2018 Jayco Eagle Recalls & Complaints

Incident: June 20, 2025 · Filed: June 22, 2025

I was troubleshooting a short in the electrical trailer brake circuit and found the cause: the wire had fallen into a crack in the frame crossmember which was chewing on it. Upon further examination, several frame stiffeners/crossmembers had cracked almost entirely through on both sides of the trailer. They cracked because during manufacturing, some goober decided it'd be a good idea to cut 95% of the web of the C-channel away to make holes 10x as large as they needed to be to run wires and slide motors. According to the original owner, he took it from IN to FL twice and I put about 3k miles on it according to my records so it only has maybe 10k miles. Looking at the amount of rust and condition of the paint compared to the rest of the underside of the camper, it looks to have been broken almost as long as the rest of the camper. This issue HAS resulted in the loss of trailer braking on a 13k lb GVWR camper. This issue does cause loss of stiffness in the frame that COULD result in excessive flex causing damage to the camper while going down the road up to catastrophic failure of the frame.

Incident: October 2, 2023 · Filed: December 30, 2023

The vehicle is a Fifth Wheel RV. Jayco Eagle HT 27.5 2018. The frame cracked, welds broke suspension/springs/equalizers where all compromised and the unit started swaying dangerously on the Interstate. Thankfully we managed to get off the highway without the unit falling over and causing catastrophic damage to us or those around us. The speed limit on the section of the highway is 80 miles an hour. Every semi that passed us almost pushed the rig over. An RV dealership in Salt Lake City still has our rig and have now finished the repairs. The Frame Manufacturer, Lippert have done most of the repairs and the dealership the rest. The rig was inspected and photographed and we have a repair report. There are many documented case of the manufacturing defect and there is an absolute danger of serious injury or death because these units have not been recalled. I can provide you with whatever detail may help to save someone else from having this happen to them.

Incident: October 1, 2021 · Filed: July 7, 2022

The contact owns a 2018 Jayco Eagle. The contact stated that the odor of propane fuel was present inside and outside of the trailer whether one or both propane tanks were opened. The cause of the failure was not yet determined. The contact received notification of NHTSA Campaign Number: 21V685000 (Equipment) however, after contacting the manufacturer, the contact was informed that the regulator numbered N-17-41 was not included in the recall. The contact indicated that the same failure listed in the recall had occurred. The failure mileage was unknown.