2021 Chevrolet Blazer Recalls, Ratings & Complaints

Incident: October 8, 2026 · Filed: October 23, 2026

In February 2023 we noticed coolant on our garage floor. Car was taken to GM dealership was told radiator seams were leaking. Replaced radiator February 14th 2023 and car had 14,597 miles cost covered by GM warranty. On October 8, 2026 vehicle taken to second GM dealership for driver assist not working be careful. The cooling fan loud when car was turned off. Dealership told us the radiator was again leaking on the seams and will need third radiator (original plus two replacements). The car had 44,328 miles. Cost quoted was $2,125 plus tax and fees. Called GM service line and filed a complaint. They told me car is out of warranty and to ask dealership to give me a payment plan and/or reduce the price. After multiple calls to dealership they said they would give me a 15 percent discount as I am a loyal customer. My wife drives this car and transport two children almost daily. Worried we will lose drive assist when in use possible causing potential issues or accident.

Incident: August 8, 2026 · Filed: October 22, 2026

Torque converters are going out and causing people to need new transmissions. I was told by dealership that evaluated mine this is a known problem! I’ve also encountered others who have same issue with their cars.

Incident: October 17, 2026 · Filed: October 18, 2026

My wife and I were just driving and suddenly the motor started stopping installing. We managed to get over toward the curb and shut the motor off and restart it. Then it ran normal. When it did stall out, and we made it to the curb, it shut itself off. That was yesterday then this morning it started to do it a little bit when we left the house.

Incident: September 27, 2026 · Filed: October 15, 2026

The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving at 35 MPH, a loud cracking sound was heard and there was gray coming from underneath the hood. The contact parked the vehicle. Additionally, the steering wheel failed to turn in the intended direction. Upon opening the hood, the contact noticed gray smoke under the hood. The contact's minor child was occupying the vehicle during the failure. The vehicle was taken to an independent mechanic, where the contact was informed that the AC compressor had melted, requiring replacement of the AC kit and expansion valves. The vehicle was repaired; however, the failure recurred and the ESC warning light illuminated on the instrument panel. The contact stated that the vehicle was unsafe to drive. The contact associated the failure with an unknown recall; however, the VIN was not included in the recall. The failure mileage was unknown.

Incident: October 9, 2026 · Filed: October 9, 2026

Steering assist reduced light came on, fan kept running after shutting off, brought to dealer to see if it was covered under the gm special coverage for thermostat, they say the radiator needs to be replaced for a leak. I looked it was leaking a bit on the top driverside corner, not actively leaking but a bit of corrosion where it had. So they want to replace the thermostat(covered under gm special coverage), the fan and radiator also replaced. From what I have read online this is a known issue with these radiators leaking at the seams. People end up replacing the radiator multiple times and still leaks. How can they get away with selling these cars with junk radiators and not recalling.

Incident: June 17, 2026 · Filed: October 1, 2026

The main instrument cluster where the speedometer and fuel gauge etc etc reside went blank during operation of the vehicle. I wasn't able to pull over safely until my destination was reached. Restarting the car seemed to "solve" the issue.

Incident: September 28, 2026 · Filed: September 30, 2026

The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving at an undisclosed speed and making a turn, the vehicle lost braking functionality. The brake pedal was depressed to the floorboard. After exiting the vehicle, the contact became aware of a fluid leak underneath the vehicle. The "BRAKE Failure" warning light was illuminated. The manufacturer was notified of the failure. The vehicle was taken to a local dealer, where technicians diagnosed a fluid leak from the vacuum pump, causing the brake failure. The contact referenced NHTSA Campaign Number: 19V645000 (Service Brakes, Hydraulic) as a possible cause for the failure. However, the VIN was not included in the recall. The dealer replaced the vacuum pump, and the vehicle was repaired. The failure mileage was 120,000.

Incident: September 25, 2026 · Filed: September 26, 2026

My 2021 Chevy blazer is leaking oil at 70,000 miles Chevy only recalled under special warranty for camshaft carrier it appears Chevy put in a glue for them seals that comes off unfortunately they don’t recall all blazers just some but I am having the same issue as that special warranty. It’s a safety concern because no oil in the car can blow up the engine .6500 to repair

Incident: September 13, 2026 · Filed: September 17, 2026

Vehicle Information: 2021 Chevrolet Blazer 2.5L engine, VIN [XXX]. Odometer 118000 miles.Description of Incident: While operating the vehicle, the mechanical brake vacuum pump experienced a catastrophic internal failure. The drive gear housing shattered violently without warning, shearing off the end of the connecting engine camshaft. Because this was an instantaneous mechanical failure, the vehicles computer did not trigger any dashboard warning lights, check engine lights, or safe mode protocols prior to the failure.Safety Hazards and Component Damage: First, the total destruction of the vacuum pump caused an immediate compromise to the brake booster vacuum lines, resulting in a sudden, dangerous loss of power braking assistance. Second, the sheared camshaft breached the engine valve cover or head, causing the engines pressurized oil system to instantly dump all engine oil externally onto the ground. Third, shrapnel or violent structural torque from the instant engine seizure punctured or severed the adjacent transmission cooler fluid lines and compromised brake fluid lines, causing total loss of transmission fluid and brake fluid simultaneously.Request for Action: This failure mirrors the exact mechanical defects documented in GM Technical Service Bulletin 21-NA-268 and previous GM vacuum pump recalls like NHTSA Recall 19V-645, which excluded the 2021 Blazer. I am filing this report because the lack of an electronic warning indicator before a catastrophic mechanical brake and engine failure poses an extreme, immediate threat to highway safety. GM must expand recall coverage or issue a Special Coverage Adjustment for this model year. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 16, 2026 · Filed: September 16, 2026

My 2021 Chevrolet Blazer has experienced repeated problems involving the cooling system and is now exhibiting recurring symptoms that concern me about the vehicle’s reliability and safety. In 2023, the vehicle required a radiator/cooling-system repair. In 2024, it again required radiator/cooling-system repair, which was performed under warranty. The vehicle is now experiencing an abnormal humming/clicking noise from under the hood. The problem initially occurred primarily after rain but has become increasingly frequent. When the noise occurs, the air-conditioning system stops cooling properly and blows warm air. The check-engine light has also illuminated intermittently. The exact component currently malfunctioning is unknown. The vehicle remains available for inspection. Because the symptoms involve the engine compartment and follow multiple previous cooling-system repairs, I am concerned about the possibility of overheating, loss of proper cooling-system operation, an unexpected breakdown while driving, or another mechanical failure that could place the occupants or other motorists at risk. Authorized Chevrolet dealerships previously inspected and repaired the vehicle’s cooling system in 2023 and again in 2024. Despite those repairs, significant symptoms have returned. The current problem has not yet been definitively diagnosed, so I cannot state that the present failure is the same component previously repaired. The warning symptoms include the abnormal under-hood humming/clicking, loss of cold air from the air-conditioning system when the condition occurs, and an intermittent check-engine light. The symptoms have become more frequent over time. I am reporting this because of the recurring nature of the problem and the vehicle’s history of multiple cooling-system repairs. I request that NHTSA document and evaluate this complaint together with any similar complaints involving this model and model year.