NHTSA vehicle safety data

2007 Ford F-750 SD Recalls & Complaints

The 2007 Ford F-750 SD has 1 NHTSA recall campaign and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2007 Ford F-750 SD. Recall data is refreshed daily from NHTSA.

2007 Ford F-750 SD owner complaints

Owners have filed 2 complaints with NHTSA about the 2007 Ford F-750 SD, describing incidents dated February 6, 2009 to January 3, 2013.

Most-cited components

Service Brakes 2 complaints
Engine 1 complaint
Power Train 1 complaint

Newest complaints

ODI #10491504 · Filed January 5, 2013
AFTER A REPAIR TO THE TRANSMISSION BY A LICENSED FACILITY, THE PROP SHAFT DEPARTED THE REAR AXLE DUE TO A FLANGE BREAKING. THE PROP SHAFT FAILED AROUND AND TORE OFF THE WIRING HARNESS TO THE TRANSMISSION AND THE REAR BRAKE LINES; THE CABLE TO THE EMERGENCY BRAKE WAS ALSO COMPROMISED. AS A RESULT…
ODI #10258492 · Filed February 12, 2009
TL*THE CONTACT OWNS A 2007 FORD F-750 SD. WHILE DRIVING IN REVERSE AT 5 MPH, THE AIR MUFFLER BECAME UNWELDED AND THE AIR BRAKES FAILED. AS A RESULT, THE CONTACT COULD NOT STOP THE VEHICLE. THE DEALER STATED THAT HE MUST PURCHASE NEW PARTS AND REPAIR THE VEHICLE HIMSELF. THE CONTACT PURCHASED THE NEW…

Read all 2 complaints

AXLE HOUSING/DANA

NHTSA #07V238000 · Power Train — Axle Assembly · NHTSA notice

Reported June 5, 2007 · FORD MOTOR COMPANY

Potentially affected: 31 vehicles

Ford campaign 07S53 · Owners notified June 12, 2007 · Vehicles built November 15, 2006 – February 14, 2007 (per NHTSA)

Defect description

ON CERTAIN TRUCKS BUILT WITH DANA REAR AXLES, THE REAR AXLE MAY HAVE A HOUSING THAT WAS BUILT USING STEEL THAT WAS THINNER THAN SPECIFIED.

Safety consequence

THROUGH NORMAL USE, THE AXLE HOUSING COULD FATIGUE AND DEVELOP A CRACK WHICH COULD RESULT IN A WHEEL END LOCK-UP OR SEPARATION, POSSIBLY RESULTING IN A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE AXLE FREE OF CHARGE. THE RECALL BEGAN ON JUNE 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-248-0186.

Notes

FORD RECALL NO. 07S53.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2007 Ford F-750 SD. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2007 Ford F-750 SD.

Power Train; Service Brakes

ODI #10491504

Incident: January 3, 2013 · Filed: January 5, 2013

AFTER A REPAIR TO THE TRANSMISSION BY A LICENSED FACILITY, THE PROP SHAFT DEPARTED THE REAR AXLE DUE TO A FLANGE BREAKING. THE PROP SHAFT FAILED AROUND AND TORE OFF THE WIRING HARNESS TO THE TRANSMISSION AND THE REAR BRAKE LINES; THE CABLE TO THE EMERGENCY BRAKE WAS ALSO COMPROMISED. AS A RESULT, THE ENGINE STOPPED. ALL POWER STEERING AND ALL BRAKING WAS LOST; THE TRUCK ROLLED TO A STOP, AND THEN ROLLED BACKWARDS ON A BUSY HIGHWAY. THE DRIVER WAS ABLE TO STEER THE VEHICLE INTO A SNOW BANK. I FEEL THIS IS A SAFETY ISSUE AS A FAILURE LIKE THIS SHOULD NOT HAVE CAUSED SUCH A CATASTROPHIC LOSS OF CONTROL- THE FRONT BRAKES AT LEAST SHOULD HAVE WORKED. *TR

Service Brakes, Air; Engine and Engine Cooling

ODI #10258492

Incident: February 6, 2009 · Filed: February 12, 2009

TL*THE CONTACT OWNS A 2007 FORD F-750 SD. WHILE DRIVING IN REVERSE AT 5 MPH, THE AIR MUFFLER BECAME UNWELDED AND THE AIR BRAKES FAILED. AS A RESULT, THE CONTACT COULD NOT STOP THE VEHICLE. THE DEALER STATED THAT HE MUST PURCHASE NEW PARTS AND REPAIR THE VEHICLE HIMSELF. THE CONTACT PURCHASED THE NEW PARTS, WHICH ARE NOW A DIFFERENT DESIGN, AND MADE A MECHANIC PERFORM THE REPAIRS. THE VEHICLE IS CURRENTLY DRIVING PROPERLY. THE FAILURE MILEAGE WAS 23,079. UPDATED 3/9/09 *CN THE CONSUMER STATED THE BRAKES FAILED WHILE HE WAS BACKING OUT OF HIS DRIVEWAY. THE PROBLEM WAS A FAULTY AIR MUFFLER THAT WAS IMPROPERLY WELDED. UPDATED 03/11/09. *JB

Other Ford F-750 SD model years

Check your 2007 Ford F-750 SD VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford F-750 SD at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN