NHTSA vehicle safety data

2020 Fleetwood Flair Recalls & Complaints

The 2020 Fleetwood Flair has 4 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Fleetwood dealer.

NHTSA recall and complaint data for the 2020 Fleetwood Flair. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2020 Fleetwood Flair owner complaints

Owners have filed 3 complaints with NHTSA about the 2020 Fleetwood Flair, describing incidents dated September 10, 2020 to May 1, 2021.

Most-cited components

Electrical System 1 complaint
Equipment 1 complaint
Power Train 1 complaint
Structure 1 complaint

Newest complaints

ODI #11423940 · Filed July 8, 2021
•NHTSA Recall Number: 21V202 •INADEQUATE REAR AXLE OIL FILL VOLUME Ford Recall number: 21S17 Ford does not appear to be able to address my concerns and repair this problem. I have attached a picture of the rear end drain plug with BURNT FLUID and METAL FILINGS as the rear end had NO LUBRICATION FOR…
ODI #11390268 · Filed January 27, 2021
TL* THE CONTACT OWNS A 2020 FLEETWOOD FLAIR RV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20E071000 (EQUIPMENT) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. CAMPING WORLD OF NASHVILLE LOCATED AT 2618 MUSIC VALLEY DR, NASHVILLE, TN 37214 AND THE MANUFACTURER WERE…
ODI #11387661 · Filed January 12, 2021
THE ONBOARD GENERATOR GIVES OFF RAW GASOLINE SMELL INSIDE THE UNIT AFTER A MINIMUM OF 35 MINUTES OF RUN TIME CREATING AN EXPLOSIVE CONDITIONS. EMAILED THE DEALER AND MANUFACTURER OF THE LIFE SAFETY ISSUES IN SEPTEMBER 13, 2020 WITH NO RESPONSE FROM THE DEALER AND LITTLE FROM THE MANUFACTURER. I…

Read all 3 complaints

Exterior Patio Outlet May Lack GFCI Protection

NHTSA #24V610000 · Equipment — Recreational Vehicle/Trailer — 120/240 Vac Electrical System — Gfci/Afci · NHTSA notice

Reported August 14, 2024 · REV Recreation Group

Potentially affected: 598 vehicles

Repair completion: 29.1% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 240812REV · Owners notified October 11, 2024

Defect description

REV Recreation Group (REV) is recalling certain 2019-2025 Holiday Rambler Admiral, 2023-2025 Holiday Rambler Eclipse, Fleetwood Flex, and 2019-2024 Fleetwood Flair motorhomes. The exterior patio outlet may lack GFCI protection when powered by the generator or shore cord.

Safety consequence

An outlet without GFCI protection may fail to shut off electrical power when a ground-fault occurs, increasing the risk of injury.

Manufacturer remedy

Dealers will install GFCI protection device prior to the inverter transfer switch, free of charge. Owner notification letters were mailed October 11, 2024. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 240812REV.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Front Overhead Cabinet Detachment May Cause Crash

NHTSA #24V607000 · Structure · NHTSA notice

Reported August 13, 2024 · REV Recreation Group

Potentially affected: 4,665 vehicles

Repair completion: 22.1% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 240809REV · Owners notified October 7, 2024

Defect description

REV Recreation Group (REV) is recalling certain 2019-2025 Holiday Rambler Admiral, 2018 Holiday Rambler Admiral XE, Fleetwood Storm, 2023-2025 Holiday Rambler Eclipse, Fleetwood Flex, 2018-2025 Fleetwood Flair, 2020-2024 Fleetwood Fortis, 2020-2025 Holiday Rambler Invicta, 2018-2023 Fleetwood Pace Arrow, and 2018-2019 Holiday Rambler Vacationer XE motorhomes, equipped with the HappiJac drop down bed option. The front overhead cabinet fasteners can break, allowing the overhead cabinet to detach.

Safety consequence

A cabinet that detaches while the vehicle is in motion can distract the driver, increasing the risk of a crash.

Manufacturer remedy

Dealers will inspect and install new hardware and fasteners as necessary, free of charge. Owner notification letters were mailed October 7, 2024. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 240809REV.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Hydraulic Lines Improperly Routed

NHTSA #22V655000 · Suspension — Adjustment — Automatic Electrical/Hydraulic · NHTSA notice

Reported August 30, 2022 · REV Recreation Group

Potentially affected: 4,395 vehicles

Repair completion: 42.26% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified October 28, 2022

Defect description

REV Recreation Group (REV) is recalling certain 2018-2019 Fleetwood Jamboree, 2020-2023 Fleetwood Southwind, Bounder, Flair, Fortis, Holiday Rambler Admiral, Invicta, Vacationer, 2021-2023 Fleetwood Discovery, Discovery LXE, Holiday Rambler Navigator, Armada, Nautica, 2023 Fleetwood Flex, Holiday Rambler Eclipse, 2021 Fleetwood Pace Arrow LXE, 2018 Holiday Rambler Vesta, 2022-2023 Fleetwood Frontier, 2021-2022 Fleetwood Pace Arrow, Holiday Rambler Endeavor, and 2019 Holiday Rambler Augusta motorhomes. The hydraulic lines may have been improperly routed, secured, or protected, which can result in a hydraulic fluid leak.

Safety consequence

A hydraulic fluid leak in the presence of an ignition source can increase the risk of a fire.

Manufacturer remedy

Dealers will inspect the hydraulic hoses for chafing or heat damage, and install hose protection, or replace them as necessary, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact REV customer service at 1-800-509-3417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Gas Leak In Cooking Stove

NHTSA #20V615000 · Equipment · NHTSA notice

Reported October 6, 2020 · REV Recreation Group

Potentially affected: 1,567 vehicles

Repair completion: 25.59% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified December 2, 2020

Defect description

REV Recreation Group (REV) is recalling certain 2020-2021 Fleetwood Flair, Bounder, Southwind and Fortis and Holiday Rambler Vacationer, Invicta, and Admiral motorhomes equipped with a Dometic propane gas stove, model R1731 or R2131 manufactured November 2018 or later or model S31 manufactured November 2018 or later. In certain stove serial number ranges, a gas leak may occur in the cooking stove.

Safety consequence

A gas leak can increase the risk of a fire.

Manufacturer remedy

REV will notify owners, and Dometic dealers will repair the affected stoves, free of charge. The recall began December 2, 2020. Owners may contact REV customer service at 1-800-509-3417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

try.vin has no NCAP crash-test rating on file for the 2020 Fleetwood Flair. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2020 Fleetwood Flair.

Power Train

ODI #11423940

Incident: May 1, 2021 · Filed: July 8, 2021

•NHTSA Recall Number: 21V202 •INADEQUATE REAR AXLE OIL FILL VOLUME Ford Recall number: 21S17 Ford does not appear to be able to address my concerns and repair this problem. I have attached a picture of the rear end drain plug with BURNT FLUID and METAL FILINGS as the rear end had NO LUBRICATION FOR 5300 miles. See the attached image. We need your help. Thank you!!! [XXX], RN, PhD and [XXX], PhD [XXX] VOX: [XXX] MOBILE: [XXX] and [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Equipment

ODI #11390268

Incident: December 1, 2020 · Filed: January 27, 2021

TL* THE CONTACT OWNS A 2020 FLEETWOOD FLAIR RV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20E071000 (EQUIPMENT) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. CAMPING WORLD OF NASHVILLE LOCATED AT 2618 MUSIC VALLEY DR, NASHVILLE, TN 37214 AND THE MANUFACTURER WERE CONTACTED ON MULTIPLE OCCASIONS HOWEVER, THE RECALL REPAIR WAS NOT PERFORMED. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Electrical System; Structure

ODI #11387661

Incident: September 10, 2020 · Filed: January 12, 2021

THE ONBOARD GENERATOR GIVES OFF RAW GASOLINE SMELL INSIDE THE UNIT AFTER A MINIMUM OF 35 MINUTES OF RUN TIME CREATING AN EXPLOSIVE CONDITIONS. EMAILED THE DEALER AND MANUFACTURER OF THE LIFE SAFETY ISSUES IN SEPTEMBER 13, 2020 WITH NO RESPONSE FROM THE DEALER AND LITTLE FROM THE MANUFACTURER. I PURCHASED A 2020 FLEETWOOD FLAIR 28A MOTORHOME IN JULY OF 2020 FROM CAMPING WORLD IN HUGO MINNESOTA. I HAVE BEEN TRYING TO GET INFORMATION FROM THE DEALER SINCE JULY OF 2020. I HAVE CONTACTED THE MANUFACTURER AND THEY ARE TRYING TO GET INFORMATION, BUT BETWEEN THE TOTAL DISREGARD AND LYING THE RV IS STILL AT THE DEALER WITH NO COMPLETION DATE IN SITE.*DT*JB CONSUMER STATED HE FILED 6 COMPLAINTS.*JB*DT*JB

Other Fleetwood Flair model years

Check your 2020 Fleetwood Flair VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Fleetwood Flair at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Fleetwood VIN