2024 Can-Am Spyder RT Recalls & Complaints

Incident: October 23, 2026 · Filed: October 28, 2026

The contact owns a 2024 Can-Am Spyder RT. The contact stated that while driving 70 MPH, the transmission unexpectedly downshifted to fourth gear and quickly decelerated to 45 MPH. The contact stated that the vehicle was uncontrollable. Several unknown warning lights were illuminated. The contact regained control of the vehicle and the transmission shifted into sixth gear. The vehicle was driven to a safe location, and the vehicle was parked and was restarted. The contact stated that upon driving at an undisclosed speed, the failure reoccurred. The contact stated that there was an abnormally loud clunking sound coming from the vehicle. The warning lights then turned off. The contact stated that the failure had occurred immediately after the vehicle was repaired under NHTSA Campaign Number: 26V575000 (Electrical System). The contact stated that the recall repair was completed over the air. The manufacturer was contacted, and a case was filed. The failure mileage was approximately 17,070.

Incident: June 26, 2026 · Filed: August 29, 2026

Vehicle was purchased new from Yacht Club Powersports in [XXX] after remaining in its shipping crate since 2024. Yacht Club documented the pre-delivery inspection on XXX. On XXX, before leaving, the front tires visibly appeared very low. A family member and I questioned the salesperson and were told the tires were fine and the vehicle was safe to ride. I then rode more than 160 miles home. During the ride, the vehicle developed significant side-to-side steering/handlebar wobble at approximately 62-70 MPH. After arriving home, tire pressures were approximately 8 PSI left front, 9 PSI right front, and 20 PSI rear. A BRP representative later advised me that approximately 8-9 PSI front and 20 PSI rear are the pressures used when these vehicles are shipped in the crate. I corrected the pressures to 20 PSI front and 28 PSI rear, but the wobble continued. On XXX, Greenmount Motorsports inspected the vehicle, documented the tires as good, and advised it was safe to ride. Because the wobble continued, I had the vehicle transported under warranty to an authorized Can-Am dealer in [XXX] on XXX. That dealer determined both front tires were defective/out of round and replaced them under warranty. The wobble stopped after replacement. The vehicle later developed suspension fault C211A, and the rear suspension air compressor required warranty replacement. A service employee at the Festus dealership told me, in substance, that they had been replacing multiple suspension air compressors on Can-Am units, not just my vehicle. After my compressor repair, the suspension became extremely harsh and required additional dealer attention. The vehicle has also displayed U0155 loss of communication with the instrument cluster and intermittent electronic/display concerns. These events occurred with fewer than 1,500 miles. I am reporting this for possible tire, steering, suspension, compressor, and related safety-defect trends. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: April 7, 2026 · Filed: April 7, 2026

About 1 time in 5, after getting ready to ride the entire display will freeze up 30-60 seconds after beginning the trip. Most often this occurs if CarPlay is also enabled. When this happens, all functionality on the dashboard display is frozen. No speedometer, tachometer, gear indicator, CarPlay freezes, etc. Only fix is to pull over, stop the bike and wait for it to power down - then restart and hope it works the next time. I have had instances where it has failed 3 times in a row before finally working. Once it works for over 2 minutes I have not had it freeze up. The other option is to keep riding with a frozen display for about 5 minutes, then it crashes and reboots and sometimes fixes itself mid-ride. This is annoying and dangerous to lose all vehicle information like this. Have checked for firmware updates OTA and it says I'm up to date. I am not the only one this happens to, the Can-Am forums have other users with the same problem.

Incident: September 14, 2025 · Filed: September 14, 2025

DUMPING OIL ENGINE TEMP LESS THAN 300 MILES

Incident: August 1, 2025 · Filed: August 22, 2025

On [XXX] at approximately [XXX] I was riding my 2024 Can-Am Spyder RT Limited on [XXX] . Upon approaching the intersection of [XXX] and [XXX] I began to slow down as the light was changing to red. At this time, people in vehicles in the the left lane began beeping their horn and pointing at me and the motorcycle. As I looked down I saw flames shooting up my left ankle and leg and rising up under the seat where the gas tank is located. I immediately pulled the motorcycle over to the shoulder of [XXX] and got off. A truck driver passing by gave me a fire extinguisher and I was able to put the fire out without any injuries. The fire went up under the seat and under the front cowling into the instrument panel. I had it towed to Maddie's Motor Sports on [XXX] in the Town of Spencerport, NY. They contacted Bombardier Recreational Products. Inc (BRP) who asked for photos from Maddie's as well as an accident/incident report to be completed by me. I did so and turned it in to Maddie's on August 5th. Shortly thereafter, the BRP representative - Bruno Bilodeau made a decision that it was an insurance issue and not a warranty issue despite the fact that he never physically inspected the motorcycle. This motorcycle had approximately 5100 miles on it at the time of the fire and was still under the manufacture's warranty (until July 2026). In addition I purchased multiple Extended Warranties to cover the motorcycle through the majority of the length of the loan. Calls and e-mails to BRP have gone unanswered. It is my position that BRP owes me a new motorcycle or they can fix mine. Mr. Bilodeau said the fire was caused by the filler cap not being secure and he could tell by a photo that was sent to him by Maddie's because he could see where fuel ran down the side of the gas tank. He's wrong - I made sure the cap was secure after fill up - it clicks when secure and I double check. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: July 22, 2025 · Filed: July 22, 2025

Well, as prompted, I upgraded the firmware on my 2024 Spyder RT LTD last week. This week I am on a trip to the Wellsboro, PA area. Carplay has been acting flaky (no better than before the upgrade). Today however, I experienced something new. The Carplay nav side of the screen froze and the speedo side went black. The dash rebooted and the speedo was fine. This happened twice today. On the second episode the dash just froze...no reboot. After turning off the bike and returning after dinner, I didn't attach the phone and just used the basic guages without incident.