2001 BMW F650 GS Recalls & Complaints

Incident: June 30, 2003 · Filed: October 1, 2009

2001 BMW F650GS FRONT FORK FAILURE - WHILE RIDING ON SMOOTH ASPHALT MY MOTORCYCLE SUFFERED A CATASTROPHIC FORK FAILURE DURING DECELERATION - BRAKING CAUSING THE AXLE TO SEPARATE FROM THE FORK AND CAUSING A ONE VEHICLE COLLISION RIDING IT INTO THE ESPLANADE - WHERE THE AXLE RETAINER BOLT SECURES THE AXLE. REPAIRS COMPLETED - REPLACE BOTH UPPER FORK TUBES / RIGHT SIDE LOWER AND REBUILD COST $800 CDN OLD LOWER - FAILURE IS AVAILABLE. *TR

Incident: September 25, 2005 · Filed: August 14, 2009

I WAS INVOLVED IN A LOW SPEED <=45 MPH MOTORCYCLE CRASH WITH A MEDIUM SIZED DOG (APPROX 50 LBS) BACK IN THE FALL OF 2005. I WAS RIDING A 2001 BMW F650 WHEN THE DOG RAN OUT IN FRONT OF ME AND I COULDN'T AVOID HITTING IT. I APPROXIMATE THE SPEED OF IMPACT AROUND 45 MPH. I SUBSEQUENTLY LOST CONTROL OF THE BIKE AND SLIDE ALONG THE PAVEMENT FOR APPROX 300 FT. THE DAMAGE TO THE BIKE CONSISTED OF A BROKEN FRONT FORK AND BENT FRONT WHEEL RIM. I HAD THE BIKE REPAIRED AND INSURANCE COVERED MOST OF THE DAMAGES TO THE BIKE. I DID SUFFER A KNEE INJURY IN THE CRASH. *TR

Incident: July 1, 2002 · Filed: December 26, 2008

-MOTORCYCLE -BMW 2001 F650GS -SUNNY DAY -STRAIGHT, RURAL CITY STREET -35MPH -CROSSED RAILROAD TRACKS -60FT LATER FELT BRAKING FROM FRONT TIRE, THEN BIKE SLID OVER TO LEFT, ME TO RIGHT -PERSONAL INJURY: BROKEN COLLAR BONE, BRUISES, MEDIUM ROAD RASH, 10 HOURS AT HOSPITAL -FRONT FORK AXLE FLANGE WAS BROKEN, INTACT, FROM MAIN CYLINDRICAL SHOCK HOUSE, AS IF SOMEONE CUT THE FLANGE OUT OF THE CYLINDRICAL SHOCK. -NEW FRONT SHOCK WAS PURCHASED, AND NEW SHOCK HAS DESIGN CHANGE THAT INCLUDES A STRESS RELIEVING GUSSET. *TR

Incident: July 26, 2008 · Filed: July 29, 2008

MY WIFE'S MOTORCYCLE, A BMW F650GS SEEMED TO BE SMELLING OF GASOLINE WHILE RUNNING IT. THE LEAK WAS NOT EVIDENT IN DRIPS OR A PUDDLE SO I BEGAN TO INVESTIGATE THE BIKE WHILE CONSEQUENTLY DOING OTHER MAINTENANCE. I FOUND A PUDDLE OF FUEL UNDER THE SEAT, ON TOP OF THE FUEL SENDING UNIT AREA. UPON CLOSER INVESTIGATION I FOUND A PIN HOLE SIZED LEAK IN THE FUEL TANK ITSELF, FROM WHICH FUEL WAS SPRAYING IN A STREAM. INVESTIGATING CLOSER I FOUND THAT THERE ARE MINUTE CRACKS ON THE TOP OF THE SAME AREA, AND FUEL WAS COMING UP THROUGH THEM. *TR

Incident: January 1, 2001 · Filed: May 27, 2004

I BOUGHT A BMW MOTORCYCLE ABOUT 3 1/2 YEARS AGO. IT HAS BEEN NOTHING BUT TROUBLE. IT WAS RECALLED FOR FAULTY REAR BRAKE, SEVERAL FUEL INJECTION SOFTWARE UPGRAGES DUE TO HORRIBLE STALLING PROBLEMS, AND ON THE MESSAGE BOARD DEVOTED TO THE BMW 650 GS, I HEAR OF A NUMBER OF ADDITIONAL FAILINGS. MINE STALLED SINCE NEW, I'VE BEEN THROUGH THEIR SOFTWAR UPGRADES THAT SOMETIMES MADE THINGS BETTER AND SOMETIMES NOT. NOW IT STALLS VERY BADLY AGAIN, BUT IS OUT OF WARRANTY SO I WOULD BE FORCED TO PAY BMW'S OUTRAGEIOUS SHOP RATES TO HAVE THE PROBLEM DIAGNOSED AND FIXED. BY THE WAY, EVEN WHEN BMW WAS COMING OUT WITH SEVERAL SOFTWARE UPGRADES, THEY CONTINTUALLY DENIED THE PROBLEM. MY BIKE STALLS SO BADLY THAT I AM AFRAID TO RIDE IT FOR FEAR IT WILL STALL AT A TIME WHEN MY SAFETY WILL BE PUT IN JEOPARDY. SO, AT 3 1/2 YEARS OLD, IT HAS ONLY 4,000 MILES ON IT. THE WORST THING I HAVE HEARD OF LATE IS THAT THERE IS A PROBLEM WITH THE '01 MODELS (WHICH I HAVE) LEAKING GAS! WHAT'S NEXT?! ALL THE BIKES SHOULD BE RECALLED TO BOTH FIX THE DANGEROUS GAS LEAKS AND THE DANGEROUS STALLING PROBLEM. THE WAY MOST OWNERS ARE DEALING WITH THE STALLING IS TO DISCONNECT EMISSION CONTROL DEVICES, WHICH GREATLY IMPROVES DRIVEABILITY, BUT OF COURES THEN IT PRODUCES A LOT MORE, PROBABLY VIOLATING ALL THE POLLUTION STANDARDS. I HAVE REFUSED TO DO THAT, SO I AM STILL STUCK WITH A VIRTUALLY UNDRIVABLE MOTORCYCLE BECAUSE I WILL NOT DISCONNECT THE 02 SENSOR OR THE CHARCOAL CANNISTER JUST TO MAKE IT RUN. YET THESE ARE ABOUT THE ONLY TYPES OF FIXES THAT SEEM TO WORK. PLEASE INVESTIGATE AND DO SOMETHING ABOUT THIS. YOU CAN FIND MANY COMPLAINTS ABOUT BMW'S DEFECTS, AND THEIR LACK OF RESPONSIVENESS IN DEALING WITH THEM BY VISITING A MESSAGE BOARD AT F650.COM. THESE BIKES ARE A HAZARD TO BOTH THE ENVIRONMENT AND TO THE SAFETY OF THEIR RIDERS.*MR

Incident: December 30, 2003 · Filed: January 23, 2004

WHILE COMING TO A COMPLETE STOP THE VEHICLE STALLED INTERMITTENTLY. ONCE THE VEHICLE WAS RESTARTED IT WOULD PERFORM PROPERLY. THE DEALER COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *NM WHEN THE VEHICLE STALLED A STRONG SMELL OF GAS WAS PRESENT. *SC *JB

Incident: December 29, 2003 · Filed: December 30, 2003

YEAR 2001 BMW F650GS MOTORCYCLE. FOR NO IDENTIFIABLE REASON, THE ENGINE IDLE DROPS TO ZERO AND THE ENGINE STALLS. IF YOU KNOW TO TURN THE IGNITION SWITCH OFF THEN ON AGAIN, THE IDLE WILL BE RESTORED WHEN THE MOTORCYCLE IS STARTED.

Incident: June 15, 2002 · Filed: July 31, 2003

MIRROR ON 2001 BMW F650 GS MOTORCYCLE FOLDS BACK. STARTED ON HOT DAY. NOW FOLDS BACK AT 20 MPH. *PH

Incident: June 6, 2003 · Filed: June 6, 2003

BMW F650GSA SURGES AND STALLS. YOU CAN NEVER TELL WHEN IT'S GOING TO DO EITHER. ONE TIME I WAS IN THE REDWOOD FOREST OUT BY BOGEDA BAY CALIFORNIA AND BEFORE I KNEW IT I WAS A SURGING SO HARD I THOUGTH I WAS GOING TO BE BUCKED OFF. THE DEALER IS AWARE OF THIS PROBLEM AND SAYS THERE'S NOTHING WRONG. IF YOU KEEP AFTER THEM THEY WILL SAY TO RIDE THE MOTORCYCLE IN VERY HIGH RPM'S. I DON'T THINK THEY KNOW WHAT IT FEELS LIKE OR SOUNDS LIKE WHEN I'M DOING 25MPH AT 6000 RPMS WHICH IS JUST BELOW THE REDLINE LIMIT.*AK

Incident: June 6, 2001 · Filed: June 6, 2001

INTERMITTENTLY MOTORCYCCLE WILL STALL OUT AND DIE WHEN ACCELERATING OR DECELERATING. BUT, PROBLEM HAS REOCCURRED. *AK