSINESS CLASS. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, GASOLINE LEAKED FROM THE TRUCK AND ONTO THE UNDER CARRIAGE. THE TRUCK WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE HIGHER PRESSURE FUEL LINE NEEDED TO BE REPLACED. THE…
ODI #10341670 · Filed July 6, 2010
TL*THE CONTACT OWNS A 2003 MERCEDES BUSINESS CLASS. THE CONTACT STATED THAT THE REPAIR FOR THE NHTSA RECALL, CAMPAIGN ID NUMBER: 09V418000, ENGINE AND ENGINE COOLING, EXHAUST SYSTEM WAS PERFORMED ON HIS VEHICLE. THE CONTACT ALSO STATED THAT THE EGR ASSEMBLY WAS DEFECTIVE AND SHOULD HAVE BEEN…

Read all 7 complaints

FREIGHTLINER/FRONT WHEEL BEARING

NHTSA #04V272000 · Suspension — Front — Wheel Bearing · NHTSA notice

Reported June 7, 2004 · FREIGHTLINER LLC

Potentially affected: 9,602 vehicles

Freightliner campaign FL-424 · Owners notified September 7, 2004 · Vehicles built October 1, 2002 – October 31, 2003 (per NHTSA)

Defect description

ON CERTAIN TRUCKS BUILT WITH 8,000 OR 6,000 POUND FRONT AXLES AND FOUR-PIECE SPINDLE NUT SETS, PREMATURE FRONT ,WHEEL BEARING WEAR MAY BE CAUSED BY INCONSISTENT BEARING ENDPLAY ADJUSTMENT.

Safety consequence

IF ALLOWED TO PROGRESS, THE FRONT WHEEL ASSEMBLY MAY SEPARATE FROM THE VEHICLE, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

THE DEALERS WILL REPLACE THE FRONT AXLE OIL SEALS AND HUB CAP GASKETS ON BOTH SIDES. THE RECALL BEGAN SEPTEMBER 7, 2004. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-424. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2003 Freightliner Business Class. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

7 owner complaints have been filed with NHTSA for the 2003 Freightliner Business Class.

Tires

ODI #10681167

Crash

Incident: November 30, 2014 · Filed: February 4, 2015

TL* THE CONTACT OWNS A 2003 FREIGHTLINER BUSINESS CLASS EQUIPPED WITH KELLY CHARGER HPT TIRES, SIZE 275/70R/24.5 (NA). THE DOT NUMBER WAS UNAVAILABLE. WHILE DRIVING APPROXIMATELY 70 MPH, THE TWO FRONT TIRES BLEW OUT. AS A RESULT, THE VEHICLE CRASHED INTO A WALL. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE FAILURE MILEAGE WAS 1,500,000 AND THE TIRE FAILURE MILEAGE WAS UNAVAILABLE.

Fuel System, Diesel

ODI #10533306

Incident: March 15, 2004 · Filed: August 2, 2013

TL* THE CONTACT OWNS A 2003 FREIGHT LINER M2 BUSINESS CLASS. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, GASOLINE LEAKED FROM THE TRUCK AND ONTO THE UNDER CARRIAGE. THE TRUCK WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE HIGHER PRESSURE FUEL LINE NEEDED TO BE REPLACED. THE TRUCK WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 5,000....UPDATED 09/18//13 *BF

Engine and Engine Cooling

ODI #10341670

Incident: June 5, 2010 · Filed: July 6, 2010

TL*THE CONTACT OWNS A 2003 MERCEDES BUSINESS CLASS. THE CONTACT STATED THAT THE REPAIR FOR THE NHTSA RECALL, CAMPAIGN ID NUMBER: 09V418000, ENGINE AND ENGINE COOLING, EXHAUST SYSTEM WAS PERFORMED ON HIS VEHICLE. THE CONTACT ALSO STATED THAT THE EGR ASSEMBLY WAS DEFECTIVE AND SHOULD HAVE BEEN REPLACED WHEN THE RECALL REPAIR WAS DONE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 50,000.

Unknown or Other

ODI #10339607

Incident: June 21, 2010 · Filed: June 22, 2010

DAIMLER VANS, LLC SAFETY RECALL 2010-040002 CALLED FREIGHTLINER DEALER IN OAK CREEK, WI (TRUCK COUNTRY, INC.) THEY HAVE NO INFORMATION AND CANNOT DO THE REPAIR ACCORDING TO THE SAFETY RECALL. I TRIED CALLING DAIMLER AND LISTENED TO MUSIC ON HOLD FOR 40 MINUTES. I GOT NOWHERE WITH THEM! *TR

Engine and Engine Cooling

ODI #10196320

1 injury

Incident: June 22, 2007 · Filed: July 13, 2007

WHILE DRIVING 2003 FRIEGHTLINER SPRINTER ON TWO OCCASIONS WAS OVERCOME WITH NOXIOUS FUMES, RESULTING IN CARBON MONOXIDE POSIONING THAT REQURIED A EMERGENCY VISIT TO THE HOSPITAL. VAN HAS BEEN IN FOR SERVICE AND CONTINUES TO HAVE SAME PROBLEM. THIS IS A COMPANY VAN .

Tires

ODI #10119524

Incident: July 27, 2004 · Filed: May 3, 2005

CONTACT STATES: JULY 27,2004, HAD A TIRE BLOW OUT ON THE REAR TIRE ON THE VAN. THE MUD FLAP BLEW OFF AND THERE WAS DAMAGE DONE TO THE WHEEL WELL. TOOK VEHICLE TO BARNETTE TIRE SERVICE, AND THE TIRE WAS REPLACED. THE MECHANIC STATED THAT THE BLOW OUT WAS DUE TO THE TIRE VALVE. NOW THERE HAS BEEN TIRE VALVE RECALL. *AK

Structure

ODI #10118837

Incident: April 26, 2005 · Filed: June 3, 2005

CONTACT STATES: THAT DOOR BLEW OPEN WHILE DRIVING. ELECTRIC DOOR FOR PASSENGERS FREIGHT LINER SPRINTER 2003. BRAUN CONVERSION FOR WHEELS CHAIRS. HAS ELECTRIC DOOR THAT HAS NO LATCH TO CLOSE AND THERE IS GAP IN THE DOOR,1/2 INCH. THE CONSUMER WAS TOLD BY THE DODGE DEALER THAT IT IS WAS THE CONVERSION PART FOR BRAUN THAT WAS THE PROBLEM. AND TO TAKE IT TO A PLACE THAT WORKS ON CONVERSIONS. VEHICLE WAS TAKEN TO WAITHER BODY SHOP 562-447-1256 FOR REPAIRS. REPAIR COST IS UNKNOWN, UNDERWRITTEN BY BRAUN CORPORATION. INCLUDES UPGRADE TO PREVENT THIS FROM HAPPENING AGAIN. *TT *NM

Other Freightliner Business Class model years

Check your 2003 Freightliner Business Class VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Freightliner Business Class at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Freightliner VIN