NHTSA vehicle safety data

2003 BMW K1200 S Recalls & Complaints

The 2003 BMW K1200 S has 1 NHTSA recall campaign and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized BMW dealer.

NHTSA recall and complaint data for the 2003 BMW K1200 S. Recall data is refreshed daily from NHTSA.

2003 BMW K1200 S owner complaints

Owners have filed 2 complaints with NHTSA about the 2003 BMW K1200 S, describing incidents dated May 10, 2007 to January 7, 2008.

Most-cited components

Fuel/Propulsion System 1 complaint
Power Train 1 complaint

Newest complaints

ODI #10214261 · Filed January 9, 2008
(1) EVENTS LEADING UP TO THE FAILURE: NORMAL USE OF THE VEHICLE (MOTORCYCLE), NOTHING OUT OF THE ORDINARY. THE SAME FAILURE HAS OCCURRED 3 TIMES (TWICE WITHIN THE WARRANTY PERIOD (3/36) AND ONCE OUTSIDE OF WARRANTY. (2) FAILURE AND ITS CONSEQUENCES: THE PLASTIC FUEL LINE CONNECTORS BETWEEN THE FUEL…
ODI #10191554 · Filed May 23, 2007
CLUTCH FAILURE WHILE DRIVING CAUSED A VERY DANGEROUS SITUATION. WHILE PULLING OUT OF AN INTERSECTION, THE CLUTCH ON THE 2003 BMW K1200GT MOTORCYCLE FAILED, CAUSING ME TO BE UNABLE TO PULL OUT AND ACCELERATE. ONCOMING TRAFFIC WAS FORCED TO SWERVE TO AVOID KILLING ME AND CAUSING A SEVERE ACCIDENT…

Read all 2 complaints

OIL TANK VENTILATION

NHTSA #07V066000 · Engine and Engine Cooling · NHTSA notice

Reported February 23, 2007 · BMW OF NORTH AMERICA, LLC

Potentially affected: 6,631 vehicles

Owners notified April 10, 2007 · Vehicles built April 1, 2003 – January 31, 2007 (per NHTSA)

Defect description

ON CERTAIN MOTORCYCLES, FREQUENT SHORT TRIPS PARTICULARLY DURING COLD TEMPERATURES, CAN CAUSE WATER TO ACCUMULATE IN THE OIL TANK, AND WHEN THE ENGINE IS RUNNING, ESCAPING WATER VAPOR CAN CONDENSE ON THE OIL TANK AIR BLEED VALVE. IN FREEZING TEMPERATURES, THIS WATER COULD FREEZE AND BLOCK THE AIR BLEED VALVE.

Safety consequence

IT IS POSSIBLE THAT A PRESSURE BUILD UP IN THE OIL TANK COULD CAUSE IT TO RUPTURE, ALLOWING OIL TO LEAK ONTO THE REAR TIRE. AN OIL LEAK COULD CAUSE A FIRE. OIL ON THE REAR TIRE COULD CAUSE LOSS OF CONTROL.

Manufacturer remedy

DEALERS WILL INSTALL A NEW OIL TANK CAP CONTAINING A VALVE TO PREVENT OVERPRESSURE IN THE TANK FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2003 BMW K1200 S. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2003 BMW K1200 S.

Fuel System, Gasoline

ODI #10214261

Incident: January 7, 2008 · Filed: January 9, 2008

(1) EVENTS LEADING UP TO THE FAILURE: NORMAL USE OF THE VEHICLE (MOTORCYCLE), NOTHING OUT OF THE ORDINARY. THE SAME FAILURE HAS OCCURRED 3 TIMES (TWICE WITHIN THE WARRANTY PERIOD (3/36) AND ONCE OUTSIDE OF WARRANTY. (2) FAILURE AND ITS CONSEQUENCES: THE PLASTIC FUEL LINE CONNECTORS BETWEEN THE FUEL TANK AND FUEL RAIL CRACK AND LEAK FUEL. ACCORDING TO MULTIPLE PERSONAL AT THE BMW DEALERSHIP, THIS IS A COMMON PROBLEM. (3) WHAT WAS DONE TO CORRECT THE FAILURE; I.E, PARTS REPAIRED OR REPLACED (AND IF OLD PART IS AVAILABLE): THE FACTORY (PLASTIC) FUEL LINE CONNECTORS WERE INSTALLED UNDER WARRANTY, HOWEVER, WHEN I WENT TO BUY THE REPLACEMENT CONNECTORS AT THE DEALERSHIP, I WAS TOLD I SHOULD BUY STEEL CONNECTORS, THAT THE PLASTIC ONES BREAK ALL THE TIME. YES, I HAVE THE OLD FUEL LINE CONNECTORS (FROM THE LAST REPAIR). *TR

Power Train

ODI #10191554

Incident: May 10, 2007 · Filed: May 23, 2007

CLUTCH FAILURE WHILE DRIVING CAUSED A VERY DANGEROUS SITUATION. WHILE PULLING OUT OF AN INTERSECTION, THE CLUTCH ON THE 2003 BMW K1200GT MOTORCYCLE FAILED, CAUSING ME TO BE UNABLE TO PULL OUT AND ACCELERATE. ONCOMING TRAFFIC WAS FORCED TO SWERVE TO AVOID KILLING ME AND CAUSING A SEVERE ACCIDENT. MINOR RESEARCH TURNED UP THAT THIS IS A COMMON FAILURE OF OIL LEAKING ONTO THE CLUTCH CAUSING TOTAL FAILURE. *AK THIS IS A VERY DANGEROUS SITUATION THAT SHOULD BE INVESTIGATED. THE BIKE WILL BE FIXED SHORTLY, BUT IS CURRENTLY AVAILABLE FOR INSPECTION AND ONCE FIXED, THE ORIGINAL PARTS WILL BE AVAILABLE FOR INSPECTION. PLEASE CONTACT ME AS SOON AS POSSIBLE IF YOU WOULD LIKE TO INSPECT THE MOTORCYCLE IN ITS CURRENT STATE. *AK SINCERELY, TOM VICKERMAN

Other BMW K1200 S model years

Check your 2003 BMW K1200 S VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your BMW K1200 S at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a BMW VIN