NHTSA vehicle safety data

2003 BMW 330CI Recalls & Complaints

The 2003 BMW 330CI has 4 NHTSA recall campaigns and 18 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized BMW dealer.

NHTSA recall and complaint data for the 2003 BMW 330CI. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 BMW 330CI owner complaints

Owners have filed 18 complaints with NHTSA about the 2003 BMW 330CI, describing incidents dated March 18, 2004 to August 17, 2020.

Most-cited components

Air Bags 9 complaints
Electrical System 3 complaints
Structure 2 complaints
Engine 1 complaint
Exterior Lighting 1 complaint
Power Train 1 complaint

Of the 18 complaints on file, 1 reports a crash; across all 18 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11350004 · Filed August 18, 2020
THE COOLING FANS EXPLODED AFTER I STARTED MY CAR UP FOLLOWING COOLANT FLUID LEAKING OUT THE BOTTOM OF A HOSE WITH NO WARNING SIGNS SHOWING THE CAR OVER HEATING IN THE END RESULT.
ODI #11340667 · Filed July 21, 2020
IT HAS BEEN MORE THAN 8 YEARS ALL POWER RELATED TO OPENING/CLOSING THE PASSENGER DOOR INCLUDING THE HANDLE DOES NOT WORK, NOT ABLE TO OPEN THE GLOVE COMPARTMENT, NOT ABLE TO OPEN THE GAS DOOR, NOT ABLE TO OPEN THE TRUNK WITHOUT HAVING TO USE THE KEY. CONVERTIBLE TOP IS NOT WORKING. WORST OF ALL I'M…
ODI #11287754 · Filed December 8, 2019
WENT THROUGH A POT HOLE IN THE FREEWAY AND THE DRIVER SIDE DOOR AIR BAGS DEPLOYED..AIR BAG ONLY SHOW HALF FILL..MY SPEED ABOUT 60 MPH..IS THIS HOW IT WORKS. NO DAMAGED EXCEPT NEEDED WHEEL ALIGNMENT.

Read all 18 complaints

Passenger Frontal Air Bag Inflators May Explode

NHTSA #20V018000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported January 15, 2020 · BMW of North America, LLC

Potentially affected: 292,948 vehicles

Repair completion: 42.41% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified February 13, 2020 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a BMW dealer immediately.

Defect description

BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

BMW will notify owners, and dealers will replace the passenger's front air bag, free of charge. The recall began February 13, 2020. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver Frontal Air Bag Inflator May Rupture

NHTSA #15V318000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 28, 2015 · BMW of North America, LLC

Potentially affected: 419,235 vehicles

Repair completion: 33.39% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified August 19, 2016 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a BMW dealer immediately.

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began Aug 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 14V-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: On December 17, 2015 BMW removed the model year 2004 X5 3.0i and 4.4i Sports Activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Side Air Bag Inflator may Rupture

NHTSA #13V172000 · Air Bags · NHTSA notice

Reported May 2, 2013 · BMW of North America, LLC

Potentially affected: 43,204 vehicles

Owners notified August 9, 2013 · Vehicles built February 1, 2002 – December 31, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a BMW dealer immediately.

Defect description

BMW is recalling certain model year 2002-2003 325i, 325xi, 330i, 330xi sedans; 325Ci and 330Ci coupes and convertibles; 325iT and 325xiT Sports Wagons; and M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag.

Safety consequence

In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.

Manufacturer remedy

Owners are advised not to drive their vehicles until they have been repaired. BMW intends to issue initial notifications to owners informing them of the safety defect in June 2013. Once replacement parts are available, estimated for July, BMW will notify owners again to contact their dealers and schedule a replacement of the passenger air bag, free of charge. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at [email protected].

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

MASTER CYLINDER LEAK

NHTSA #07E023000 · Service Brakes, Hydraulic — Foundation Components — Master Cylinder · NHTSA notice

Reported March 29, 2007 · CARDONE INDUSTRIES, INC.

Potentially affected: 13,128 vehicles

Owners notified April 2, 2007

Defect description

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Safety consequence

LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CARDONE MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2003 BMW 330CI. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

18 owner complaints have been filed with NHTSA for the 2003 BMW 330CI.

Engine

ODI #11350004

Incident: August 17, 2020 · Filed: August 18, 2020

THE COOLING FANS EXPLODED AFTER I STARTED MY CAR UP FOLLOWING COOLANT FLUID LEAKING OUT THE BOTTOM OF A HOSE WITH NO WARNING SIGNS SHOWING THE CAR OVER HEATING IN THE END RESULT.

Electrical System

ODI #11340667

Incident: January 1, 2012 · Filed: July 21, 2020

IT HAS BEEN MORE THAN 8 YEARS ALL POWER RELATED TO OPENING/CLOSING THE PASSENGER DOOR INCLUDING THE HANDLE DOES NOT WORK, NOT ABLE TO OPEN THE GLOVE COMPARTMENT, NOT ABLE TO OPEN THE GAS DOOR, NOT ABLE TO OPEN THE TRUNK WITHOUT HAVING TO USE THE KEY. CONVERTIBLE TOP IS NOT WORKING. WORST OF ALL I'M NOT ABLE TO HAVE A PASSENGER IN THE CAR FOR SAFETY PURPOSES. DEALERS HAVE NOT BEEN HELPFUL. CAR IS LIKE NEW WITH LESS THAN 80,000 MILES.

Air Bags

ODI #11287754

Incident: November 28, 2019 · Filed: December 8, 2019

WENT THROUGH A POT HOLE IN THE FREEWAY AND THE DRIVER SIDE DOOR AIR BAGS DEPLOYED..AIR BAG ONLY SHOW HALF FILL..MY SPEED ABOUT 60 MPH..IS THIS HOW IT WORKS. NO DAMAGED EXCEPT NEEDED WHEEL ALIGNMENT.

Structure

ODI #11207519

Incident: May 12, 2019 · Filed: May 14, 2019

TL* THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT STATED THAT WHILE DRIVING AT 25-30 MPH, THE VEHICLE WENT OVER A BUMP IN THE ROADWAY AND THE ROLLOVER PROTECTION SYSTEM ACTIVATED. THE CONTACT STATED THAT THERE WAS NO ACCIDENT AND THAT THE VEHICLE DID NOT ROLLOVER. THE CONTACT STATED THAT SAFETY LEVER TO RELEASE THE ROLLOVER PROTECTION SYSTEM WAS NEVER INSTALLED IN THE VEHICLE. THE CONTACT STATED THAT THE CONVERTIBLE TOP WAS UNABLE TO BE LOWERED OR RAISED. WINSLOW BMW OF COLORADO SPRINGS LOCATED AT 5845 N NEVADA AVE, COLORADO SPRINGS, CO 80918, (719) 387-9650 WAS CONTACTED BY PHONE AND AN APPOINTMENT WAS SCHEDULE TO HAVE THE VEHICLE DIAGNOSED AND INSPECTED WHICH WAS STILL PENDING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,006.

Air Bags

ODI #11024649

Crash 1 injury

Incident: December 1, 2016 · Filed: September 20, 2017

TL* THE CONTACT OWNED A 2003 BMW 330CI. WHILE DRIVING 50 MPH, THE CONTACT SUFFERED A STROKE AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DEPLOYED AND THAT METAL FRAGMENTS STRUCK THE CONTACT IN THE MOUTH. THE CONTACT SUSTAINED INJURIES TO THE MOUTH AND LOST A TOOTH. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE WAS DESTROYED AND TOWED TO A JUNK YARD. A POLICE REPORT WAS FILED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) IN AUGUST OF 2017. THE FAILURE MILEAGE WAS APPROXIMATELY 146,000. THE VIN WAS NOT AVAILABLE.

Air Bags

ODI #11021686

Incident: June 30, 2016 · Filed: September 6, 2017

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE CONTACT RECEIVED THE NOTIFICATION IN JUNE OF 2016. THE DEALER (BMW OF EL PASO, 6318 MONTANA AVE, EL PASO, TX, 79925) STATED THAT THE PARTS WERE UNAVAILABLE FOR THE REPAIR, AND THAT THEY WOULD CALL WHEN THEY HAD PARTS AVAILABLE FOR THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED OR MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE FAILURE MILEAGE WAS APPROXIMATELY 96,000. PARTS DISTRIBUTION DISCONNECT.

Air Bags

ODI #10899623

Incident: August 30, 2016 · Filed: August 30, 2016

TL* THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V428000 (AIR BAGS) AND 15V318000 (AIR BAGS); HOWEVER, THE PARTS FOR THE RECALL REPAIRS WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. PARTS DISTRIBUTION DISCONNECT.

Air Bags

ODI #10899418

Incident: July 18, 2015 · Filed: August 30, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Air Bags

ODI #10864417

Incident: July 15, 2015 · Filed: May 11, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Air Bags

ODI #10852203

Incident: July 1, 2015 · Filed: March 29, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Other BMW 330CI model years

Check your 2003 BMW 330CI VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your BMW 330CI at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a BMW VIN