NHTSA vehicle safety data
2007 Fccc B2 Recalls & Complaints
The 2007 Fccc B2 has 8 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Fccc dealer.
NHTSA recall and complaint data for the 2007 Fccc B2. Recall data is refreshed daily from NHTSA.
2007 Fccc B2 owner complaints
Owners have filed 1 complaint with NHTSA about the 2007 Fccc B2, describing incidents dated September 20, 2009.
Most-cited components
- Visibility/Wiper 1 complaint
Newest complaints
ODI #10357121 · Filed
TL*THE CONTACT OWNS A 2007 FREIGHTLINER B2 BUS. THE CONTACT STATED THAT THE WINDSHIELD WIPER MOTOR STOPPED FUNCTIONING INTERMITTENTLY. HE HAD TO TURN THE VEHICLE OFF AND WITHIN A FEW MINUTES HE WAS ABLE TO RESTART IT. THE CONTACT INSTALLED A NEW MOTOR BUT THE FAILURE CONTINUED TO OCCUR. THE VEHICLE…
GRID HEATER/POSSIBLE FIRE
NHTSA #10V340000 · Engine and Engine Cooling · NHTSA notice
Reported July 27, 2010 · DAIMLER TRUCKS NORTH AMERICA
Potentially affected: 5,445 vehicles
Manufacturer campaign 10C-5 · Owners notified July 29, 2011 · Vehicles built September 5, 2006 – June 30, 2010 (per NHTSA)
Defect description
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FCCC B2 106 CH AND THOMAS BUILT SAF-T-LINER C2 AND HDX SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 5, 2006 THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
Safety consequence
A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
Manufacturer remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 29, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
Notes
DAIMLER TRUCKS' RECALL CAMPAIGN NUMBER IS 10C-5.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
HYDRAULIC BRAKE SWITCHES
NHTSA #10V178000 · Exterior Lighting — Brake Lights — Switch · NHTSA notice
Reported April 30, 2010 · DAIMLER TRUCKS NORTH AMERICA
Potentially affected: 8,971 vehicles
Manufacturer campaign FL-577 · Owners notified May 27, 2011 · Vehicles built January 19, 2005 – April 16, 2010 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 FREIGHTLINER BUSINESS CLASS C2, FCCC B2 CHASSIS, S2 CHASSIS, AND MC CHASSIS MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.
Safety consequence
THE STOP LAMPS MAY NOT PROPERLY INDICATE THAT THE SERVICE BRAKES ARE APPLIED WHICH MAY LEAD TO A CRASH WITHOUT WARNING.
Manufacturer remedy
DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
Notes
DTNA'S RECALL CAMPAIGN NUMBER IS FL-577.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
AIR MANAGEMENT UNIT (AMU) PRESSURE SWITCH
NHTSA #08V602000 · Exterior Lighting — Brake Lights · NHTSA notice
Reported November 19, 2008 · DAIMLER TRUCKS NORTH AMERICA
Potentially affected: 15,686 vehicles
Manufacturer campaign FL-538 · Owners notified March 18, 2009 · Vehicles built March 1, 2005 – May 31, 2008 (per NHTSA)
Defect description
DAIMLER TRUCKS IS RECALLING 15,686 MY 2005 THROUGH 2009 FCCC AND THOMAS BUILT SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN MARCH 2005 AND MAY 2008 EQUIPPED WITH A CERTAIN BRAKE LAMP AIR PRESSURE SWITCH. THE CONTACTS IN THE PRESSURE SWITCH FOR THE LOW CURRENT BRAKE LAMP SIGNAL TO THE CHASSIS ECU MAY HAVE BECOME CONTAMINATED BY SILICONE DURING ASSEMBLY CAUSING INSULATING DEPOSITS TO BUILD UP OVER TIME PREVENTING THE BRAKE LAMPS FROM OPERATING.
Safety consequence
INOPERATIVE BRAKE LAMPS WOULD NOT PROVIDE A SIGNAL TO FOLLOWING DRIVERS THAT THE BRAKES ARE APPLIED AND A CRASH MAY OCCUR.
Manufacturer remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE PRESSURE SWITCH FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 18, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR THOMAS BUILT BUSES AT 1-336-889-4871.
Notes
DAIMLER TRUCKS' RECALL NO. FL-538.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
8K THIN SPINDLE-NUT/ARVINMERITOR/AXLE ALLIANCE
NHTSA #08V137000 · Power Train — Axle Assembly · NHTSA notice
Reported March 25, 2008 · DAIMLER TRUCKS NORTH AMERICA
Potentially affected: 28,764 vehicles
Manufacturer campaign FL-527 · Owners notified January 8, 2009 · Vehicles built January 26, 2000 – March 24, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
DAIMLER TRUCKS IS RECALLING 28,764 MY 2001 THROUGH 2008 FCCC B2 AND FS65 SCHOOL BUS CHASSIS, FCCC FB65 CONVENTIONAL BUSES, AND STERLING ACTERRA, FREIGHTLINER FLN, AND BUSINESS CLASS M2 HEAVY TRUCKS, BUILT FROM JANUARY 26, 2000, THROUGH MARCH 24, 2008, MANUFACTURED WITH ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 THROUGH 8,000 POUND FRONT AXLES UTILIZING A FOUR PIECE SPINDLE-NUT SET. THESE AXLE ASSEMBLIES MAY HAVE BEEN PRODUCED WITH A THIN SPINDLE NUT WHICH MAY LEAD TO INCORRECT END PLAY, CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.
Safety consequence
CONTINUED OPERATION MAY LEAD TO WHEEL SEPARATION AND POSSIBLY A VEHICLE CRASH.
Manufacturer remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 8, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
Notes
DAIMLER TRUCKS RECALL NO. FL-527.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
STEERING ARM/TIE ROD ARM
NHTSA #07V306000 · Steering · NHTSA notice
Reported July 18, 2007 · FREIGHTLINER LLC
Potentially affected: 18,000 vehicles
Manufacturer campaign FL-501 · Owners notified December 21, 2007 · Vehicles built January 5, 2007 – May 17, 2007 (per NHTSA)
Defect description
FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.
Safety consequence
INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.
Manufacturer remedy
THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Notes
FREIGHTLINER RECALL NO. FL-501.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
SR-7 SPRING BRAKE VALVE ASSEMBLY/BENDIX/PARKER
NHTSA #07V302000 · Service Brakes, Air — Supply — Check Valve · NHTSA notice
Reported July 16, 2007 · FREIGHTLINER LLC
Potentially affected: 75,000 vehicles
Manufacturer campaign FL-504 · Owners notified January 11, 2008 · Vehicles built July 1, 2002 – July 3, 2007 (per NHTSA)
Defect description
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
Safety consequence
THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.
Manufacturer remedy
FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Notes
FREIGHTLINER RECALL NO. FL-504.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
PARK BRAKE
NHTSA #07V055000 · Service Brakes, Air · NHTSA notice
Reported February 13, 2007 · FREIGHTLINER LLC
Potentially affected: 535 vehicles
Manufacturer campaign FL-491 · Owners notified May 24, 2007 · Vehicles built July 3, 2006 – November 3, 2006 (per NHTSA)
Defect description
CERTAIN MY 2007 THOMAS BUILT C2 SAF-T-LINER SCHOOL BUSES AND FREIGHTLINER BUSINESS CLASS M2, FCCC B2, AND S2 BUS CHASSIS MANUFACTURED BETWEEN JULY 3 AND NOVEMBER 3, 2006.
Safety consequence
UNDER CERTAIN CONDITIONS, THE PARK BRAKE OR WORK BRAKE MAY FAIL ALLOWING THE VEHICLE TO ROLL, POSSIBLY RESULTING IN PERSONAL INJURY. ALSO, THE STOP LAMPS MAY INTERMITTENTLY FAIL TO ILLUMINATE WHEN THE SERVICE BRAKE IS APPLIED.
Manufacturer remedy
FREIGHTLINER WILL NOTIFY OWNER AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON MAY 24, 2007. OWNERS CAN CONTACT FREIGHTLINER'S CUSTOMER ASSISTANCE CENTER AT 800-385-4357.
Notes
FREIGHTLINER'S RECALL NO. FL-491.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
SPRING BRAKE MODULATING VALVES/BENDIX
NHTSA #06V205000 · Parking Brake — Conventional — Air · NHTSA notice
Reported June 12, 2006 · FREIGHTLINER LLC
Potentially affected: 5,243 vehicles
Manufacturer campaign FL-477 · Owners notified June 28, 2006 · Vehicles built April 1, 2006 – May 26, 2006 (per NHTSA)
Defect description
CERTAIN HEAVY TRUCKS, SHUTTLE BUSES, AND SCHOOL BUSES EQUIPPED WITH BENDIX MODULATED SPRING BRAKE VALVES. A DEFECT IN THE MODULATED SPRING BRAKE VALVE CASTING MAY CAUSE AN INTERMITTENT DELAY IN THE APPLICATION OF THE PARK BRAKE.
Safety consequence
THE VEHICLE MAY ROLLAWAY WITHOUT WARNING, POSSIBLY CAUSING PERSONAL INJURY.
Manufacturer remedy
FREIGHTLINER WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE VALVES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 28, 2006 TO FREIGHTLINER, STERLING, AND FCCC OWNERS. THOMAS BUILT MAILED LETTERS TO OWNERS BEGINNING JULY 27, 2006. THIS RECALL HAS BEEN SUPERSEDED (REPLACED) BY RECALL 07V302 (FL-504).
Notes
FREIGHTLINER RECALL NO. FL-477.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Other Fccc B2 model years
Check your 2007 Fccc B2 VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Fccc B2 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Fccc VIN