NHTSA vehicle safety data
2005 Country Coach Allure Recalls & Complaints
The 2005 Country Coach Allure has 6 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Country Coach dealer.
NHTSA recall and complaint data for the 2005 Country Coach Allure. Recall data is refreshed daily from NHTSA.
2005 Country Coach Allure owner complaints
Owners have filed 1 complaint with NHTSA about the 2005 Country Coach Allure, describing incidents dated October 2, 2007.
Most-cited components
- Structure 1 complaint
- Suspension 1 complaint
- Tires 1 complaint
Newest complaints
ODI #10208093 · Filed
HIT A POTHOLE AT APPROX 45-50 MPH...FRONT/RIGHT SHOCK FAILED..AFTER REACHING REPAIR FACILITY WE DISCOVERED THE ENTIRE FRONT END (NEW HOLLAND) HAD BEEN COMPROMISED....BENT AND CRACKED HOW COULD A POTHOLE CAUSE THIS TYPE OF DAMAGE UNLESS THERE WAS AN INHERENT WEAKNESS WITHIN THE STRUCTURE? *TR
IDENTIFICATION LAMPS/FMVSS 108
NHTSA #07V225000 · Exterior Lighting · NHTSA notice
Reported June 5, 2007 · COUNTRY COACH INC
Potentially affected: 605 vehicles
Owners notified April 7, 2008 · Vehicles built May 1, 2004 – June 30, 2005 (per NHTSA)
Defect description
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE MOTOR HOMES WERE EQUIPPED WITH MORE THAN THREE AMBER IDENTIFICATION LAMPS LOCATED AT THE TOP AND FRONT OF THE VEHICLE. ALSO, THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUE AT 45 DEGREES AS SPECIFIED IN THE STANDARD.
Safety consequence
THE FIVE IDENTIFICATION LIGHTS COULD POSSIBLY CAUSE CONFUSION TO ON-COMING MOTORISTS WHO ARE USED TO OBSERVING THREE IDENTIFICATION LIGHTS. THE INADEQUACY OF THE FRONT AND REAR SIDE MARKER LIGHTS COULD AFFECT VISIBILITY OF THE MOTOR HOME DURING HOURS OF DARKNESS THAT COULD POTENTIALLY RESULT IN A CRASH.
Manufacturer remedy
DEALERS WILL REMOVE THE TWO EXTRA IDENTIFICATION LAMPS AND INSTALL FOUR SIDE MARKER LIGHTS, ONE AT EACH CORNER, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 31, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 800-547-8015.
Notes
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
FMVSS 120/TIRE INFLATION PRESSURES
NHTSA #05V277000 · Tires — Pressure Monitoring and Regulating Systems · NHTSA notice
Reported June 14, 2005 · COUNTRY COACH INC
Potentially affected: 9 vehicles
Owners notified June 23, 2005 · Vehicles built May 1, 2005 – May 31, 2005 (per NHTSA)
Defect description
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE FRONT AND REAR TIRE COLD TIRE INFLATION PRESSURES OF 125 PSI EXCEED THE MANUFACTURER'S RECOMMENDED MAXIMUM COLD INFLATION PRESSURE OF 120 PSI.
Safety consequence
THIS COULD POSSIBLY LEAD TO PREMATURE RIM FAILURE. SUCH A RIM FAILURE COULD RESULT IN THE LOSS OF STEERING CONTROL AND COULD RESULT IN A CRASH.
Manufacturer remedy
COUNTRY COACH WILL ISSUE REPLACEMENT FEDERAL TIRE LABELS REFLECTING THE CORRECTED COLD TIRE INFLATION PRESSURE OF 120 PSI FOR BOTH THE FRONT AND REAR TIRES. THIS CHANGE WILL RESULT IN A REDUCTION OF THE COLD INFLATION TIRE PRESSURE OF EACH FRONT AND REAR TIRE BY 5 PSI. THE RECALL BEGAN ON JUNE 23, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.
Notes
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
BURNER TUBES /VEHICLE SYSTEMS/WEBASTO
NHTSA #05V209000 · Equipment · NHTSA notice
Reported May 9, 2005 · COUNTRY COACH INC
Potentially affected: 282 vehicles
Vehicles built December 1, 2002 – April 1, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.
Safety consequence
THE SURFACE TEMPERATURE OF THE EXHAUST TUBE EXITING FROM THE HEATER CAN INCREASE AND COULD POTENTIALLY IGNITE COMBUSTIBLE MATERIALS IN OR AROUND THE VEHICLE.
Manufacturer remedy
VEHICLE SYSTEMS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR COUNTRY COACH AT 1-800-547-8015.
Notes
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
COUNTRY COACH/CIRCUIT BREAKER
NHTSA #04V464000 · Electrical System — Wiring — Fuses and Circuit Breakers · NHTSA notice
Reported September 21, 2004 · COUNTRY COACH INC
Potentially affected: 380 vehicles
Owners notified November 8, 2004 · Vehicles built June 1, 2004 – September 10, 2004 (per NHTSA)
Defect description
ON CERTAIN MOTOR HOMES, A CIRCUIT BREAKER IN THE CLEARANCE LIGHT CIRCUIT DOES NOT PROTECT THE CIRCUIT FROM A TOO HIGH AMPERAGE DRAW CAUSED BY A TOWED PASSENGER VEHICLE.
Safety consequence
THE CIRCUIT BREAKER CAN OVERHEAT THE WIRE AND INSULATION TO A POINT WHICH COULD CAUSE A FIRE.
Manufacturer remedy
DEALERS WILL REPLACE THE DEFECTIVE CIRCUIT BREAKERS. THE RECALL BEGAN ON NOVEMBER 8, 2004. CUSTOMERS CAN CONTACT COUNTRY COACH AT 1-541-998-3720.
Notes
HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
COUNTRY COACH/HOLLAND USA/STEERING GEAR PLATE
NHTSA #04V259000 · Steering · NHTSA notice
Reported June 7, 2004 · COUNTRY COACH INC
Potentially affected: 527 vehicles
Vehicles built May 1, 2004 – May 31, 2004 (per NHTSA)
Defect description
ON CERTAIN MOTOR HOMES EQUIPPED WITH AN INDEPENDENT FRONT SUSPENSION (IFS) GEN II BUILT BY HOLLAND USA, THE GEAR PLATE SUPPORT GUSSETS WERE REMOVED. THIS CAN ALLOW THE PLATE TO FLEX DURING A STATIC STEER CONDITION.
Safety consequence
THE FLEXING MAY RESULT IN STRESS CRACKING WHICH COULD POTENTIALLY CAUSE A LOSS OF VEHICLE STEERING CONTROL WHICH COULD RESULT IN A VEHICLE CRASH.
Manufacturer remedy
HOLLAND USA IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. A BOLT-ON STRENGTHENING OF THE STEERING GEAR PLATE WITH U-BOLTS CONNECTING THE CROSS MEMBER TO EACH SIDE OF THE GEAR PLATE AT THE REAR PLUS A TUBE SUPPORT IN THE FRONT WITH J-BOLTS TO THE GEAR PLATE WILL BE INSTALLED. OWNERS SHOULD CONTACT HOLLAND USA CUSTOMER SERVICE AT 1-888-396-6501 FOR INFORMATION AND INSTRUCTIONS FOR WHERE CUSTOMERS CAN TAKE THEIR VEHICLES TO HAVE THE REPAIRS DONE FREE OF CHARGE.
Notes
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
HOLLAND/INDEPENDANT FRONT SUSPENSIONS
NHTSA #04E040000 · Steering · NHTSA notice
Reported May 28, 2004 · HOLLAND USA, INC.
Potentially affected: 610 vehicles
Owners notified July 28, 2004
Defect description
HOLLAND INDEPENDENT FRONT SUSPENSIONS P/N 90547917 IFS-114 WITH THE 90547978 SUBFRAME FOR USE ON CERTAIN COUNTRY COACH VEHICLES AND SHIPPED BETWEEN MARCH 5, 2003, AND JUNE 28, 2004. EARLY IFS-114 UNITS WITH P/N 90546687 USED A DIFFERENT SUBFRAME, P/N 90546691 THAT IS NOT AFFECTED BY THIS RECALL. THE NEW SUBFRAME DID NOT HAVE GUSSETS THAT HELP SUPPORT THE STEERING GEAR MOUNTING PLATE. THE LACK OF GUSSETS ALLOWS EXCESSIVE FLEXING OF THE STEERING GEAR MOUNTING PLATE WHICH MAY LEAD TO FATIGUE CRACKS.
Safety consequence
IF A CRACK WERE TO DEVELOP AND PROPAGATE TO THE POINT WHERE THE STEERING GEAR MOUNTING PLATE WERE TO SEPARATE FROM THE SUSPENSION SUBFRAME, THEN STEERING CAN BECOME LOOSE WITH POSSIBLE LOSS OF STEERING CONTROL. A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR EVEN DEATH.
Manufacturer remedy
HOLLAND WILL NOTIFY COUNTRY COACH'S CUSTOMERS AND PROVIDE REMEDY FREE OF CHARGE. OWNER NOTIFICATION BEGAN JULY 28, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HOLLAND USA CUSTOMER SERVICE AT 1-888-396-6501.
Notes
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Other Country Coach Allure model years
Check your 2005 Country Coach Allure VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Country Coach Allure at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Country Coach VIN