NHTSA vehicle safety data
2009 Champion EZ-Trans Recalls, Ratings & Complaints
The 2009 Champion EZ-Trans has 3 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized Champion dealer.
NHTSA recall and complaint data for the 2009 Champion EZ-Trans. Recall data is refreshed daily from NHTSA.
EQUIPMENT:ELECTRICAL
NHTSA #13V422000Reported September 12, 2013 · Champion Bus, Inc.
Potentially affected: 598 vehicles
Defect description
Champion Bus is recalling certain model year 2010 American Crusader, American Coach, CTS-FE, CTS-RE, and IC Low Floor buses; and 2009-2010 Challenger and Crusader buses; and 2009-2011 Defender and EZ Trans buses; and 2010-2011 IC High Floor buses. The buses are manufactured from August 1, 2009, through May 19, 2011, and equipped with A&M Systems door headers containing model 3230 circuit boards. Voltage spikes may damage electrical components and electrical circuits, causing the circuit board to develop high resistance.
Safety consequence
High resistance may cause the board to overheat, increasing the risk of a fire.
Manufacturer remedy
Champion Bus will notify owners, and dealers will inspect the door header and replace any defective circuit board, free of charge. The recall began on October 22, 2013. Owners may contact Champion at 1-810-724-6474.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
EQUIPMENT:APPLIANCE:AIR CONDITIONER
NHTSA #10V127000Reported March 31, 2010 · CHAMPION BUS, INC.
Potentially affected: 191 vehicles
Defect description
CHAMPION BUS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2006-2010 BUSES EQUIPPED WITH TRANS/AIR AIR CONDITIONING SYSTEMS INSTALLED BETWEEN MAY 2006 AND JUNE 2009. EACH TRANS/AIR SYSTEM COMES WITH AN ELECTRICAL KIT WHICH CONTAINS A RELAY BOARD AND EC PC BOARD WHICH IF IMPROPERLY INSTALLED COULD OVERHEAT.
Safety consequence
AN ELECTRICAL FAILURE IN THE RELAY BOARD, CAN CAUSE OVERHEATING AND POSE A SERIOUS FIRE HAZARD.
Manufacturer remedy
TRANS AIR WILL NOTIFY THE OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. PLEASE ALSO SEE TRANS/AIR DEFECT REPORT 09E-042. THE SAFETY RECALL BEGAN ON MAY 19, 2010. OWNERS MAY CONTACT TRANS/AIR WARRANTY AND SERVICE DEPARTMENT AT 1-800-673- 2446.
Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
INTERIOR LIGHTING
NHTSA #09V369000Reported September 24, 2009 · CHAMPION BUS, INC.
Potentially affected: 69 vehicles
Defect description
CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 TRANSIT BUSES MANUFACTURED BETWEEN JANUARY 2003 AND AUGUST 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
Safety consequence
A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.
Manufacturer remedy
CHAMPION BUS WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON DECEMBER 11, 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR CHAMPION BUS AT 1-800-331-5761.
Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Other Champion EZ-Trans model years
Check your 2009 Champion EZ-Trans VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Champion EZ-Trans at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Champion VIN