try.vin
Log in

NHTSA vehicle safety data

2005 Audi A4 Recalls, Ratings & Complaints

The 2005 Audi A4 has 4 NHTSA recall campaigns and 219 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Audi dealer.

NHTSA recall and complaint data for the 2005 Audi A4, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Audi A4 owner complaints

Owners have filed 219 complaints with NHTSA about the 2005 Audi A4, describing incidents dated December 8, 2004 to June 18, 2026.

Most-cited components

  • Exterior Lighting 101 complaints
  • Air Bags 54 complaints
  • Electrical System 24 complaints
  • Engine 18 complaints
  • Power Train 16 complaints
  • Fuel/Propulsion System 12 complaints

Of the 219 complaints on file, 7 report a crash and 3 a fire; across all 219 complaints, owners report 8 injuries (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #11744972 · Filed

    The contact's husband owned a 2005 Audi A4. The contact received several recall letters and cards from the NHTSA and Audi manufacturer for a Takata Air Bag recall. The contact stated that the last notification received stated that the owner could die if the recall was not completed. The contact was…

  • ODI #11634360 · Filed

    The car is completely defective,total engine, gasket,water pump,intake manifold,airbag, transmission,torque,drive shaft, universal joints,all rear axles,wheel bearing,bought at auction Aug 19,2024, $4000, the as is was so small and on the back of a sheet we did not see it,we are senior,

  • ODI #11559327 · Filed

    The airbags in our 2005 Audi A4 were recalled. We had the airbag replaced due to the recall in Audi of Stratham, 58 Portsmouth Ave, Stratham, NH 03885 in February 2023. On 12/8/23, my daughter was involved in a serious front-end collation with another vehicle. The airbags in the Audi did not deploy…

Read all 219 complaints

Owner-reported

2005 Audi A4 mileage at failure

163 of the 219 complaints on file for the 2005 Audi A4 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Exterior LightingMedian 55,000 milesMiddle half 50,000–75,000 milesBased on 86 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

Passenger Frontal Air Bag Inflator May Explode

NHTSA #18V427000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported June 22, 2018 · Volkswagen Group of America, Inc.

Potentially affected: 237,947 vehicles

Repair completion: 42.32% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 69R7 · Owners notified June 29, 2018 · Vehicles built November 11, 2004 – May 17, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2005-2008 Audi A4 Sedan, A4 Avant, S4 Avant and S4 Sedan, 2007-2008 RS4 Sedan, 2004 RS4 Cabriolet, 2007-2009 A4 Cabriolet and S4 Cabriolet, 2005-2011 A6 Sedan, 2006-2011 A6 Avant, and 2007-2011 S6 Sedan vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Audi has notified owners, and dealers will replace the passenger frontal air bag with an alternate remedy part, free of charge. The recall began June 29, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69R7. Note: This recall supersedes recalls 16V382, 17V032 and 18V004 and includes vehicles that may have had their air bag previously replaced under one of those campaigns.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Rupture

NHTSA #17V032000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported January 11, 2017 · Volkswagen Group of America, Inc.

Potentially affected: 33,421 vehicles

Owners notified March 30, 2018 · Vehicles built November 11, 2004 – May 19, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009 Audi A4 Cabriolet, S4 Cabriolet, A6 Avant, A6 Sedan and S6 Sedan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone B" above, Volkswagen is recalling certain 2005-2008 Audi A4 Avant, A4 Sedan, A6 Sedan, S4 Avant and S4 Sedan vehicles, 2007-2008 A4 Cabriolet, RS4 Sedan, S4 Cabriolet and S6 Sedan vehicles, and 2006-2008 A6 Avant and 2008 RS4 Cabriolet vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Audi will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began March 30, 2018. Owners may contact Audi customer service at 1-800-253-2834. Note: This recall has been superseded by recall number 18V427.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Rupture

NHTSA #16V382000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported June 1, 2016 · Volkswagen Group of America, Inc.

Potentially affected: 194,453 vehicles

Repair completion: 33.12% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified April 28, 2017 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2004-2008 Audi A4, and 2005-2011 Audi A6 vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Volkswagen is recalling certain model year 2004-2008 Audi A4, and 2005-2008 Audi A6 vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Volkswagen is recalling model year 2004 Audi A4 vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Audi will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Owner notification letters were mailed April 28, 2017. Owners may contact Audi customer service at 1-800-822-2834.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Water Pump may cause Failure of Timing Belt

NHTSA #14E007000 · Engine and Engine Cooling — Engine · NHTSA notice

Reported March 7, 2014 · The Gates Corporation

Potentially affected: 50 vehicles

Repair completion: 2% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified May 1, 2014

Defect description

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Safety consequence

A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

Manufacturer remedy

Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Other Audi A4 model years

Check your 2005 Audi A4 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Audi A4 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Audi VIN