2020 Chevrolet Spark Recalls & Complaints

Incident: December 29, 2024 · Filed: October 22, 2026

Two times in the last two years my vacuum pump has failed. First time it happened in Dec 2024. It happened again in July 2026. With the failure my breaks were very difficult to push to slow the vehicle down. No lights or alarms just one minute I had breaks second they weren’t working properly. Luckily I was on a high way and had time to slow down so an accident didn’t occur. First repair my partner did second I took to a local garage to fix it.

Incident: October 22, 2025 · Filed: November 4, 2025

The contact owns a 2020 Chevrolet Spark. The contact stated that while driving at 15 MPH and depressing the accelerator pedal, the vehicle lost motive power. The contact exited the vehicle, unlatched the hood, and wiggled the battery cable, and the vehicle worked as intended. No warning light was illuminated. An independent mechanic and the dealer were contacted. The vehicle was taken to the dealer and was inspected, and the contact was informed that the transmission needed to be replaced. The vehicle was then taken to an independent mechanic, where it was diagnosed, and it was determined that the battery cables needed to be replaced. The transmission was replaced; however, the battery was not replaced. The manufacturer was not notified of the failure. The approximate failure mileage was 243,656.

Incident: September 6, 2025 · Filed: October 29, 2025

The contact was a passenger in a 2020 Chevrolet Spark. The contact stated that, while the owner was driving at an undisclosed speed through an intersection, another vehicle failed to yield for a red light. As a result, the other vehicle collided with the passenger side front quarter panel of the vehicle. The air bags did deploy, which the contact held responsible for the injuries she sustained. No warning lights were illuminated. The vehicle was towed to a storage facility and deemed a total loss by the owner's insurance provider. A police report was filed, and injuries were reported. Both the driver and the contact were transported to an area hospital by EMT. The driver was treated for whiplash, back pain, and shortness of breath. The contact was treated for an injured sternum, injured left knee, injured left ankle, injured right hip, broken right hand middle finger, and whiplash. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown.

Incident: April 21, 2025 · Filed: April 21, 2025

The contact owns a 2020 Chevrolet Spark. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle was able to restart. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 38,000. The VIN was not available.

Incident: August 29, 2024 · Filed: August 29, 2024

The contact owns a 2020 Chevrolet Spark. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle lost motive power. An unknown message was displayed. The vehicle was able to restart, but the failure persisted. The vehicle was taken to the dealer, where the O2 sensor was replaced; however, the failure recurred. The vehicle was then taken to an independent mechanic, but the cause of the failure could not be determined. The mechanic performed an oil change however, the failure recurred. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,848.

Incident: September 26, 2023 · Filed: September 26, 2023

My 2020 Chevy Spark was hit from behind at a rate of 40-50 mph. The airbags did not employ. However, the vehicle that struck the car, all of its airbags deployed.

Incident: August 17, 2023 · Filed: August 27, 2023

Vehicle caught on fire from the inside somewhere towards the driver side in dash. Instrument cluster and dash completely burnt. Entire inside interior of car burnt

Incident: August 17, 2023 · Filed: August 17, 2023

The contact owned a 2020 Chevrolet Spark. The contact stated that the police department informed them that the vehicle caught on fire. The contact stated that the fire may have started under the instrument panel and air bags had deployed. The vehicle was severely burned and only the contact’s vehicle was burned. The fire department was able to extinguish the fire. A police report was filed. The vehicle was not diagnosed. No one was injured. The dealer was not contacted. The manufacturer was contacted, and a case was filed. The failure mileage was 19,000. The contact stated the vehicle has been totaled out.

Incident: June 23, 2023 · Filed: June 23, 2023

The fuel line or a component which is part of the fuel system was chewed through by a rodent and the gas was pouring out of the rear of the car. My safety was at risk because if I didn't first smell the gas and then see the dripping gas, something may have sparked and caused the car to catch on fire or explode. The problem was confirmed by the dealer who sold me the car and who repaired the problem. The problem was not inspected by the manufacturer, etc. There were no warning lights that could have warned about the problem until the tank ran dry. I did see online that there is a class action against Toyota and Honda because the wires in their cars are coated with a soy material which is attracting rodents. My 2020 Chevy Spark was purchased new. The car I had previously sat out in the same parking area for 9 years and I have never had rodents attracted to the wires or fuel system.

Incident: January 3, 2023 · Filed: January 3, 2023

The contact owns a 2020 Chevrolet Spark equipped with Kumho Tires, Tire Line: Solus TA31, Tire Size: 185/55/R15, DOT Number: Y0MBYAY1. The contact stated that the driver's and passenger's side front tires and the passenger's side rear tire had chunks of rubber separating from the tread. The vehicle was taken to an independent mechanic, who diagnosed that the driver's and passenger's side front tires and the passenger's side rear tire needed to be replaced. The tires were not replaced. The manufacturer was made aware of the failure and informed the contact that the tires were not covered under warranty. The failure mileage was 22,817.