try.vin
Log in

NHTSA vehicle safety data

2006 Fleetwood Expedition Recalls & Complaints

The 2006 Fleetwood Expedition has 4 NHTSA recall campaigns and 7 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Fleetwood dealer.

NHTSA recall and complaint data for the 2006 Fleetwood Expedition. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Fleetwood Expedition owner complaints

Owners have filed 7 complaints with NHTSA about the 2006 Fleetwood Expedition, describing incidents dated February 1, 2006 to March 2, 2018.

Most-cited components

  • Visibility/Wiper 6 complaints
  • Electrical System 1 complaint
  • Structure 1 complaint

Of the 7 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #11078330 · Filed

    THE WINDOWS ON THE MOTORCOACH ARE DOUBLE PANE AND OR FOGGY ON THE INSIDE. IT IS A DEFINITE SAFETY HAZARD, ESPECIALLY THE WINDOWS ON THE DRIVER AND PASSENGER SIDE. IT IS DIFFICULT TO SEE THE REARVIEW MIRRORS WITH THE FOGGY WINDOWS.

  • ODI #10748169 · Filed

    TL* THE CONTACT OWNS A 2006 FLEETWOOD EXPEDITION. WHILE PARKED, THE VEHICLE CAUGHT FIRE UNDERNEATH THE DASHBOARD. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 53,700.

  • ODI #10552215 · Filed

    TL* THE CONTACT OWNS A 2006 FLEETWOOD EXPEDITION. THE CONTACT STATED THAT THE SEAL ON THE PASSENGER AND DRIVER'S SIDE WINDOWS WERE FRACTURED AND CAUSED THE WINDOWS TO CONSTANTLY BECOME FOGGY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS…

Read all 7 complaints

BATTERY CABLE

NHTSA #09V056000 · Electrical System — 12V/24V/48V Battery — Cables · NHTSA notice

Reported February 18, 2009 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 3,782 vehicles

Fleetwood campaign 90209 · Owners notified May 26, 2009 · Vehicles built October 1, 2005 – March 31, 2008 (per NHTSA)

Defect description

FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.

Safety consequence

THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.

Manufacturer remedy

DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Notes

FLEETWOOD RECALL NO. 90209.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

REFRIGERATOR/DOMETIC

NHTSA #08V320000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 15, 2008 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 70,101 vehicles

Owners notified October 24, 2008 · Vehicles built April 1, 2003 – November 30, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

ENTRY STEP

NHTSA #06V055000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported February 23, 2006 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 1,236 vehicles

Fleetwood campaign 60220 · Owners notified March 17, 2006 · Vehicles built September 1, 2005 – December 31, 2005 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC ENTRY STEP BUILT WITH A CONTROL UNIT MANUFACTURED BY AMERICAN TECHNOLOGIES, MAY DEVELOP AN ELECTRICAL SHORT DURING COLD WEATHER, ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE.

Safety consequence

THIS WILL MAKE THE STEP INOPERABLE AND POSSIBLY RESULT IN A RISK OF PERSONAL INJURY, VEHICLE OR OTHER PROPERTY DAMAGE.

Manufacturer remedy

DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE ALL AMERICAN TECHNOLOGIES CONTROLS ASSOCIATED WITH THE KWIKEE BRAND ELECTRIC ENTRY STEP FREE OF CHARGE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Notes

FLEETWOOD RECALL NO.60220.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

INCORRECT TOW HITCH CERTIFICATION LABEL

NHTSA #05V333000 · Equipment — Other — Labels · NHTSA notice

Reported July 27, 2005 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 2,435 vehicles

Fleetwood campaign 50719 · Owners notified August 4, 2005 · Vehicles built June 1, 2004 – April 11, 2005 (per NHTSA)

Defect description

CERTAIN DIESEL CLASS A MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE MANUFACTURERS' TOW HITCH RECEIVER INFORMATION LABEL WAS PRINTED WITH THE INCORRECT WEIGHT CARRYING CAPACITY VALUE AND THE INCORRECT TONGUE WEIGHT VALUE.

Safety consequence

THE WEIGHT LABEL ON THE HITCH RECEIVER PROVIDES THE MAXIMUM TRAILER WEIGHT RATING AND THE MAXIMUM TONGUE WEIGHT RATING. IT IS IMPORTANT THAT THESE RATINGS NOT BE EXCEEDED. FAILURE TO COMPLY COULD RESULT IN DAMAGE TO THE MOTOR HOME FRAME, BODY, OR HITCH RECEIVER AND COULD CAUSE UNSTABLE DRIVING AND HANDLING CHARACTERISTRICS WHICH MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

FLEETWOOD WILL MAIL OWNERS THE CORRECT TOW HITCH RECEIVER WEIGHT INFORMATION LABEL. IF OWNERS DO NOT FEEL COMFORTABLE INSTALLING THE LABEL, DEALERS WILL INSTALL THE LABEL FOR THEM. THE RECALL BEGAN AUGUST 4, 2005. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Notes

FLEETWOOD RECALL NO. 50719. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Other Fleetwood Expedition model years

Check your 2006 Fleetwood Expedition VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Fleetwood Expedition at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Fleetwood VIN