NHTSA vehicle safety data

2006 Chevrolet Malibu Maxx Recalls, Ratings & Complaints

The 2006 Chevrolet Malibu Maxx has 4 NHTSA recall campaigns and 269 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2006 Chevrolet Malibu Maxx, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Chevrolet Malibu Maxx owner complaints

Owners have filed 269 complaints with NHTSA about the 2006 Chevrolet Malibu Maxx, describing incidents dated February 5, 2006 to February 1, 2025.

Most-cited components

Steering 206 complaints
Electrical System 28 complaints
Service Brakes 23 complaints
Power Train 17 complaints
Electronic Stability Control (ESC) 12 complaints
Engine 8 complaints

Of the 269 complaints on file, 12 report a crash and 1 a fire; across all 269 complaints, owners report 5 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11647569 · Filed March 11, 2025
The contact owns a 2006 Chevrolet Malibu Maxx. The contact stated that while driving at various speeds, the power steering malfunctioned, and the steering wheel became difficult to turn in either direction. During the failure, the check engine warning light illuminated. The vehicle was taken to the…
ODI #11539214 · Filed August 17, 2023
The contact owns a 2006 Chevrolet Malibu Maxx. The contact stated while driving 45 MPH, the steering wheel became firm. There was no warning light illuminated. The contact attempted to pull over, but the steering wheel was difficult to maneuver. The contact was able to pull over, shut off and…
ODI #11505829 · Filed February 6, 2023
The contact owns a 2006 Chevrolet Malibu Maxx. The contact stated that while driving at an undetermined speed and attempting to make a left turn, the steering wheel failed to turn left or right. The vehicle continued to move forward. The power steering assist fault light was illuminated. The contact…

Read all 269 complaints

Owner-reported

2006 Chevrolet Malibu Maxx mileage at failure

235 of the 269 complaints on file for the 2006 Chevrolet Malibu Maxx give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Steering	Median 85,000 miles	Middle half 60,000–115,000 miles	Based on 186 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

Sudden Loss of Electric Power Steering

NHTSA #15V064000 · Steering — Electric Power Assist System · NHTSA notice

Reported February 4, 2015 · General Motors LLC

Potentially affected: 69,633 vehicles

Repair completion: 55.68% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14772 · Owners notified February 24, 2015 · Vehicles built April 1, 2006 – June 30, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Safety consequence

If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Manufacturer remedy

GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Brake Lights may or may not Randomly Illuminate

NHTSA #14V252000 · Electrical System — Wiring · NHTSA notice

Reported May 14, 2014 · General Motors LLC

Potentially affected: 2,440,524 vehicles

Repair completion: 59.64% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 13036 · Owners notified August 18, 2014 · Vehicles built January 26, 2005 – June 9, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Safety consequence

Any of the above failure conditions increases the risk of a crash.

Manufacturer remedy

GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Transmission Shift Cable may Fracture/Rollaway

NHTSA #14V224000 · Power Train — Automatic Transmission · NHTSA notice

Reported April 30, 2014 · General Motors LLC

Potentially affected: 1,131,113 vehicles

Repair completion: 53.63% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14152 · Owners notified June 27, 2014 · Vehicles built June 25, 2003 – April 5, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.

Safety consequence

If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Manufacturer remedy

GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Sudden Loss of Electric Power Steering

NHTSA #14V153000 · Steering — Electric Power Assist System · NHTSA notice

Reported March 31, 2014 · General Motors LLC

Potentially affected: 1,373,177 vehicles

Repair completion: 60.08% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N140115 · Owners notified July 17, 2014 · Vehicles built May 24, 2005 – March 31, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Safety consequence

If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Manufacturer remedy

GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

2006 Chevrolet Malibu Maxx 5-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

269 owner complaints have been filed with NHTSA for the 2006 Chevrolet Malibu Maxx.

Steering; Engine

ODI #11647569

Incident: February 1, 2025 · Filed: March 11, 2025

The contact owns a 2006 Chevrolet Malibu Maxx. The contact stated that while driving at various speeds, the power steering malfunctioned, and the steering wheel became difficult to turn in either direction. During the failure, the check engine warning light illuminated. The vehicle was taken to the local dealer who diagnosed that the power steering assist assembly was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the NHTSA Campaign Number: 15V064000 (STEERING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 204,000.

Steering

ODI #11539214

Incident: March 17, 2023 · Filed: August 17, 2023

The contact owns a 2006 Chevrolet Malibu Maxx. The contact stated while driving 45 MPH, the steering wheel became firm. There was no warning light illuminated. The contact attempted to pull over, but the steering wheel was difficult to maneuver. The contact was able to pull over, shut off and restart the vehicle, but the failure persisted. The vehicle was not diagnosed. The dealer was not contacted. The vehicle was not repaired. The manufacturer was contacted and stated that there was no recall for the failure. The failure mileage was 241,000.

Steering

ODI #11505829

Incident: January 10, 2023 · Filed: February 6, 2023

The contact owns a 2006 Chevrolet Malibu Maxx. The contact stated that while driving at an undetermined speed and attempting to make a left turn, the steering wheel failed to turn left or right. The vehicle continued to move forward. The power steering assist fault light was illuminated. The contact had to push the vehicle off the roadway. The vehicle was taken to an independent mechanic who informed her about a power steering sensor failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 111,000.

Steering

ODI #11460929

Incident: April 1, 2022 · Filed: April 15, 2022

The contact owns a 2006 Chevrolet Malibu Maxx. The contact stated that while her husband was driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 206,203.

Steering

ODI #11442562

Incident: December 2, 2021 · Filed: December 3, 2021

The contact owns a 2006 Chevrolet Malibu Maxx. The contact stated that while pulling into a parking space, the vehicle inadvertently lost power steering functionality. The power steering warning light illuminated. The contact turned off and restarted the vehicle; however, the steering wheel remained difficult to steer. The contact was able to drive the vehicle to his residence with manual steering. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The approximate failure mileage was 140,000. Consumer stated "Failed component/part Information", it is incorrect to identify the failure in the hydraulic power assist/power steering fluid. The power steering on my car is electrical assist.

Steering

ODI #11435948

Incident: September 7, 2021 · Filed: October 7, 2021

The contact owns a 2006 Chevrolet Malibu Maxx. The contact stated that while stationary or while driving at various speeds, the power steering assist would fail to operate, and the power steering warning light would illuminate on the instrument panel. The contact stated that the steering wheel would lock as the failure occurred. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle with power steering failure. The manufacturer was also notified of the failure and informed her that there were no recalls on the vehicle. The contact was given a case number. The vehicle has been repaired. The failure mileage was approximately 180,000.

Service Brakes; Engine

ODI #11413026

Incident: July 6, 2020 · Filed: April 20, 2021

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE WOULD JERK UPON DEPRESSION OF THE BRAKE PEDAL WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO JIM KERAS CHEVROLET (2000 COVINGTON PIKE, MEMPHIS, TN 38128) WHERE THEY PERFORMED SERVICES TO THE BRAKE BOOSTER, MASTER CYLINDER, HYDRAULIC BRAKE SYSTEM, LOWER CONTROL ARMS, AS WELL AS SEVERAL OTHER UNKNOWN SERVICES. THREE WEEKS AFTER THE REPAIRS, THE VEHICLE WOULD NOT START AND THE VEHICLE WAS TOWED TO THE RESIDENCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 241,404.

Steering

ODI #11219969

Incident: June 13, 2019 · Filed: June 14, 2019

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT AS SOON AS THE VEHICLE WAS STARTED, A GRINDING NOISE BEGAN AND THE STEERING WHEEL SHOOK. THE STEERING VIBRATION CONTINUED PERMANENTLY WHILE THE VEHICLE WAS BEING DRIVEN. THE CONTACT STATED THAT THE FAILURE BEGAN EVER SINCE THE VEHICLE WAS PURCHASED IN OCTOBER OF 2018, BUT HAD BECOME WORSE OVER TIME. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Steering

ODI #11219735

Incident: June 12, 2019 · Filed: June 13, 2019

THERE WAS A RECALL FOR ELECTRIC POWER STEERING MINE WAS TAKEN CARE OFF BEFORE I PURCHASED THE VEHICLE. HOWEVER, IT LOST ELECTRIC POWER STEERING AGAIN AND IS NO LONGER UNDER RECALL WARRANTY.

Exterior Lighting

ODI #11181718

Incident: February 21, 2019 · Filed: February 21, 2019

THE PASSENGER SIDE LOW BEAM LIGHT KEEPS GOING OUT. I HAVE CHANGED THE LIGHT BUILD 3 TIMES IN THE LAST 2 MONTHS. THE LAST TIME BEING SATURDAY MORNING, THEN ON THE WAY HOME TONIGHT IT IS OUT AGAIN. LAST FRIDAY, IT WAS WORKING ON MY WAY SOMEWHERE AND THEN QUITE. ON MY WAY HOME IT STARTED WORKING AGAIN. IT DIDN'T MATTER IF I TURNED, HIT A BUMP, ETC. IT JUST GOES ON AND OFF RANDOMLY. I HAVE READ MANY MANY COMPLAINTS THAT THIS HAPPENS TO OTHERS AS WELL. I FEEL CHEVROLET NEEDS TO DO A RECALL AND FIX THIS PROBLEM FOR THE SAFETY OF EVERYONE!

Other Chevrolet Malibu Maxx model years

Check your 2006 Chevrolet Malibu Maxx VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Malibu Maxx at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN