2006 BMW M5 Recalls & Complaints

Incident: August 19, 2026 · Filed: August 19, 2026

The contact owns a 2006 BMW M5. The contact stated that while opening the trunk of the vehicle, the positive terminal on the battery was fully melted and was very hot. The contact believed that the issue was a fire hazard and was lucky to have found the issue before any other damage could occur. The contact referenced NHTSA Campaign Number: 12V126000 (Electrical System) as a possible cause for the failure. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and stated that the vehicle was inspected in 2012 under the recall but had passed the inspection, and the vehicle was not repaired. The failure mileage was 97,000.

Incident: May 22, 2020 · Filed: May 24, 2020

CLEARANCE FAILURE ON S85 ENGINE TO ROD BEARINGS CAUSES OIL STARVATION. THIS IN TURN CAUSES ENGINE CATASTROPHIC FAILURE. IF DRIVING THIS WILL EFFECT POWER BREAKING, POWER STEERING AND ALL COMPONENTS REQUIRING THE ENGINE TO BE RUNNING. THIS IS A VERY COMMON ISSUE, I NOW HAVE SYMPTOMS REQUIRING A CHANGE OF ROD BEARINGS. *TR

Incident: July 24, 2017 · Filed: August 3, 2017

UPON STARTING MY CAR, I RECEIVED AN ERROR MESSAGE " FAULT IN PASSENGER RESTRAINT SYSTEM AFFECTING AIR BAGS, BELT TENSIONER OR BELT FORCE LIMITER" THE MESSAGE CONTINUES TO SHOW UP EVERY DAY.. THIS IS THE SAME ISSUE THAT HAS A RECALL IN ALL OTHER 5 SERIES MODELS FOR THIS YEAR, 2006 AND HAS A RECALL FOR THOSE VEHICLES. THIS MODEL SHOULD BE ADDED SINCE ITS THE SAME ISSUE. SEE ATTACHED.

Incident: January 26, 2017 · Filed: February 17, 2017

THE EARLY M5 WITH THE SMG (SEQUENTIAL MANUAL GEARBOX) 7 SPEED HAVE NUMEROUS TSB'S AND WARRANTY CAMPAIGNS. THE SHIFTING OF THE GEARBOX IS UP EXECUTED BY PRESSURE FROM THE HYDRUALIC PUMP THAT STORES AAPRX 80PSI IN THE ACCUMULATER. THIS ACCUMULATOR OR PUMP HAS A HI CHANCE OF FAILING AND WHEN IT DOES THE CAR SHUTS DOWN WITHOUT WARNING. MY CAR SHUT DOWN IN THE MIDDLE OF THE INTERSECTION JUST RECENTLY. AND I HAVE HAD THIS PUMP REPLACE TWICE OUT OF WARRANTY AND ONCE WITHIN WARRANTY. A MAJOR FLAW OF THE GETRAG SMG 7SPD. BMW DISCONTINUED THIS TRANSMISSION BUT CONTINUES TO RAISE PRICES ON THE REPLACEMENT PUMPS AS THEY KNOW THERE IS A HIGH TURNOVER OF REPAIRS. PLEASE VISIT THE BMW M FORUMS AS THIS TOPIC IS HEAVILY DISCUSSED

Incident: April 14, 2016 · Filed: April 14, 2016

STEERING WHEEL LOCK MALFUNCTIONS AND KEEPS STEERING WHEEL LOCKED, WILL NOT RELEASE INTERMITTENTLY.

Incident: December 7, 2009 · Filed: December 10, 2015

TL* THE CONTACT OWNS A 2006 BMW M5. THE CONTACT STATED THAT THE AIR BAG LIGHT REMAINED ILLUMINATED WHILE A PASSENGER OCCUPIED THE SEAT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BASE OF THE SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.

Incident: August 8, 2015 · Filed: August 11, 2015

THE CAR HAS AN ISSUE WITH PASSENGER AIRBAG OCCUPANCY SENSOR, WHEN SOMEONE SITS ON THE PASSANGER SEAT THE AIRBAG TURNS ON, THESE BMWS HAS MANY RECALLS FOR THIS ISSUE, FOR SOME REASON MINE DOES NOT FALL INTO THE RECALL. I HAVE SCANNED THE COMPUTER AND CONFIRMED THAT THE SENSOR IS THE ISSUE, I WOULD LIKE THIS ISSUE TO BE RECALLED ON MY CAR BECAUSE THIS A COMMON ISSUE FOR THESE, I HAVE READ MANY OTHER PEOPLE WITH THIS ISSUE, ON FORUMS, BUT A RECALL HAS NOT BEEN ISSUED, I THINK ITS IMPORTANT TO DO THIS RECALL BECAUSE IT IS NOT SAFE FOR MY PASSANGER, IN CASE SOME SORT OF ACCIDENT HAPPENS AND THE AIRBAG DOES NOT DEPLOY.

Incident: December 3, 2014 · Filed: January 21, 2015

MALFUNCTION IN PASSENGER RESTRAINT SYSTEM. WARNING MESSAGE STATING "FAULT IN PASSENGER - RESTRAINT SYSTEM AFFECTING AIRBAG, BELT TENSIONER OR BELT FORCE LIMITER" IS ACTIVATED EVERY FEW MINUTES THAT CAR IS IN DRIVE. WAS INFORMED THAT THE PASSENGER AIRBAGS WILL NOT DEPLOY IN THE EVENT OF A CRASH. DEALERSHIP INFORMED ME THAT THIS WAS NOT COVERED BY WARRANTY AND MY EXTENDED WARRANTY PROVIDER (HENDRICKS AUTOGUARD) HAS REFUSED TO HONOR ITS OBLIGATIONS BY CLAIMING THE PART IS A NON-COVERED ELECTRICAL COMPONENT. *TR

Incident: December 1, 2014 · Filed: December 15, 2014

WELL DOCUMENTED (ON THE INTERNET) PROBLEM WITH THE PASSENGER SIDE ACTIVE RESTRAINT SYSTEM FAILING, TYPICALLY DUE TO THE PASSENGER SIDE OCCUPANCY MAT. THIS PROBLEM HAS BEEN DOCUMENTED IN ALMOST EVERY MODEL MANUFACTURED SINCE 2000, BUT HAS ONLY BEEN ADDRESSED IN A FEW, SELECT, VEHICLES. THIS IS THE MOST COMMON COMPLAINT FOR THIS MODEL ON CARSAFETY.GOV AND HAS NOT BEEN ACKNOWLEDGED BY BMW OF NORTH AMERICA. THIS PROBLEM, IN ITSELF, CAN LEAD TO A VARIETY OF MALFUNCTIONS IN THE EVENT OF AN ACCIDENT CAUSING SERIOUS INJURY OR DEATH. THE PROBLEM HAS ALSO LED TO A LARGE MARKET OF "DUMMY SENSORS" BEING SOLD ON EBAY AND SIMILAR SITES, WHICH TRICK THE COMPUTER INTO THINKING THE AIRBAG SENSOR IS CORRECTLY FUNCTIONING. THESE DUMMY SENSORS DO NOT REMEDY THE PROBLEM AND CAN LEAD TO AN INCREASED RISK OF INJURY OR DEATH. SYNOPSIS: AIRBAG SYSTEM WARNING LIGHT AND RESTRAINT SYSTEM WARNING LIGHT APPEAR IN INSTRUMENT CLUSTER. IDRIVE SYSTEM READS: PASSENGER RESTRAINT SYSTEM MALFUNCTION. SEAT SENSOR MAT FOR THE PASSENGER SEAT AIR BAG DISENGAGES WHEN PASSENGER IS SEATED. THE DISENGAGING OF THE PASSENGER AIR BAG POSES A GREAT DANGER FOR THE PASSENGER DUE TO THE PASSENGER AIR BAG WILL NOT DEPLOY IN A ACCIDENT CAUSING INJURY OR DEATH. BMW IS AWARE OF THIS ONGOING PROBLEMS WITH THE M5 E60 SERIES, BUT WILL NOT ADDRESS THIS ISSUE OF SAFETY. BMW CHARGES THE OWNER UP TO 5000.00 DOLLARS TO FIX THIS SAFETY ISSUE. *TR

Incident: October 3, 2011 · Filed: November 1, 2014

TL-THE CONTACT OWNS A 2006 BMW M5. THE CONTACT STATED THAT THE HE COULD SMELL STRONG FUEL ODOR AFTER FILLING THE FUEL. THE INDEPENDENT MECHANIC DIAGNOSED THE FUEL TANK HAD A CRACK INSIDE THE PLASTIC. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000. NE