NHTSA vehicle safety data

2001 Coachmen Santara Recalls & Complaints

The 2001 Coachmen Santara has 2 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Coachmen dealer.

NHTSA recall and complaint data for the 2001 Coachmen Santara. Recall data is refreshed daily from NHTSA.

2001 Coachmen Santara owner complaints

Owners have filed 2 complaints with NHTSA about the 2001 Coachmen Santara, describing incidents dated May 29, 2004 to June 20, 2004.

Most-cited components

Tires 2 complaints

Newest complaints

ODI #10098755 · Filed November 12, 2004
I HAVE A 2000 COACHMEN MOTORHOME WHICH CAME WITH MICHELIN XRV TIRES ON IT. SPECIFICALLY 235/80R 22.5. I HAVE HAD ONE TIRE BLOW OUT WHILE DRIVING AND ANOTHER TIE WAS DISCOVERED TO HAVE WHAT APPEARED TO BE A "WIDE PLY GAP" ON THE SIDEWALL SO I REMOVED IT. ON THE FIRST TIRE, WHICH BLEW OUT, I CALLED…
ODI #10079766 · Filed June 24, 2004
WHILE DRIVING AT 65 MPH CONSUMER HEARD A BUMPING SOUND FROM THE FRONT OF THE MOTOR HOME. CONSUMER THEN PULLED OFF THE ROAD TO INSPECT THE NOISE, AND FOUND THAT THE FRONT DRIVER SIDE TIRE TREAD SEPARATED. THE FRONT PASSENGER SIDE TIRE STARTED TO SHOW THE SAME SIGNS OF FAILURE. *AK

Read all 2 complaints

COACHMEN/SAMSUNG/MICROWAVES

NHTSA #03V373000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported October 14, 2003 · COACHMEN RV COMPANY, LLC

Potentially affected: 19,110 vehicles

Vehicles built May 1, 2000 – December 11, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN MOTOR HOMES, TRAVEL TRAILERS, AND FIFTH WHEEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Safety consequence

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Manufacturer remedy

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR COACHMEN AT 1-219-825-5821.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

COACHMEN/CRV GROUND WIRE

NHTSA #00V178000 · Electrical System — Wiring · NHTSA notice

Reported July 7, 2000 · COACHMEN INDUSTRIES, INC.

Potentially affected: 158 vehicles

Owners notified July 31, 2000 · Vehicles built May 2, 2000 – June 30, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: CLASS A MOTOR HOMES, MODELS 3602 AND 3500. THE 120-VOLT CIRCUIT GROUND WIRE THAT PROVIDES BONDING FROM THE POWER CENTER AND THE GENERATOR TRANSFER SWITCH TO THE FRAME WAS INCORRECTLY CONNECTED TO THE 12-VOLT GROUND BAR.

Safety consequence

THIS CAN LEAD TO HIGHER VOLTAGE WITHIN THE 12-VOLT GROUND SYSTEM AND CAUSE FAILURES IN THE INDIVIDUAL ELECTRONIC EQUIPMENT (REFRIGERATOR CONTROL, FURNACE CONTROL, RADIOS, ETC.).

Manufacturer remedy

DEALERS WILL RE-WIRE THESE MOTOR HOMES.

Notes

OWNER NOTIFICATION BEGAN JULY 31, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-219-825-5821. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2001 Coachmen Santara. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2001 Coachmen Santara.

Tires

ODI #10098755

Incident: May 29, 2004 · Filed: November 12, 2004

I HAVE A 2000 COACHMEN MOTORHOME WHICH CAME WITH MICHELIN XRV TIRES ON IT. SPECIFICALLY 235/80R 22.5. I HAVE HAD ONE TIRE BLOW OUT WHILE DRIVING AND ANOTHER TIE WAS DISCOVERED TO HAVE WHAT APPEARED TO BE A "WIDE PLY GAP" ON THE SIDEWALL SO I REMOVED IT. ON THE FIRST TIRE, WHICH BLEW OUT, I CALLED MICHELIN AND THEY WERE IMMEDIATELY DEFENSIVE. EVEN THOUGH I WAS NICE THE LADY DIDN'T LIKE MY PERSISTENCE AND HUNG UP ON ME. THE MICHELIN CALL CENTER TOLD ME THAT 70% OF MOTORHOMES ARE OVERLOADED AND THAT MINE WAS PROBABLY OVERLOADED ALSO. SHE REFERRED ME TO A DEALER IN SALT LAKE CITY. I WENT TO A DEALER WHO HAD THE MICHELIN REP LOOK AT IT. HE SAID IT WAS THE RESULT OF AN IMPACT BUT HE GAVE ME A $100 CREDIT. IN AUGUST I FOUND A BUBBLE ON ANOTHER TIRE AND TOOK IT TO A GOODYEAR DEALER WHO SAID IT LOOKED LIKE A WIDE PLY GAP AND REFERRED ME TO A MICHELIN DEALER IN THE AREA. THAT DEALER LOOKED AT IT AND SAID HE SEE THIS FREQUENTLY AND ADVISED ME TO GET THESE TIRE OFF MY RV ASAP. I COULD NOT REPLACE IT AS HE HAD QUIT STOCKING THE TIRES BECAUSE THEY WERE SO BAD. I CALLED MICHELIN AND GOT THE SAME 70% OVERLOADED STORY A FEW MONTHS LATER AND WAS REFERRED TO A LOCAL DEALER. THIS TIRE HAD NOT BLOWN OUT SO I KNEW I WOULD GET THE TIRE REPLACED AS A MANUFACTURE DEFECT. WITH NO INDICATION OF ANY IMPACT ON THE SIDEWALL OF THE TIRE THE NEW MICHELIN DEALER TOLD ME IT WAS A RESULT OF IMPACT. I OBJECTED AND HE GOT HOSTILE. AS HE HELPED ME PUT THE TIRE BACK IN THE RV HE SMASHED HIS FINGER SEVERELY: ). THAT WHAT HE GETS FOR LYING! I TALKED TO A MOTORHOME DEALER AND HE TOLD ME OF THE PROBLEMS IN THE INDUSTRY WITH MICHELIN XRV TIRES SO, I WANT THEM ALL REPLACED. *JB

Tires

ODI #10079766

Incident: June 20, 2004 · Filed: June 24, 2004

WHILE DRIVING AT 65 MPH CONSUMER HEARD A BUMPING SOUND FROM THE FRONT OF THE MOTOR HOME. CONSUMER THEN PULLED OFF THE ROAD TO INSPECT THE NOISE, AND FOUND THAT THE FRONT DRIVER SIDE TIRE TREAD SEPARATED. THE FRONT PASSENGER SIDE TIRE STARTED TO SHOW THE SAME SIGNS OF FAILURE. *AK

Other Coachmen Santara model years

Check your 2001 Coachmen Santara VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Coachmen Santara at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Coachmen VIN