2007 Chevrolet Aveo Recalls, Ratings & Complaints

Incident: January 1, 2025 · Filed: January 24, 2026

The airbag warning light has remained illuminated since I acquired the vehicle in January 2025. The warning light stays on continuously and does not reset. This indicates a fault in the airbag system, and I have been advised that when this light is on, the airbags may be disabled and may not deploy in a crash. The vehicle has also experienced ongoing electrical problems, including lighting failures, blown fuses, and shift-interlock malfunctions, which suggests an electrical system fault affecting multiple safety-related systems. These issues create concern that the airbag control system may be impacted by the same electrical malfunction. The vehicle has not been repaired or diagnosed by a dealer for the airbag issue. The condition is still present and the warning light remains illuminated. This failure creates a serious safety risk because the airbags may not function in the event of a collision.

Incident: October 1, 2025 · Filed: January 24, 2026

While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. The airbag warning light is also illuminated, indicating the safety restraint system may not function properly in a crash. These failures create a serious safety risk due to loss of exterior lighting, inability to shift, inability to turn the ignition off, and possible airbag malfunction. This failure is consistent with a known defect involving the Daytime Running Light (DRL) module overheating and causing electrical shorts, as documented in manufacturer recall and technical service bulletins for this vehicle. The problem has been reproduced multiple times and remains unresolved.

Incident: December 31, 2022 · Filed: January 31, 2023

The contact owns a 2007 Chevrolet Aveo. The contact was made aware of NHTSA Campaign Number: 06V398000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The contact stated that after the vehicle was involved in an accident, the vehicle lost motive power and failed to restart on various occasions. No warning lights were illuminated, and the vehicle was towed to the contact's residence. The vehicle was then towed to an independent mechanic, where it was diagnosed that the fuel pump needed to be replaced. The vehicle was repaired; however, the contact stated that the failure had reoccurred, and the vehicle failed to restart. The manufacturer was made aware of the failure. The failure mileage was unknown.

Incident: July 20, 2020 · Filed: August 2, 2021

The contact owns a 2007 Chevrolet Aveo. The contact stated while starting the vehicle, the driver’s side front air bag sensor warning light illuminated. The contact took the vehicle to an independent mechanic who inspected the vehicle and completed a diagnostic test which displayed a failure with the front driver’s side air bag. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately of 52,000.

Incident: July 10, 2021 · Filed: July 16, 2021

Out of no where it cought on fire

Incident: July 15, 2020 · Filed: July 21, 2020

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE SHUDDERED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO AN UNKNOWN ENGINE CYLINDER FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

Incident: January 30, 2020 · Filed: January 31, 2020

I HAVE PROBLEMS WITH WHENEVER I GO TO PUT GAS IN MY CAR, SOME OF IT GOES ON THE GROUND. NOT ALL OF THE GAS GOES ON THE GROUND, BUT A LITTLE LESS THAN HALF OF WHAT I PURCHASED. MY HEADLIGHTS ARE SO DIM THAT I CAN'T HARDLY SEE WHEN I'M DRIVING AT NIGHT. ALSO, MY PASSENGER SIDE AIR BAG LIGHT IS CONSTANTLY ON? THERE'S ONE THERE AND NOTHING BIGAMY WRONG WITH IT THAT I CAN SEE. THE STEREO.....ONLY THE DRIVER SIDE FRONT SPEAKER WORKS, THE OTHER THREE DOESN'T WORK AT ALL....PLEASE LOOK INTO THESE FEW THINGS OR GIVE ME SOME SORT OF IDEA OF WHAT I CAN DO

Incident: December 1, 2018 · Filed: December 6, 2018

VEHICLE HEADLIGHTS FAILED. CAR WAS PARKED IN THE DRIVEWAY. AN HOUR LATER WHEN IT WAS STARTED AGAIN, THE HEADLIGHTS FAILED TO COME ON AND REMAIN INOPERABLE. BULBS, SWITCH, AND RELAY HAVE ALL BEEN CHECKED AND VERIFIED TO BE OPERABLE.

Incident: March 22, 2010 · Filed: December 1, 2018

"TAKATA RECALL" I BOUGHT MY CAR IN 2009. ABOUT 6 MONTHS LATER THE AIRBAG LIGHT CAME ON AND THE DEALER WENT OUT OF BUSINESS. WHEN I CHECKED THE VIN NUMBER IT WAS NOT AMONG THE MANY, MANY AVEOS TAGGED FOR RECALL TO REPLACE FAULTY AIRBAG SYSTEMS. AND I'M NOT ALONE. COMPLAINTS KEEP PILING IN FROM AVEO OWNERS ABOUT THE AIRBAG SAFETY LIGHTS THAT NEVER TURN OFF, NEARLY CATCHING UP WITH 20 YEARS OF "COMPLAINTS INVOLVING TAKATA INFLATORS..." MY CAR WAS PARKED WHEN AN INDIVIDUAL BACKED INTO MY PASSENGER DOOR. THE COLLISION WAS SO SEVERE THE DOOR HAD TO BE REPLACED. YET IT TRIGGERED NO AIRBAGS. DID YOU KNOW WHILE THE AIRBAG LIGHT IS ENGAGED, THE CAR CANNOT BE SOLD? YOU THINK THIS MIGHT BE DUE TO THE FACT THAT IT INDICATES A SERIOUS PROBLEM WITH THE AIRBAG SYSTEM - THAT MOST PROMINENT FEATURE IN AVEO'S HIGHLY TOUTED "5-POINT" SAFETY RATING? SO WHAT'S ITS RATING WITHOUT AIRBAGS? OR DO WE NEED A HIGHER BODY COUNT BEFORE THE MAKERS AND SAFETY REGULATORS ARE WILLING TO TALK ABOUT THAT? NEED WE REALLY TOIL WITH THE QUESTION ABOUT WHY AMERICA LOST ITS PLACE IN THE AUTO INDUSTRY? WE NEED GO NO FURTHER THAN RIGHT HERE.

Incident: June 9, 2017 · Filed: November 7, 2018

TAMARA RECALL MY CAR COMBUSTED INTO FRAMES AFTER BEING WRECKED INTO A CURVE OF LAST YEAR OF JUNE.