2020 Jayco Jay Flight Recalls & Complaints

Incident: October 30, 2022 · Filed: October 31, 2022

The contact owns a 2020 Jayco Jay Flight Travel Trailer. The contact stated that the stove became inoperable. The contact received notification of NHTSA Campaign Number: 21V840000 (Equipment) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. Parts distribution disconnect. The failure mileage was unknown.

Incident: December 6, 2021 · Filed: March 29, 2022

The contact owns a 2020 Jayco Jay Flight RV. The contact stated while using the RV and attempting to light the stove and heater, the propane gas flow stopped. The contact said that he later received a recall letter from the manufacturer regarding the propane flow issue in the RV; NHTSA Campaign Number: 21V685000 (Equipment). The contact had not taken the RV to the local dealer. The RV was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 5,000.

Incident: September 25, 2021 · Filed: December 2, 2021

After a trip from Dallas to Los Angeles, I noticed inside tire wear on the rear tires. After close inspection, found both leaf spring support brackets had separated from the frame and rear axle was ~3" shifted to the left. If we had started to make the trip back home, the axles could've come off the trailer resulting in a terrible accident. Pictures were taken and sent to Good Sam for extended warranty and Jayco was supposed to have been informed to OK the repairs. Not sure if this was done.

Incident: August 27, 2021 · Filed: August 27, 2021

The contact owns a 2020 Jayco Jay Flight trailer. The contact received notification of NHTSA Campaign Number: 21V425000 (Equipment) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Incident: August 20, 2021 · Filed: August 20, 2021

The contact owns a 2020 Jayco Travel Trailer. The contact received a recall notification for NHTSA Campaign Number: 21V425000 (Equipment) however, the dealer informed the contact that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and advised the contact that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

Incident: August 12, 2021 · Filed: August 12, 2021

The contact owns a 2020 Jayco Jayco trailer. The contact received a recall notification for NHTSA Campaign Number: 21V425000 (Equipment) however, the dealer informed the contact that they would only complete the recall repair of the vehicle in four months. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Incident: April 1, 2020 · Filed: August 12, 2021

The contact owns a 2020 Jayco Jay-Flight RV. The contact received notification of NHTSA campaign number: 21V425000 (Equipment) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was ordered but had not yet been received. The contact was unable to reach the manufacturer to determine the status of the parts order or to confirm the shipping date. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while turning on the refrigerator which runs by fuel the warning light would flash. Also, while using the stove the unit experienced low fuel pressure. The cause of the failures was not determined. The failure mileage was unknown. Invalid VIN.

Incident: August 6, 2021 · Filed: August 9, 2021

The contact owns a 2020 Jayco Jay Flight. The contact received a recall notice for NHTSA campaign number: 21V425000 (Equipment). The contact called the dealer and was informed that she had to either bring the trailer to the dealer or pay a mechanic to make a service call for the recall repair. The contact stated that she did not have the money to tow the trailer or pay to have a mechanic service the recall. The manufacturer was not made aware of the issue. The RV was not repaired. The contact had not experienced a failure. Parts distribution disconnect.

Incident: August 5, 2021 · Filed: August 5, 2021

The contact owns a 2020 Jayco Jay Flight SLX RV. The contact received notification of NHTSA campaign number: 21V203000 (Equipment), 21V179000 (Equipment) and 21V184000 (Equipment) however, the parts to do the recall repairs were unavailable. The contact called the local dealer who stated that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts Distribution disconnect.

Incident: May 11, 2021 · Filed: July 16, 2021

The contact owns a 2020 Jayco Jay Flight travel trailer equipped with a Dometic cooking stove with part number: RV1731. The contact received notification of NHTSA Campaign Number: 21V184000 (Equipment). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue but informed the contact that part was not yet available. The contact was informed that it would be another month for before parts became available. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.