NHTSA vehicle safety data

2002 Harley-Davidson Flhtcu-1 Shrine Recalls & Complaints

The 2002 Harley-Davidson Flhtcu-1 Shrine has 1 NHTSA recall campaign and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Harley-Davidson dealer.

NHTSA recall and complaint data for the 2002 Harley-Davidson Flhtcu-1 Shrine. Recall data is refreshed daily from NHTSA.

2002 Harley-Davidson Flhtcu-1 Shrine owner complaints

Owners have filed 2 complaints with NHTSA about the 2002 Harley-Davidson Flhtcu-1 Shrine, describing incidents dated January 20, 2006 to July 6, 2007.

Most-cited components

Electrical System 1 complaint
Engine 1 complaint

Newest complaints

ODI #10202567 · Filed September 11, 2007
I HAVE FILED A COMPLAINT WITH THE WISCONSIN DEPARTMENT OF AGRICULTURE, TRADE AND CONSUMER PROTECTION, AND I BELIEVE THAT THEY HAVE SENT YOU A COPY OF THAT COMPLAINT. ON JULY 6, 2007 WE WERE RIDING IN THE HILLS OF TENN. WHEN THE ENGINE OF MY 2002 HARLEY- DAVIDSON FLHTCUI FIRE FIGHTER EDITION WITH…
ODI #10148248 · Filed January 20, 2006
ON 1-20-2006, I WAS OPERATING MY 2002 HARLEY DAVIDISON ULTRA CLASSIC, WHEN THE ENTIRE ELECTRICAL SYSTEM SHUTDOWN. I WAS TRAVELING AT ABOUT 50 MPH WHEN THIS HAPPENED. THE MOTORCYCLE ROLLED TO A STOP AND AFTER A FEW MOMENTS IT STARTED. ABOUT A 1/4 MILE UP THE ROAD IT HAPPENED AGAIN. I HAD BEEN USING…

Read all 2 complaints

HARLEY-DAVIDSON/FENDER TIP LIGHT

NHTSA #02V002000 · Exterior Lighting · NHTSA notice

Reported January 4, 2002 · HARLEY-DAVIDSON MOTOR COMPANY

Potentially affected: 28,949 vehicles

Owners notified January 9, 2002 · Vehicles built March 5, 2001 – October 25, 2001 (per NHTSA)

Defect description

ON CERTAIN MOTORCYCLES, THE CLIPS THAT RETAIN THE WIRING FOR THE FRONT FENDER TIP LIGHT CAN BECOME DETACHED FROM THE FENDER, CAUSING THE WIRES TO FRAY AND SHORT.

Safety consequence

THIS COULD CAUSE THE LIGHTING SYSTEM FUSE TO BLOW, LEAVING THE VEHICLE WITHOUT AN OPERATIONAL FRONT FENDER TIP LIGHT, HEADLIGHT, TAILLIGHT, RUNNING LIGHTS, AND PASSING LAMPS (IF EQUIPPED).

Manufacturer remedy

DEALERS WILL REPLACE THE FENDER TIP LIGHT WIRING HARNESS RETENTION CLIPS, AND INSPECT AND REPLACE, IF NECESSARY, ANY DAMAGED WIRING HARNESSES. OWNER NOTIFICATION BEGAN JANUARY 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2002 Harley-Davidson Flhtcu-1 Shrine. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2002 Harley-Davidson Flhtcu-1 Shrine.

Engine and Engine Cooling

ODI #10202567

Incident: July 6, 2007 · Filed: September 11, 2007

I HAVE FILED A COMPLAINT WITH THE WISCONSIN DEPARTMENT OF AGRICULTURE, TRADE AND CONSUMER PROTECTION, AND I BELIEVE THAT THEY HAVE SENT YOU A COPY OF THAT COMPLAINT. ON JULY 6, 2007 WE WERE RIDING IN THE HILLS OF TENN. WHEN THE ENGINE OF MY 2002 HARLEY- DAVIDSON FLHTCUI FIRE FIGHTER EDITION WITH 36,000 MILES HAD A CATASTROPHIC ENGINE FAILURE CAUSED BY CAM BEARING FAILURE. THE ENGINE IS JUNK AND NEEDS TO BE REMANUFACTURED. MY CONCERN IS THAT HARLEY HAS KNOWN THAT THEY HAVE A PROBLEM WITH THE TWIN CAM ENGINE BEARINGS GOING OUT AND WILL NOT STAND BEHIND THEIR PRODUCT WHICH IS A $3,600.00 REPAIR. THE BIGGER CONCERN IS THAT WE WERE ONLY GOING 25-30 MILES PER HOUR WHEN THIS HAPPENED AND I HAD ALL TO DO TO KEEP FROM CRASHING. WHAT IF WE WERE ON THE INTERSTATE DOING 70 MILES PER HOUR. WHAT KIND OF FAITH AM I GOING TO NEED WHEN I GET THE ENGINE BACK AFTER REMANUFACTURED. *TR UPDATED 12/12/07

Electrical System

ODI #10148248

Incident: January 20, 2006 · Filed: January 20, 2006

ON 1-20-2006, I WAS OPERATING MY 2002 HARLEY DAVIDISON ULTRA CLASSIC, WHEN THE ENTIRE ELECTRICAL SYSTEM SHUTDOWN. I WAS TRAVELING AT ABOUT 50 MPH WHEN THIS HAPPENED. THE MOTORCYCLE ROLLED TO A STOP AND AFTER A FEW MOMENTS IT STARTED. ABOUT A 1/4 MILE UP THE ROAD IT HAPPENED AGAIN. I HAD BEEN USING THE BIKE FOR ABOUT 16 MILES / 25 MINUTES WHEN THIS OCCURRED. THIS IS NOT THE FIRST TIME. IN NOVEMBER 12, 2005, I TOOK THE MOTORCYCLE TO THE HARLEYDAVIDISON DEALERSHIP TO COMPLAIN ABOUT THE SAME PROBLEM. THEY TOLD ME THAT THIS PROBLEM HAD NOTHING TO DO WITH THE PRIOR RECALL ON A CIRCUIT BREAKER. I WAS CHARGED $70.00 AND TOLD THEY FOUND A PINCHED WIRE. I ASKED ABOUT THE RECALL, AND THEY INFORMED ME, MY MOTORCYCLE HAD THE RECALL COMPLETED DURING A PRIOR MAINTENANCE. I BELIEVE THAT EITHER THE REPLACED CIRCUIT BREAKER IS ALSO BAD OR THERE IS A NEW PROBLEM THAT WILL CAUSE SOMEONE TO GET HURT. *NM

Check your 2002 Harley-Davidson Flhtcu-1 Shrine VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Harley-Davidson Flhtcu-1 Shrine at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Harley-Davidson VIN