2001 BMW 325XI Recalls & Complaints

Incident: November 10, 2021 · Filed: November 10, 2021

The contact owns a 2001 BMW 325XI equipped with Primewell Tires, Tire Line: Valera Touring II, Tire Size: 205/50/R17, DOT Number: (Not Available). The contact stated that while inflating the passenger’s side front tire, air was leaking from cracks on the sidewall of the tire. The tire was not replaced. The dealer was not made aware of the failure. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Numbers: 17T013000 (Tires) and 16T017000 (Tires) however, the contact did not receive the recall notifications. The failure mileage was not available.

Incident: July 19, 2017 · Filed: July 22, 2017

I RECEIVED A RECALL NOTICE FROM BMW AND BROUGHT THE CAR IN TO THEM AT BMW O F SUDBURY, SUDBURY MA UNDER RECALL 17V-047 DRIVER'S AIR BAG MODULE ON JULY 19, 2017, BUT THEY RETURNED THE CAR WITHOUT REPLACING THE AIR BAG - THEY SAID THEY DIDN'T HAVE TO DO IT.

Incident: July 15, 2015 · Filed: May 11, 2017

I THINK I KNOW WHY THE CAR CATCHES ON FIRE SINCE MINE ALMOST DID AND I TROUBLESHOOT THE PROBLEM. THE ALTERNATOR IS NOT DISCONNECTED FROM THE BATTERY WHEN THE IGNITION KEY IS TURNED OFF AND THE CAR IS PARKED IN THE DRIVEWAY. IF THE ALTERNATOR EVER OVERHEATS FOR ANY REASON (SUCH AS THE COOLING VENT COMES LOOSE), THE PASS TRANSISTOR IN THE BUILT IN REGULATOR OF THE ALTERNATOR BEGINS TO SHORT. SINCE IT IS NEVER DISCONNECTED FROM THE BATTERY (EVEN WITH THE IGNITION KEY REMOVED) THE FIST SYMPTOM APPEARS TO BE A BAD BATTERY AS THE ALTERNATOR KILLS THE BATTERY. ESPECIALLY IF YOU REPLACE THE BATTERY WITH A NEW, FRESH ONE AND CONTINUE TO DRIVE THE CAR THE PASS TRANSISTOR CONTINUES TO SHORT MORE AND MORE (IT CHARGES THE BATTERY MORE AND MORE LEADING TO OVERCHARGING AND POSSIBLE FIRE) AND EVENTUALLY SHORTS SO BAD THAT EVEN WHEN TURNED OFF IT DRAWS SO MUCH CURRENT FROM THE BATTERY THAT IT STARTS TO CATCH FIRE. IF AT THIS POINT YOU DON'T HAPPEN TO BE THERE TO DISCONNECT THE BATTERY IT BECOMES A CASCADED FAILURE AND WILL BECOME AN ENGINE FIRE. I KNOW BECAUSE THIS IS EXACTLY WHAT HAPPENED TO ME. I WAS LUCKY ENOUGH TO CATCH IT AND FIGURED IT OUT BY MEASURING THE RESISTANCE OF THE ALTERNATOR AND WAS SHOCKED AT HOW LOW IT WAS. I REPLACED THE ALTERNATOR AND EVERYTHING HAS BEEN FINE SINCE. I STILL HAVE THE OLD ALTERNATOR IF ANYONE WANTS TO EXAMINE IT. IN MY OPINION THE ALTERNATOR SHOULD NEVER BE LEFT CONNECTED TO THE BATTERY WITH THE IGNITION KEY OFF. I JUST DON'T SEE ANY REASON FOR IT. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Incident: April 18, 2017 · Filed: April 22, 2017

SECOND REAR COIL FAILURE. FIRST WAS 4/2007 AT 39800 MI (REF ODI 10189296). EXACTLY SAME LOCATION IN COIL AS LAST TIME. CORRODED CRACKED SURFACE (>95%) INDICATES PART FAILED LONG BEFORE THE COIL END BROKE OFF AND FLEW OUT OF CAR. FINAL FAILURE WAS UNDER BRAKING. PART WAS FORCEBLY EJECTED AND COULD HAVE INJURED A BYSTANDER OR ONCOMING VEHICLE.

Incident: March 9, 2017 · Filed: March 9, 2017

I WAS LOCKED INSIDE MY CAR TONIGHT. I ENTERED MY CAR THROUGH THE UNLOCKED DRIVER'S DOOR. OTHER DOORS WERE LOCKED. STARTED ENGINE AND LEFT MY DRIVEWAY. DRIVER'S DOOR LOCKED AUTOMATICALLY. WHEN I ATTEMPTED TO EXIT MY CAR, THE DOORS WOULD NOT UNLOCK. DOOR HANDLE PULLED AS IF DISENGAGED TO ANY MECHANICAL CONNECTION OTHER THAN RETURN SPRING. I ATTEMPTED TO UNLOCK DOORS WITH THE CENTER CONSOLE SWITCH TO NO AVAIL. TURNED OFF ENGINE, REMOVED KEY AND ATTEMPTED TO UNLOCK WITH FOB TO NO AVAIL. ATTEMPTED DOOR PULL ON OTHER THREE DOORS WITH RESULTS THE SAME AS PREVIOUSLY DESCRIBED. I RETURNED HOME TO MY DRIVEWAY, PARKED THE CAR AND ATTEMPTED TO OPEN THE DOORS FROM THE INSIDE OF THE CAR WITH NO SUCCESS. I ATTEMPTED WITH THE KEY IN THE IGNITION AND ENGINE RUNNING, ENGINE OFF, KEY REMOVED FROM IGNITION, ETC. EVERY OPTION WAS ATTEMPTED. THE ONLY OPERATIONAL UNLOCK MECHANISM WAS FOR THE REAR HATCH GLASS, WHICH BECAME MY EXIT BY MY CRAWLING THROUGH THE PASSENGER COMPARTMENT. I WAS TRAPPED. THE ELECTRICAL SYSTEM FAILED AND INTERLOCKED THE MECHANICAL PULL.

Incident: August 3, 2015 · Filed: August 4, 2015

TOOK THE CAR TO BMW SERVICE CENTER AT FIELD'S BMW, NORTHFIELD, IL 60093 3 AUGUST 2015 AS SUPPLEMENTAL RESTRAINT SYSTEM LIGHT ALERT STAYS ON AND WAS ADVISED THERE IS A DANGER BUT IT IS NOT COVERED BY ANY RECALL. STATED THE AIRBAG FOR PASSENGER MAY NOT DEPLOY. BMW AND FIELD'S WILL NOT PAY FOR REPLACEMENT OR REPAIR STATING IS NOT PART OF RECENT RECALL.

Incident: June 30, 2001 · Filed: June 25, 2015

I AM THE ORIGINAL OWNER OF A 2001 BMW 325XI VEHICLE. I LIVE IN THE SOUTH. THE PASSENGER SIDE ONLY TAKATA AIRBAG WAS RECALLED BY BMW AND REPLACED WITH ANOTHER TAKATA AIRBAG. THE DRIVER SIDE AIRBAG WAS NOT RECALLED. THE PASSENGER SIDE AIRBAG IS NOT AS CLOSE TO A POTENTIAL PASSENGER, ALTHOUGH BMW CONSIDERED IT VERY NECESSARY TO RECALL, BUT THE DRIVER SIDE AIRBAG IS MUCH CLOSER TO THE DRIVER, SINCE IT IS BEHIND THE STEERING WHEEL. THIS MAKES NO SENSE. BOTH AIRBAGS SHOULD HAVE BEEN AND NOW SHOULD BE RECALLED. I FEAR FOR MY LIFE OR POTENTIAL SERIOUS BODILY INJURY. THERE HAS BEEN NO RECALL, NOR IS THERE AN OPEN RECALL ON THE DRIVER SIDE AIRBAG, STATED ON THE SAFERCAR.GOV WEBSITE, WHICH I CONSTANTLY CHECK BY USING MY VIN NUMBER. I URGE YOU TO ORDER A RECALL ON THE DRIVER SIDE AIRBAG AT ONCE. I HAVE WATCHED AND WILL CONTINUE TO WATCH THE HEARINGS. I HAVE ALSO CONTACTED MY GOVERNMENT REPRESENTATIVES AND SENATORS AND TAKEN NOTES ON THE HEARINGS. PLEASE CONTINUE YOUR THOROUGH WORK, BUT ALSO PLEASE HELP ME! UPDATED 09/10/15*LJ

Incident: September 1, 2013 · Filed: February 9, 2014

THE OEM TAIL LAMP ASSEMBLIES OVERHEAT AT THE PLUGIN PIN #3 CAUSING FIRE. THIS AFFECTS BOTH RIGHT AND LEFT TAIL LAMP ASSEMBLIES. I HAVE HAD TO REPLACE BOTH TAIL LAMP ASSEMBLIES MULTIPLE TIMES. THIS PROBLEM ALSO AFFECTS THE XENON HEADLAMP FUNCTION CAUSING THE HEADLAMPS TO FAIL, SOMETIMES BOTH HEADLAMPS AT THE SAME TIME MAKING IT DANGEROUS DURING NIGHT TIME DRIVING. *TR

Incident: October 15, 2013 · Filed: November 17, 2013

PIN NUMBER 3 ON THE TAILLIGHT BULB HOUSING BEGINS TO MELT AT THE CONNECTION POINT CAUSING ANY NUMBER OF THINGS TO HAPPEN WITH THE ELECTRICAL SYSTEM. YOU MAY EXPERIENCE FLICKERING HEADLIGHTS, LOSS OF TAILLIGHT FUNCTION, LOSS OF TURN SIGNAL FUNCTION, OR ELECTRICAL FIRE. *TR

Incident: September 20, 2013 · Filed: November 17, 2013

AFTER YOU ENTER 5TH GEAR, THE SHIFTER WILL NOT RETURN TO THE NEUTRAL POSITION AND PREVENTS ACCESS TO 3RD GEAR. THIS WILL ULTIMATELY CAUSE THE DRIVER TO DOWNSHIFT INTO THE INCORRECT GEAR CAUSING ENGINE DAMAGE, DAMAGE TO THE GEARBOX, AND/OR CAUSE AN ACCIDENT WHILE DRIVING DURING CERTAIN CONDITIONS. *TR