NHTSA vehicle safety data

2005 R-Vision Trail-Lite Recalls & Complaints

The 2005 R-Vision Trail-Lite has no NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized R-Vision dealer.

NHTSA recall and complaint data for the 2005 R-Vision Trail-Lite. Recall data is refreshed daily from NHTSA.

2005 R-Vision Trail-Lite owner complaints

Owners have filed 2 complaints with NHTSA about the 2005 R-Vision Trail-Lite, describing incidents dated May 28, 2007 to January 5, 2016.

Most-cited components

Structure 1 complaint
Tires 1 complaint

Newest complaints

ODI #10838116 · Filed February 25, 2016
TL* THE CONTACT OWNS A 2005 R-VISION TRAIL-LITE EQUIPPED WITH UNIROYAL LAREDO HD/H TIRES, SIZE: 225/75/R16 (NA). WHILE DRIVING APPROXIMATELY 50 MPH, THE REAR PASSENGER SIDE INNER TIRE BLEW OUT AND DETACHED THE PROPANE TANK LINES. THE CONTACT OBSERVED THAT THE TREAD SEPARATED ON THE TIRE AND, AS A…
ODI #10209490 · Filed November 20, 2007
CONSUMER RV TIRE BLEW OUT AND COLLECTED WATER WHILE DRIVING IN A RAIN STORM. CONSUMER STATES THAT THE TIRES WERE INFLATED TOO MUCH SO HE REDUCED THE PRESSURE. *KB THE CONSUMER NOTICED THE RIGHT TIRE HAD BEEN RUBBING ON THE WHEEL WELL AND THAT IT HAD WORN HOLES IN THE RIGHT WHEEL WELL. 3 DAYS LATER…

Read all 2 complaints

NHTSA lists no recall campaigns for the 2005 R-Vision Trail-Lite as of November 3, 2026. New recalls can be issued at any time, so check the specific VIN at nhtsa.gov/recalls before buying.

try.vin has no NCAP crash-test rating on file for the 2005 R-Vision Trail-Lite. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2005 R-Vision Trail-Lite.

Tires

ODI #10838116

Incident: January 5, 2016 · Filed: February 25, 2016

TL* THE CONTACT OWNS A 2005 R-VISION TRAIL-LITE EQUIPPED WITH UNIROYAL LAREDO HD/H TIRES, SIZE: 225/75/R16 (NA). WHILE DRIVING APPROXIMATELY 50 MPH, THE REAR PASSENGER SIDE INNER TIRE BLEW OUT AND DETACHED THE PROPANE TANK LINES. THE CONTACT OBSERVED THAT THE TREAD SEPARATED ON THE TIRE AND, AS A RESULT, THE TIRE BLEW OUT. THE PREVIOUS NIGHT, THE CONTACT INSPECTED THE TIRES AND OBSERVED THAT THE TREADS ON ALL FOUR REARS TIRES WERE SEPARATING. THE TWO REAR PASSENGER SIDE TIRES WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE TIRES WERE NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12T019000 (TIRES). THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 44,000 AND THE TIRE FAILURE MILEAGE WAS 10,000.

Structure

ODI #10209490

Incident: May 28, 2007 · Filed: November 20, 2007

CONSUMER RV TIRE BLEW OUT AND COLLECTED WATER WHILE DRIVING IN A RAIN STORM. CONSUMER STATES THAT THE TIRES WERE INFLATED TOO MUCH SO HE REDUCED THE PRESSURE. *KB THE CONSUMER NOTICED THE RIGHT TIRE HAD BEEN RUBBING ON THE WHEEL WELL AND THAT IT HAD WORN HOLES IN THE RIGHT WHEEL WELL. 3 DAYS LATER, THE FRONT LEFT TIRE WENT FLAT DUE TO THE RUBBING ON THE WHEEL WELL. THE CONSUMER BELIEVED THERE WAS A MANUFACTURING DEFECT. THE CONSUMER STATED THERE SHOULD HAVE BEEN AT LEAST 2 INCHES BETWEEN THE WHEEL WELL AND THE TIRES, WHICH COULD HAVE BEEN ACCOMPLISHED BY USING A LONGER AXLE. THERE APPEARED TO BE NO MORE THAN AN INCH BETWEEN THE TIRE AND THE WHEEL WELL ON THE LEFT SIDE OF THE RV AND EVEN LESS ON THE RIGHT SIDE. THE CONSUMER BELIEVED THERE WAS AN ATTEMPT TO CORRECT THE PROBLEM BY USING WASHERS AND A HIGHER AIR PRESSURE THAN RECOMMENDED.*JB

Other R-Vision Trail-Lite model years

Check your 2005 R-Vision Trail-Lite VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your R-Vision Trail-Lite at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a R-Vision VIN