NHTSA vehicle safety data

2004 Extreme RV Sportsmaster Recalls & Complaints

The 2004 Extreme RV Sportsmaster has 2 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Extreme RV dealer.

NHTSA recall and complaint data for the 2004 Extreme RV Sportsmaster. Recall data is refreshed daily from NHTSA.

2004 Extreme RV Sportsmaster owner complaints

Owners have filed 1 complaint with NHTSA about the 2004 Extreme RV Sportsmaster, describing incidents dated July 13, 2005.

Most-cited components

Tires 1 complaint

Newest complaints

ODI #10138865 · Filed September 28, 2005
CONSUMER RIGHT FRONT TIRE BLEW OUT THE SIDEWALL EXPOSING STEEL BELTS. *TS *** NAR RECEIVED 9-29-05*** THE TIRE WAS REPLACED WITH THE NEW FULL SIZE SPARE. ALMOST A MONTH LATER THE RIGHT FRONT TIRE BLEWOUT AGAIN LEAVING A 2 INCH HOLE IN THE TREAD. THIS WAS THE ORIGINAL SPARE WHICH HAD LESS THAN 2000…

Read the full complaint

REFRIGERATOR/DOMETIC

NHTSA #08V350000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 16, 2008 · EXTREME RV LLC

Potentially affected: 3,294 vehicles

Owners notified January 7, 2009 · Vehicles built March 26, 2004 – April 17, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

EXTREME RV IS RECALLING 3,294 MY 2004-2007 FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

EXTREME RV IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR EXTREME RV AT 1-208-453-2500.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #08V252000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported June 5, 2008 · EXTREME RV LLC

Potentially affected: 12,951 vehicles

Recall influenced by NHTSA's Office of Defects Investigation

Defect description

EXTREME RV IS RECALLING 12,951 MY 2003-2004 SPORTSMASTER, MONTEREY, EXTREME AND MY 1997-2003 KIT RV CALAY, COMPANION, ESPRE, EXTREME, MILLINIUM, MONTEREY, PATIO HAULER, ROAD RANGER, SPORTSMASTER AND SUNCHASER TRAVEL AND FIFTH WHEEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Manufacturer remedy

EXTREME RV WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR EXTREME RV AT 1-208-453-2500.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2004 Extreme RV Sportsmaster. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2004 Extreme RV Sportsmaster.

Tires

ODI #10138865

Incident: July 13, 2005 · Filed: September 28, 2005

CONSUMER RIGHT FRONT TIRE BLEW OUT THE SIDEWALL EXPOSING STEEL BELTS. *TS *** NAR RECEIVED 9-29-05*** THE TIRE WAS REPLACED WITH THE NEW FULL SIZE SPARE. ALMOST A MONTH LATER THE RIGHT FRONT TIRE BLEWOUT AGAIN LEAVING A 2 INCH HOLE IN THE TREAD. THIS WAS THE ORIGINAL SPARE WHICH HAD LESS THAN 2000 MILE ON IT. SIX DAY LATER THE LEFT REAR TIRE BLEWOUT LEAVING A 1 INCH HOLE IN THE TREAD OF THE TIRE. (2004 SPORTSMASTER 194T TRAVEL TRAILER) (5 ORIGINAL CARLISLE ST RADIAL ST250/75R14 LOAD C). *NM

Other Extreme RV Sportsmaster model years

Check your 2004 Extreme RV Sportsmaster VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Extreme RV Sportsmaster at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Extreme RV VIN