2023 BMW I4 Recalls & Complaints

Incident: August 25, 2026 · Filed: October 19, 2026

My vehicle intermittently loses drive power while being driven, suddenly and with no warning. Sometimes it drives normally, then fails repeatedly later. Before any warning appeared I had isolated instances of hesitation or power loss, but with nothing on the cluster I assumed I was misperceiving it. On August 25, 2026, the vehicle lost power four times while I was driving on the freeway and displayed a drivetrain malfunction warning for the first time. I took the car to an authorized dealer on August 28, 2026, at 60,676 miles. The dealer ran the manufacturer's diagnostic test plan, found multiple stored drive motor electronics faults, and identified rotor position sensor faults in both the front and rear drive motors. The manufacturer's own technical support was consulted and recommended the repairs. The estimate was about $17,353 to replace both sensors and service the 12V harness. It has worsened since. In early October 2026 it lost power six times within about 2.5 miles on one short trip. On October 15, 2026, it suddenly lost power on surface streets and I was nearly rear-ended. The abrupt speed reduction gave no warning to following traffic; a collision was avoided only because the other driver stopped in time. Because the failure cannot be anticipated, I cannot know whether it will occur while merging, at an intersection, or at freeway speed. I have substantially reduced my use of the car. The car was built in December 2022, within the range of a manufacturer bulletin on debris inside the electrical machine causing high voltage isolation faults, and within NHTSA Recall 25V395000, whose chronology states debris could have entered the electric drive motor during supplier production. Other owners of this model and year publicly report the same symptoms and diagnosis. The vehicle is unrepaired and available for inspection. The manufacturer has an open case but has not physically inspected it. No police or insurance inspection. No crash, fire, or injury.

Incident: July 15, 2026 · Filed: September 7, 2026

The steering wheel would suddenly become stiff (frozen or locked) during normal driving especially during turning. When it happened, I lost total control of the car causing dangerous situations on the road. A warning message appeared stating: "Changed steering effort, drive moderately and contact service center." At a BMW dealership, the problem was reproduced and confirmed. They replaced 12 Volt battery, and the car was released. The new 12 volt battery didn't help the steeling issue. After a few weeks, the steeling system completely failed. The car has to be towed to BMW dealership for repair. It was identified that the steeling issue was caused by premature failure of the BMW electronic power steering system.

Incident: May 1, 2026 · Filed: May 27, 2026

The dashboard turn signal indicators are blocked by the steering wheel unless I adjust the steering wheel to a very high position that makes driving unsafe. When the turn signals are on, there is no clicking noise like many cars have. I suggest that BMW update the vehicle software to allow the driver to adjust the location of the turn signal indicators within the digital dash display, or also include turn signal indicators in the heads-up display.

Incident: May 18, 2026 · Filed: May 24, 2026

While driving my 2023 BMW i4, the vehicle suddenly displayed multiple drivetrain and chassis malfunction warnings shortly after charging the vehicle at a ChargePoint station. The vehicle experienced a sudden loss of power/propulsion while driving, creating a serious safety concern. After stopping, the vehicle began rolling backward unexpectedly and several systems appeared to malfunction. The center display/screens became partially or fully unresponsive/blank and multiple warning messages appeared simultaneously. Due to the loss of propulsion and safety concerns, CHP assistance was required to safely move the vehicle off the roadway. The vehicle was later towed to BMW service for inspection and diagnosis. I am concerned this may involve a failure related to the electrical system, high-voltage battery system, propulsion system, drivetrain, or vehicle software. The sudden loss of power while operating the vehicle created a dangerous driving condition. The vehicle had approximately 76,000 miles at the time of the incident.

Incident: April 29, 2026 · Filed: May 3, 2026

While driving on frewway in HOV lane next to tall concrete center barrier, side collision mitigation system suddenly began to aggressively and continuously jerk steering right and left. After about 10-20 seconds this caused loss of control, with vehicle turning around 180 degrees and, during the spin, impacting the center concrete wall, causing deployment of all airbags. Traffic was very heavy, and although there were no injuries or collisons with other vehicles, the loss of control was life-threatening. This route was driven previously under exactly the same conditions (clear, dry day in HOV lane) with no problem more than 20 times. This problem occurred about two weeks after the latest BMW software update. BMW was informed and what they might do is unknown.

Incident: December 27, 2023 · Filed: April 14, 2026

On [XXX], while driving on a public highway, the vehicle shut off and came to a complete stop as I was going around a roundabout. I was in the inside lane, had just finished charging in Yuma, Az., and was just about to get back on the freeway heading back into California. Thankfully, there was no one behind me at that moment and I was able to restart the vehicle and continue driving. After arriving at my destination in Winterhaven, CA, I later saw that I had two missed calls from BMW Roadside Assistance. They called to check on my welfare as, unbeknownst to me, the vehicle sent out an alert as a result of the incident. 12/30/2023, I took the vehicle to BMW of San Diego (where I leased the car from) regarding the above mentioned incident as well as repeated Drivetrain Malfunction warnings. The vehicle had 43,770 miles on it. By 1/12/2024, the dealership informed me they could not replicate the problem, and what I found most alarming, was they could find no evidence that it ever happened. I asked if they could promise me it would not happen again, they could not. This caused me great fear for myself and for others. All they could offer was that I could file a claim with BMW of North America, which I did that same day. It was not until 3/19/2024 that BMW notified me they rejected my claim. On [XXX], as I was returning home from El Centro, CA, I received a warning message, "URGENT HIGH VOLTAGE SYSTEM CHECK UP" and directing me to the nearest service center. Again, I took the vehicle to BMW of SD, stopping to charge along the way, because the range was dropping rapidly. The mileage was 95,074, still under warranty. Again, they found nothing and made me take the car back. Ultimately, on [XXX], another alert "Range reduced: Limited charging possible. Have problem checked by the nearest service center." At BMW of El Cajon I was told that Cell Module #2 had failed and would need to be replaced, but now the car was out of warranty and my cost would be $23,366. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: March 6, 2026 · Filed: March 9, 2026

I am reporting a recurring, catastrophic suspension defect in my 2023 BMW i4 eDrive40 that results in life-threatening rear tire failure. Despite adhering to all maintenance schedules, the vehicle's rear axle geometry fails to maintain stability, leading to extreme, accelerated inner-tread wear while the center and outer tread remains healthy. Timeline of Events: Initial Incident 5/4/2025 (21,493 miles): Suffered a sudden rear tire blowout while driving due to the inner tire wall wearing down to the metal cords. The dealer (BMW of Fort Lauderdale) performed an alignment and replaced the tires on my expense. Recurring Failure 3/6/2026 (35,200 miles): Less than 14,000 miles after the dealer-certified alignment, the new rear tires have reached a catastrophic state. The inner shoulders are completely bald (2.7mm inner vs 4.8mm outer), exposing the safety protector and creating an imminent risk of a second high-speed blowout. Manufacturer Response: The authorized dealer inspected the vehicle on 3/9/26 and stated the "alignment is within factory specifications," yet they refused to address why a vehicle "in spec" is destroying safety-critical components in under 14k miles. This indicates either a fundamental design flaw in the suspension components (e.g., bushings or control arms unable to support EV weight/torque) or defective factory alignment parameters provided by BMW for this specific model. Safety Hazard & Lack of Warning: This defect is a "silent killer." The failure occurs on the innermost edge of the tire, which is physically obscured by the vehicle’s body and cannot be seen during a standard walk-around. Because this EV has no regular service intervals (like oil changes), there is no professional opportunity to inspect the inner tires. A driver has no way to predict or diagnose this before a sudden, high-speed blowout occurs. BMW claims the car is "within spec," which indicates a fundamental design flaw that makes the vehicle un-roadworthy and dangerous

Incident: February 19, 2026 · Filed: February 25, 2026

I was driving about 30 mph when I was prompted with the following error message, “Drive train fault, restart not possible, High Voltage Battery,” I was able to drive home which was about 1 mile away. I drove the car home, parked it and turned it off for 45 minutes then I attempted to turn it on but was unable to and continued to receive the same message. Side note, this vehicle was purchased from BMW Beverly Hills on 1/25/26 and not a month went by before I ran into this issue.

Incident: January 21, 2026 · Filed: January 27, 2026

The sunroof spontaneously shattered while driving on the freeway. The sun shade was closed but had it been open, the glass would have entered the cabin and potential for harm. In addition, the loud bang was a distraction and had there been more heavy traffic there was potential for accident. There was no identified object that hit the sunroof. The car was taken to the dealership for repair and inspection.

Incident: December 6, 2025 · Filed: December 24, 2025

On [XXX] in Columbia SC, my vehicle reported a drivetrain failure at approximately 1800 and advised me to pullover immediately and contact roadside assistance. I promptly parked in the safest space I could approximately within 50 yards of receiving the alert. The vehicle would no longer move once parked to include neutral. BMW roadside assistance took 48 hours to pick up and transport the vehicle to my dealer in Florence SC. I was informed of a recall on the vehicle by the dealership and advised they would not be able to diagnose and repair until they obtained a part from another dealer that allowed them to put it into neutral. Very few updates were provided by the dealership. On 23 December I was informed the vehicle was repaired and ready. I was informed the problem was with the 12 volt battery. The battery was not replaced as it was deemed to be functioning properly after the computer system was updated. I picked up the vehicle on [XXX] with my daughter to drive it 2 miles to our home. 1.5 mile after leaving the dealership the warning came on again causing my daughter to not be able to move the vehicle out of the road at an intersection. The car could not be put into neutral to move it. BMW roadside assistance informed it would be 48 hours before the vehicle could be towed despite me telling them that it was in the flow of traffic. They advised me to locate a tow truck and I would be reimbursed. I contacted USAA roadside and they were able to have a tow truck to the vehicle 3 hours after the failure. I consider this failure to be very dangerous as the vehicle cannot be placed into neutral to move it out of the flow of traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)