NHTSA vehicle safety data

2005 Forest River Tsunami Recalls & Complaints

The 2005 Forest River Tsunami has 4 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Forest River dealer.

NHTSA recall and complaint data for the 2005 Forest River Tsunami. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Forest River Tsunami owner complaints

Owners have filed 2 complaints with NHTSA about the 2005 Forest River Tsunami, describing incidents dated June 13, 2005 to September 19, 2005.

Most-cited components

Electrical System 1 complaint
Tires 1 complaint

Newest complaints

ODI #10138133 · Filed September 29, 2005
DT: ON SEPTEMBER 19, 2005 WAS TRYING TO CLOSE THE WATER RELEASE FOR GRAY WATER, BAY WATER, AND THE FRESH WATER. WENT TO SHUT THE GRAY WATER RELEASE BECAUSE IT WAS DRIPPING, AND WHEN CHECKING IT THE CONSUMER GOT ELECTROCUTED. THERE WAS A SHORT SOMEWHERE IN THIS TRAILER. THE CONSUMER DID NOT HAVE IT…
ODI #10127516 · Filed July 5, 2005
DT: WHILE DRIVING CONSUMER HAD A BLOWOUT AT 55 MPH ON TURNPIKE. THIS HAPPENED ON THE LEFT REAR WHEEL TIRE ON THE OUTSIDE OF THE MOTORHOME. TOOK THE TIRE TO A GOODYEAR DEALER, WHO SAID CONSUMER WOULD HAVE TO PURCHASE A NEW TIRE, AND THEY WOULD TAKE THE BLOWN OUT TIRE AND SEND IT TO THE MANUFACTURER…

Read all 2 complaints

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

NHTSA #11V152000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported March 1, 2011 · FOREST RIVER, INC.

Potentially affected: 38 vehicles

Owners notified March 14, 2011 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FOREST RIVER IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Safety consequence

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Manufacturer remedy

FOREST RIVER IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON MARCH 14, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

REFRIGERATOR/DOMETIC

NHTSA #08V346000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 7, 2008 · FOREST RIVER, INC.

Potentially affected: 107,417 vehicles

Owners notified November 7, 2008 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FOREST RIVER IS RECALLING CERTAIN MY 2003-2006 MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

FOREST RIVER IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FOREST RIVER AT 1-574-389-4600.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

STEERING GEAR SPACER/FREIGHTLINER/ZF

NHTSA #08V067000 · Steering — Gear Box — Shaft Pitman · NHTSA notice

Reported February 14, 2008 · FOREST RIVER, INC.

Potentially affected: 89 vehicles

Owners notified January 30, 2008 · Vehicles built June 13, 2002 – June 13, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FOREST RIVER IS RECALLING 89 MY 2003-2008 TSUNAMI MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS. THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATION BALLS TO ESCAPE FROM THE RECIRCULATION BALL CIRCUIT RESULTING IN A LOSS OF STEERING.

Safety consequence

THE OPERATOR MAY NOTICE HIGHER REQUIRED STEERING WHEEL INPUTS, OR THE NEED FOR MORE STEERING WHEEL ADJUSTMENTS WHILE DRIVING IN A STRAIGHT LINE IN COMBINATION WITH METALLIC CRACKING NOISES PRIOR TO A LOSS OF STEERING. LOSS OF STEERING COULD RESULT IN A VEHICLE CRASH.

Manufacturer remedy

FOREST RIVER IS WORKING WITH FREIGHTLINER AND ZF TO REPLACE THE STEERING GEAR (PLEASE SEE 07V343 AND 07E049). OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712 OR FOREST RIVER AT 1-574-389-4600.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

BURNER TUBES/VEHICLE SYSTEMS/WEBASTO

NHTSA #05V234000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Water Heater · NHTSA notice

Reported May 19, 2005 · FOREST RIVER, INC.

Vehicles built January 1, 2003 – April 30, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.

Safety consequence

THE SURFACE TEMPERATURE OF THE EXHAUST TUBE EXITING FROM THE HEATER CAN INCREASE AND COULD POTENTIALLY IGNITE COMBUSTIBLE MATERIALS IN OR AROUND THE VEHICLE.

Manufacturer remedy

VEHICLE SYSTEMS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR FOREST RIVER AT 574-522-1583.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2005 Forest River Tsunami. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2005 Forest River Tsunami.

Electrical System

ODI #10138133

Incident: September 19, 2005 · Filed: September 29, 2005

DT: ON SEPTEMBER 19, 2005 WAS TRYING TO CLOSE THE WATER RELEASE FOR GRAY WATER, BAY WATER, AND THE FRESH WATER. WENT TO SHUT THE GRAY WATER RELEASE BECAUSE IT WAS DRIPPING, AND WHEN CHECKING IT THE CONSUMER GOT ELECTROCUTED. THERE WAS A SHORT SOMEWHERE IN THIS TRAILER. THE CONSUMER DID NOT HAVE IT PLUGGED UP BECAUSE WAS AFRAID OF THE TRAILER. CONTACTED THE DEALER, AND THEY WANTED THE CONSUMER TO BRING THE TRAILER BACK, BUT THEY WILL NOT GIVE THE MONEY BACK. CONTACTED THE MANUFACTURER, THEY QUOTED THE DEALER ASKING THE CONSUMER TO BRING TRAILER BACK. THEY WILL NOT GIVE HER MONEY BACK. THE DEALER AND THE MANUFACTURER WILL NOT HAVE THE TRAILER TOWED . *AK

Tires

ODI #10127516

Incident: June 13, 2005 · Filed: July 5, 2005

DT: WHILE DRIVING CONSUMER HAD A BLOWOUT AT 55 MPH ON TURNPIKE. THIS HAPPENED ON THE LEFT REAR WHEEL TIRE ON THE OUTSIDE OF THE MOTORHOME. TOOK THE TIRE TO A GOODYEAR DEALER, WHO SAID CONSUMER WOULD HAVE TO PURCHASE A NEW TIRE, AND THEY WOULD TAKE THE BLOWN OUT TIRE AND SEND IT TO THE MANUFACTURER FOR INSPECTION BY AN ENGINEER. IF THERE WAS A DEFECT THEY WOULD REIMBURSE CONSUMER. THE CONSUMER DECIDED TO TAKE TIRE TO DEALER FROM WHERE RV WAS PURCHASED, AND THE DEALER REPLACED TIRE FREE OF CHARGE. LATER AT HOME, CONSUMER NOTED A BUBBLE/BLISTER ON THE LEFT FRONT INSIDE TIRE, AND RETURNED TO DEALER, WHO AGAIN REPLACED TIRE. HOWEVER, CONSUMER WAS FEARFUL THIS MAY HAPPEN AGAIN CONSIDERING THE REMAINING TIRES ARE THE SAME BRAND. THESE 2 FAILURES OCCURRED WHEN THE TIRES HAD ABOUT 200 MILES ON THEM. 1993, GOODYEAR G670 RV UNISTEEL, TIRE SIZE IS 245/70/R19.5, THIS OCCURRED ON A FOREST RIVER INC, MODEL : GEORGETOWN RV MOTORHOME. *AK

Other Forest River Tsunami model years

Check your 2005 Forest River Tsunami VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Forest River Tsunami at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Forest River VIN