How many recalls does the 2009 E-One Cyclone II have?

NHTSA lists 4 recall campaigns for the 2009 E-One Cyclone II as of October 16, 2026. Each includes the defect description, safety consequence, and the remedy E-One will perform. New recalls can be issued at any time; this page is refreshed from NHTSA daily.

How do I tell if my 2009 E-One Cyclone II is affected by a recall?

Enter your 17-character VIN — stamped at the base of the windshield on the driver side and on the door jamb sticker — at nhtsa.gov/recalls. NHTSA's VIN lookup shows whether your specific vehicle has an unrepaired recall; the list on this page covers every campaign for the 2009 E-One Cyclone II.

Are recall repairs on a 2009 E-One Cyclone II free?

Usually. Federal law requires E-One to remedy recalls on the 2009 Cyclone II free of charge at an authorized E-One dealer, regardless of how many owners the vehicle has had or how many miles are on the odometer — unless it was first sold more than 15 years before the recall was issued (5 years for tires).

Does a recall on the 2009 E-One Cyclone II affect resale value?

An open recall can reduce resale value; a recall that has been repaired (documented in the vehicle history report) generally does not. Before you buy or sell a used 2009 E-One Cyclone II, check the VIN at nhtsa.gov/recalls to confirm every recall has been remedied.

How many owner complaints are on file for the 2009 E-One Cyclone II?

No owner complaints have been filed with NHTSA on the 2009 E-One Cyclone II.

NHTSA vehicle safety data

2009 E-One Cyclone II Recalls, Ratings & Complaints

The 2009 E-One Cyclone II has 4 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized E-One dealer.

NHTSA recall and complaint data for the 2009 E-One Cyclone II. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

SUSPENSION:FRONT

NHTSA #18V171000

Reported March 15, 2018 · E-One Incorporated

Potentially affected: 36 vehicles

Defect description

E-One Incorporated (E-One) is recalling certain 2008-2015 E-One Typhoon, Cyclone II, and Quest II vehicles, equipped with Timoney Independent Front Suspensions. Inconsistent machining may result in fatigue cracks developing over time in the front axle spindles, causing failure of the spindle and the possible separation of a front wheel from the vehicle.

Safety consequence

A wheel separation from the vehicle can increase the risk of a crash.

Manufacturer remedy

E-One will notify owners, and dealers will replace the front axle spindle, free of charge. The recall began on April 24, 2018. Owners may contact E-One customer service at 1-352-861-3612.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

ELECTRICAL SYSTEM

NHTSA #18V056000

Reported January 9, 2018 · E-One Incorporated

Potentially affected: 196 vehicles

Defect description

E-One Incorporated (E-One) is recalling certain 2005-2010 E-One Typhoon, Cyclone II, X-036, Cyclone III, SPGL, SPBE, FLM2, F550, I440, and I740 emergency vehicles, equipped with an IOTA 50 Amp transfer switch. Electrical connections at the transfer switch may loosen and cause excessive heat.

Safety consequence

The excessive heat can increase the risk of a fire.

Manufacturer remedy

E-One will notify owners, and dealers will replace the IOTA transfer switch with a Powermax switch, free of charge. The recall began on February 19, 2018. Owners may contact E-One customer service at 1-352-861-3612.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

ELECTRONIC STABILITY CONTROL (ESC)

NHTSA #11V564000

Reported December 1, 2011 · E-ONE, INC.

Potentially affected: 220 vehicles

Defect description

E-ONE IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 CYCLONE II, TYPHOON, AND QUEST VEHICLES MANUFACTURED FROM MAY 1, 2008, THROUGH NOVEMBER 28, 2011, AND EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.

Safety consequence

IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

E-ONE WILL NOTIFY OWNERS AND IS WORKING WITH MERITOR WABCO TO REPLACE THE CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2011. OWNERS MAY CONTACT E-ONE CUSTOMER SERVICE AT 1-800-627-5050 OR MERITOR ON TRACK CUSTOMER SERVICE AT 1-866-668-7221.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

ENGINE AND ENGINE COOLING

NHTSA #10V225000

Reported May 26, 2010 · E-ONE, INC.

Potentially affected: 20 vehicles

Defect description

E-ONE IS RECALLING CERTAIN MODEL YEAR 2008-2009 QUEST AND CYCLONE II FIRE TRUCKS EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES MANUFACTURED FROM MARCH 13, 2008 THROUGH SEPTEMBER 27, 2009. THERE IS A SOFTWARE PROBLEM IN THE ENGINE CONTROL COMPUTER THAT MAY CAUSE UNEXPECTED ENGINE SHUT DOWN UNDER CERTAIN OPERATING CONDITIONS.

Safety consequence

UNEXPECTED SHUT DOWN OF THE ENGINE MAY PREVENT THE OPERATION OF EQUIPMENT ON THE VEHICLE DURING RESCUE OPERATION PUTTING THE PUBLIC AND FIRE FIGHTERS AT RISK.

Manufacturer remedy

DETROIT DIESEL IS HANDLING THE OWNER NOTIFICATION SCHEDULE AND REMEDY FOR THIS CAMPAIGN. THE MOTOR CONTROL MODULE WILL HAVE A NEW SOFTWARE INSTALLED FREE OF CHARGE. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708.

Notes

E-ONE SAFETY RECALL NO. 4EN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Other E-One Cyclone II model years

Check your 2009 E-One Cyclone II VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your E-One Cyclone II at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an E-One VIN